Tl* the contact owns a 1991 plymouth voyager. The contact stated while driving at unknown speeds, the anti-lock braking system warning light illuminated on the dashboard. The dealer advised the ABS system was defective and would need to be replaced, the repair was performed on the vehicle, however, the failure recurred. The manufacturer advised they would contact the dealer but would not provide any assistance. The failure mileage was 79,000 and the current mileage was 80,000.
1991 Plymouth Voyager brakes problems
149 complaints (29% of all complaints for this car). Typical mileage when it fails: 108,000. 5 crashes reported.
- owner complaints
- 149
- of this car's complaints
- 29%
- typical mileage
- 108,000
- crashes
- 5
- recalls
- 3
Which part fails
- Antilock/traction control/electronic limited slip115
- Foundation components8
- Foundation components: master cylinder5
- Foundation components: hoses, lines/piping, and fittings5
- Antilock/traction control/electronic limited slip: ABS warning light4
- Foundation components: disc: caliper3
- Power assist: hydraulic2
- Foundation components: disc: rotor2
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Plymouth Voyager brakes problems in other years
Specific symptoms reported on the 1991 Plymouth Voyager brakes
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Service brakes, hydraulic: antilock/traction control/electronic limited slip
- What is wrong
- The ABS hydraulic control unit can experience excessive brake actuator piston seal wear causing pump-motor deterioration.
- Risk
- If this condition occurs, the ABS function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident.
- Remedy
- Dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. Also the warranty on all ABS components will be extended to 10 years or 100,000 miles (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). Owners will also be reimbursed for previous ABS component repair costs.
Recall number 96V099000 · Recall details
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
- What is wrong
- The anti-lock brake system high pressure pump may be porous which will result in brake fluid leakage.
- Risk
- Fluid leakage eventually causes the loss of both theanti-lock brake system and hydraulic assist for the brake system, resulting inincreased likelihood of brake lockup and increased stopping distances, whichcould result in a vehicle accident.
- Remedy
- Replace the ABS high pressure pump and high pressure hose if the last six digits of the bar code label on the pump are between 052300 and 059262.
Recall number 92V030000 · Recall details
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
- What is wrong
- The anti-lock brake system high pressure hose may leak or detach at its crimped end fitting resulting in the discharge of hydraulic fluid.
- Risk
- Fluid discharge eventually causes the loss of both theanti-lock brake system and hydraulic assist for the brake system, resulting inincreased likelihood of brake lockup and increased stopping distances, whichcould result in a vehicle accident.
- Remedy
- Replace the ABS high pressure hose with a hose of different design and construction.
Recall number 91V191000 · Recall details
Related investigations
Abs braking system fails
There is no summary currently available
EA94028
Abs braking system fails
There is no summary currently available
PE94024
Braking performance loss
Abs system leaks are alleged by consumers which result in complete brakefailure. Severre leaking occurs while the vehicle sits for several hoursresulting in complete loss of fluid. Leaks are appearing in both the highand low pressure lines possibly due to a faulty seal or coupling. Onecomplaint alleges fluid being forced out of brake reservoir when engine isstarted, possible pointing to a faulty check valve in the accumulator.
PE91094
Abs control failure
There is no summary currently available
PE91093
What 1991 Plymouth Voyager owners say
Most recent owner complaints, unedited.
Brake failure 1991 plymouth van ABS system failure pumps brake fluid out top fill caps while parked & runs battery down to dead also hard pedal at any time fails to stop ABS system was repaired or replaced about 1999 dash warning go on & off at any time been dealer shop 4 weeks dispute lifetime warranty for recall.
Dt*: the contact stated the brakes do not work properly. While applying pressure the pedal felt spongy and must be pumped several times before the vehicle will stop. An the federal safety agency recall, # 96v099000 was performed on the vehicle concerning, the service brakes, hydraulic: antilock however, the recall did not remedy the problem. The dealership would not offer a second repair without charge under the recall.
Brakes failed to stop and light comes on w/anti lock light chrysler replaced with another exact part from junkyard and charged me for new parts $937.59. 1.5 yrs. Later same problem occurs, this is how I learned what they had done.
Vehicle has been a source of numerous never seen before and unresolved problems especially due to the fact that it is presently located in provence (france) where parts and labor are very hard to come by.....
When coming to a stop consumer applied a lot of pressure to the brake pedal to stop the vehicle. Consumer believed this was due to manufacturer's recall 702 concerning ABS braking system.
When the brakes were applied brake pedal went to the floor, and vehicle came to a stop. Took vehicle to dealer, and dealer indicated that accumulator pressure switch needed to be replaced.
Intermittently ABS light and brake light would come on simultaneously, and cause brake loss. Vehicle been to dealer on three occasions, and they were unable to locate cause of problen. Feel free to provide any further information.
Windshield wipers fail to operate. Seat belts are a problem. Problem with brakes.
While applying brakes, pedal goes half way to the floor and ABS brake light appears on the dashboard.*ak a certified mechanic informed consumer that they understood the fact that there have been recalls (the federal safety agency campaign id # 96v099000) on certain models of the plymouth voyagers. Speedometer failed and was replaced.
Questions about the 1991 Plymouth Voyager brakes
Does the 1991 Plymouth Voyager have brakes problems?
Owners have filed 149 complaints about the brakes of the 1991 Plymouth Voyager, 29% of all its complaints, more than any other problem.
At what mileage do 1991 Plymouth Voyager brakes problems start?
The typical (median) mileage in owner complaints is 108,000 miles.
Was there a recall on the 1991 Plymouth Voyager brakes?
Yes, 3 recalls: 96V099000, 92V030000, 91V191000. Check your VIN to see if your car still needs the free repair.
What year does the Plymouth Voyager have bad brakes?
The Plymouth Voyager model years with the most brakes complaints are 1993 (170 complaints), 1992 (162 complaints) and 1991 (149 complaints).
Other 1991 Plymouth Voyager problems
Seat belts 102Body 70Transmission 48Engine 35Visibility 29Steering 27Fuel system 23Locks 21Electrical 19Acceleration 10Airbags 10Lights 9Seats 8Suspension 8Tires 4Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 1991 Plymouth Voyager?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history