Consumer attaching bolts on the liftgate failed prior to recall 99v‑213, when the recall was recieved consumer made an appointment for the recall to be taken care of, after repair the hinge was broken and the liftgate would not close, the dealer said the hinge was bent when the vehicle arrived to be fixed but the consumer stated that the liftgate was working fine when she took it in for repair. Nlm
1991 Plymouth Voyager body complaints
Page 2 of 3: complaints 11 to 40 of 70, newest first, as owners wrote them.
Sliding door had come off. Passenger's door won't open from outside, and driver's door will not close completely.
Driver's and passenger's doors came off due to weld failure. If the occupants were not seat belted they may have fallen out. Reoccurring problem. Manufacturer aware of problem. *ak
Poor design of passenger side door caused weak weld to break causing door to jam with fender, or it cannot be opened at all. Nlm
Recalled gas props on the rear liftgate were replaced the failed again by not remaining up when the consumer opened the liftgate. Nlm
Vehicle experiencing problem with sliding door keeps coming off. Door been repaired on three occasions, but door still keeps coming off.this can lead to someone being thrown out of vehicle if invoved in a collision.
A frame broken while crossing rail road tracks at 40 MPH. Also, caused damages to transmission. Manufacturer notified ,and informed consumer that vehicle was out of warranty and over milleage.
Vehicle experienced failure of the component on two occasions prior to notice, struts broke on the hatchback support. Mjs (99v‑213)
While driving at any speed there is some type of noise within the rubber boots. Also,door locks/speedometer are not working, and electrical wires shorted out. Dealer can't determine cause of the the problem.
Whenever vehicle is traveling uphill the light indicates hatchback is open, when its not. Dealer has not seen vehicle.
All electric power locks are going up and down, and the door ajar light stays on.
No summary
Bolt that holds the hydraulic shock absorbers on the passenger's side sheared off at the chassis mount on the liftgate, causing liftgate to come crashing down. No one was injuried when this happened. The dealer has been aware of the problem. The problem has not been corrected. *ak
It seems that chrysler mini-vans with power locks start to fail at about 6 years of age. Three friends & I have mini-vans who's passenger doors cannot be unlocked at all manually, and they won't stay unlocked. Once unlocked with the power button or key. This could easily trap a child inside in an accident. We have to hold the power lock button in the up position to even open the door from the inside. The names and addresses of my friends with the same problem are: scott & stacy hill 968 don juan # 5; colo. Spgs. Co 80909; 473-4303; '92 mini-van. Carlos & julia melendez 12570 old barn rd. Elbert, co 80106; 719‑495‑8771; '91 voyager; email: [email protected]. Merlin & zoeann holmes 1932 downing st. Colo. Spgs, co 80909; 719‑633‑7299; '90 caravan; email: [email protected]. Is this a widespread problem and has there been a recall? Thank you, annette johnson.
Paint stripping off of hood and roof of vehicle. Roof starting to rust.
While driving vehicle or if the vehicle is in park, the side door keeps falling off the hinges. The side door fell off five times.
Both driver's and passenger's side doors are falling off, and nobody can't fix them. Manufacturer states that because it is not a recall there is nothing that can be done.
While putting a stroller into the van, the bolt that holds the right rear strut to the vehicle broke, causing the hatchback to drop down suddenly. The problem has been corrected.
While opening the passenger's door the door fell off the hinge. Consumer received no inducations. Manufracturer has been contacted.
When driver opened the sliding door, the door came off the track. The problem has not been corrected.
Passenger side, center seat seat belt unhooked at the floor anchor position.
Left rear hatch strong arm which lifts the hatchback exploded, shearing cylinder rod chassis connecting stud, permitting cylinder rod to force its way under plastic finish trim/headliner into pasenger compartment, almost striking rear seat occupant.
Bolts that attach the lift-gate supports broke. T
Owner states that while driving the sliding door panel fell off, dealer had to grease up the door , owner notes that she had five kids in vehicle when this happened.
Sliding side passenger's door automatic lock locks up halfway open, resulsting in manually opening and closing door.
Occupant entered the vehicle through the sliding door, proceeded about 45 feet when the sliding door disengaged from the track.
Rear liftgate support failure.
The driver's side door welding has come loose from the hinge.
Doors coming off.
Consumer went to warm up the truck and the rear hatch exploded. Please decribe .
VIN decoder
See the problems and recalls for an exact car
Buying a used 1991 Plymouth Voyager?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history