Fuel sensor failure warning w/ accompanying check engine light. Fuel gauge non-functional. I ran code on it (forget the exact code) but YouTube mechanic showed how to fix by changing out the Fuel Sensor, which I did. Engine light went away. Been fine for a month and a half. It's now back to doing it again. Fuel Sensor Failure. I can't keep replacing these things, we're on a tight budget. I don't want to run out of gas somewhere due to not knowing how much I have.
2015 Ram 1500 fuel system complaints
Page 4 of 9: complaints 71 to 100 of 239, newest first, as owners wrote them.
Good morning! I own a 2015 Ram Ecodiesel. I am not the original owner. I am in California. The truck is not under warranty and the FCC will not help me nor the dealership. A few months ago I was towing my horses in a trailer and the truck started to lose acceleration, started to over heat, black smoke was coming out from under the hood, and it almost lost power going up a hill. It was very scary and it almost caused an accident and my horses were terrified. I barely got it to drive up the hill and pulled over to safe place. The truck was smoking black smoke, smelled terrible, and we felt in danger. I took truck to dealership in San Luis Obispo CA. It was diagnosed with a bad intake manifold, bad fuel lines, bad egr cooler. The estimate in costs was about $7,000. Luckily my husband is a mechanic and he performed the repairs. Than the truck was back up and running, no more black smoke, and it sounded better. On [XXX] I was hauling my horses and small only 2 horse trailer, same trailer, it’s small, not oversized or too big for my truck….. the truck started to lag, lose acceleration and drive slow, then it started a knocking sound….. then a high pitch noise….. this was terrifying as we were on a very busy freeway. I pulled over and the engine started to smoke and make horrible noises like knocking and high pitch screeches. My husband and I and our two horses were once again stranded with a broken down truck. This time on a very busy freeway, highway [XXX] in California. The truck was towed to the dealership that day. We were stranded for hours with horses and no water on side of a freeway. The truck was diagnosed by Santa maria, CA dodge ram Chrysler with a blown up engine, that must be completely replaced. The repair is $20,000 or more. This is a common issue in these trucks. This truck is dangerous and needs to be recalled and taken off the road. All of these engines are bad and they should all be bought back. They were ruined after the emissions scandal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFOR
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated while driving approximately 55 MPH, the vehicle lost motive power and was jerking before downshifting to 2nd gear. The lightning bolt symbol was displayed, and the check engine warning light was illuminated. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was diagnosed but was not repaired. The approximate failure mileage was 115,000. VIN tool confirms parts not available.
The reason for the submission is regarding the unresolved safety recall, the federal safety agency Recall Number22V-406. Recall StatusRecall Incomplete, remedy not yet available Summary Some 2014-2020 MY Jeep Grand Cherokee vehicles equipped with a 3.0L diesel engine may have been built with a high pressure fuel pump ("HPFP") that could fail prematurely. A HPFP failure may introduce internally failed component debris into the fuel system potentially causing fuel starvation. Safety Risk Fuel starvation may result in an unexpected loss of motive power, which can cause a vehicle to crash without prior warning.
The contact owns a 2015 Ram 1500. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway however, the vehicle was not able to be restarted. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the high-pressure fuel pump. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel), but the VIN was not included. The manufacturer was notified of the failure but did not assist. The failure mileage was unknown.
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
driving about 60 mph in rainy eavnivg when saddenly car start shaking beadly and almost lost control lost power and slowly got home and connect scaner witch shows code for crankshaft position sensor A circuit range/performance P0336
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated while driving approximately 60-80 MPH, the vehicle went into LIMP Mode and the speed was reduced. A message indicating that the engine would shut down after 170 miles was displayed. The vehicle was taken to the dealer, where it was diagnosed that there were metal shavings in the high-pressure fuel pump. The dealer determined that the fuel system needed to be replaced. The contact stated that the dealer only replaced the fuel rails, and the failure recurred on the same day of the repair. The vehicle was towed to the dealer, where an unknown repair was performed; however, the failure persisted. The vehicle was taken to a second dealer, Monahan’s Chrysler Dodge Jeep Ram (403 E Interstate 20. Monahan’s, TX 79756), where the Diesel Exhaust Fluid (DEF) pump was replaced; however, the failure persisted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, and several cases were opened. There was no further assistance provided. The failure mileage was approximately 70,000. VIN tool confirms parts not available.
The contact owns a 2015 Ram 1500. The contact stated the vehicle was included in the federal safety agency Campaign Number: 20V475000 (Engine and Engine Cooling). After the recall remedy was completed, the vehicle went into LIMP Mode, while driving approximately 10-15 MPH. The vehicle then started to jerk. An unknown warning light illuminated, and the check engine warning light illuminated. The vehicle was taken back to the same dealer that completed the recall repair and the contact was informed that the tone wheel and crank sensor had failed and needed to be replaced. The contact also received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact that the repair was not covered under the recall. The manufacturer also informed the contact that the vehicle was no longer under warranty. The approximate failure mileage was 96,000. VIN tool confirms parts not available.
On August 27, 2023, on my home my 2015 RAM 1500 Eco Diesel lost all power at 70 mph and the "Electronic Throttle Control" light came on. I was able to get my truck home in "limp mode" and had it towed to the dealership the next day (August 28, 2023). Two weeks later, the dealership called and said that my truck had "fuel contamination" because there were "shavings and rust" in my fuel filter housing and it would cost $21k to replace the entire fuel system. I asked for a more thorough diagnostic because there is the open recall (Z46) on the vehicle related to the high-pressure fuel pump that will leave debris in the system. They then claimed that a "Stalantis engineer" looked at it and put a restriction on the vehicle to not be covered under recall warranty due to "fuel contamination." I asked for a detailed diagnostic report which they could not provide. I then filed a claim through Stalantis and went through a 2-month process and 4 different case managers who ultimately claimed that they couldn't cover it because of the fuel contamination restriction. So, I then filed an insurance claim who did their own investigation, including collecting a fuel sample from the truck tank, investigating the last fuel station I used, and interviewing the dealership. They concluded that the issue was due to the recall (specifically, the fuel pump leaving debris in my fuel system) and was NOT external fuel contamination. They also claimed that the dealership would not provide a diagnostic report. Consequently, this could not be covered as an insurance claim and should be covered under vehicle warranty. All that said, I have no other option but to file this complaint as Stalantis has not been willing to even consider covering the vehicle despite the open recall, and an independent investigation. It is also my understanding that there is no approved fix for this recall, however I've been without a vehicle or a path forward for 3-months and feel Stalantis owes its customers a solution.
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2015 RAM 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Took my truck in for engine light. Was told unfixable recall and they can’t give me vehicle back. That vehicle is my life. Without it I am unable to do what I need to do.
The contact owns a 2015 Ram 1500. The contact stated while her husband was driving approximately 65 MPH, the vehicle lost motive power. There was no warning light illuminated. The contact's husband was able to veer to the side of the road. The vehicle was towed to the local dealer, where it was diagnosed and the failure was related to the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel); however, the dealer informed the contact that the vehicle could not be repaired under the recall because the vehicle was missing an EGR. The vehicle was towed to an independent mechanic, where the high-pressure fuel Pump (HPFP) was replaced; however, the failure persisted. The vehicle was towed to a second dealer, Capital Chrysler Dodge Jeep Ram of Indian Trail (5501 W Hwy 74, Monroe, NC 28110), who inspected the vehicle and informed the contact that the EGR system had been removed. The dealer contacted the manufacturer and later informed the contact the vehicle could not be repaired under the federal safety agency Campaign Numbers: 22V406000 (Fuel System, Diesel), 20V475000 (Engine and Engine Cooling) or 19V757000 (Engine and Engine Cooling) because the EGR system was missing. The vehicle was not repaired. The failure mileage was approximately 106,000.
While driving on the highway between Nenana and Fairbanks, AK, on August 9, 2023, I attempted to pass a slow moving RV towing a trailer. While in the passing lane, I accelerated and my vehicle suddenly loss power. I was forced to swerve out of the passing lane to avoid a collision with with oncoming traffic and the vehicle being passed. After that event, the vehicle would not exceed 3000rpms or 35mph up hills. Immediately after the event, the service engine light came on and the dash showed engine error codes. I took the vehicle to the dealer (Gene's Chrysler in Fairbanks Alaska). After inspection, they indicate that the magnetic surface of the engine tone wheel was delaminating and this initiated the sensor to cause a "limp mode" (mode that limits vehicle's speed). After that event, the vehicle also had trouble starting as though it was not receiving sufficient fuel. The dealer indicated that my vehicle's vin was not covered under the recall even though the problem matched the federal safety agency campaign number: 23V411. Stellantis’ own number for this recall is 66A. This recall is an expansion of recall 20V475. I feel that my vehicle needs to be added to this recall. Without my vehicle covered under this recall, my family is incurring the costs of a rental car until the new part arrives. The vehicle was dropped off at the dealer on August 23. The part is delayed and expected on October 15 (nearly a two month wait because of a vehicle defect that effects safety). The dealer indicated my vehicle is unsafe to drive. Why isn't my vehicle part of this recall? It is clearly the exact problem identified in the recall notice.
The contact owns a 2015 Ram 1500. The contact stated that while driving at 65 MPH, the vehicle lost motive power. The vehicle was not able to be restarted. The vehicle was towed to an independent mechanic where the high-pressure fuel pump needed to be replaced. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure but was unable to confirm when part would be available. The failure mileage was 163,000. VIN tool confirms parts not available.
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle failed to start. The vehicle was towed to an independent mechanic and diagnosed with fuel system failure. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 115,000. VIN tool confirms parts not available.
Component: front fuel tank strap frame "t-slot" bracket corroded to the point where metal won't hold the load of the fuel tank and front fuel tank strap is detached causing the fuel tank to drop. Safety concerns: if the fuel tank were to drop and contact the ground, the fuel tank may detach from the vehicle causing engine stall, and in the event of crash, the fuel tank may not remain secured to the vehicle, possibly causing a fuel leak, fuel leak increase the risk of a fire. This problem was documentet on recall # 18v160000 and my vehicle has exact condition (corrosion causes fuel tank strap frame bracket to break allowing fuel tank to drop) but for some reason my vehicle it is not included in this recall. No inspection by official authorities was performed on my vehicle as of this time - at the sam time I don't feel safe to drie this vehicle in this condition. This occured recently without any warning signs.
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who related the failure to the federal safety agency campaign. The failure mileage was 136,000. VIN tool confirms parts not available.
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that on several occasions while driving at undisclosed speeds, the vehicle hesitated. No warning lights were illuminated. An undisclosed dealer was contacted and confirmed that parts were not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms parts not available.
The vehicle has experienced multiple Turbo underboost code causing the vehicle to be put into limp mode without any explanation, Rhyme or Reason. The vehicle once this code is tripped places the vehicle into limp mode at which time virtually all power is lost this is now happened three different times with no explanation completely randomly the last time was when pulling a trailer uphill resulting in a near crash experience and being stranded on the side of the highway I had to force reset the computer by cycling the ignition to get the code to go away there was no problems prior to this code popping up or after. When this occurs it can be extremely dangerous when at highway speeds considering that the vehicle goes into limp mode and you're no longer able to go more than 10 miles an hour let alone if you're pulling a trailer it's virtually impossible to move the vehicle and if you're going uphill on a two-lane Highway with fully loaded 18 wheelers behind you at 65 mph and you all of a sudden come to a crawl you can see how this poses a major risk for injury or accident
I was pulling out from my street that connects to a two lane highway. From my street you can see if cars are coming from quite a distance away. There was a semi truck in the distance going east bound in the direction I needed to torn into. There was absolutely enough room for me to merge out into the east bound lane without the semi truck even being affected. I was now about a 1/4 mile down the road and the semi was still aways back. Then, my truck started to sputter and not accelerate and as this a two lane road there at this point was nowhere to pull over. The semi was now coming up quick due to loss of power in my truck. I turned on my hazards by this time he was close and had to make an evasive lane change to avoid running into the back of me. Luckily, there was no on coming traffic. This is not the first incident of my truck losing power and almost being rear-ended. I purchased the truck from a dealer in December of 2022. They have not been of any help, and frankly they are not willing to do a thing to help. I'm at a loss and have no idea what to do. I feel I was sold a truck with a potentially dangerous recall that can cause a major car accident which could result in death. There is no resolve for this recall at this time. This recall not only puts my family at risk, it endangers the general public.
The contact owns a 2015 Ram 1500. The contact stated while driving 70 MPH, the vehicle lost automotive power and there was no warning light illuminated. The contact pulled over to the side of the road. The vehicle was towed to the dealer, where the high-pressure fuel pump (HPFP) was replaced; however, several months later, the failure recurred. The contact later received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The vehicle was then towed to Marion Chrysler Dodge Jeep Ram (44 Worley Rd, Marion, NC 28752) where it was diagnosed that the high-pressure fuel pump (HPFP) needed to be replaced a second time. The dealer confirmed that the part to do the recall repair was not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 70,999. VIN tool confirms parts not available.
High pressure fuel pump may fail prematurely. Recall dated June 9, 2022 and after more than a year there is still no remedy.
While moving to south carolina I noticed that something was hanging, a wire or some typ if line, as I crawled under the truck, I found that it was the fuel tank strap. The strap had pulled out from the frame that was corroded. I have always washed the under carriage coming from massachussetts and the road salt. At the present time I am using a tie down strap to secure in place. Searching the internet, I found that there is some type of recall but never recieved anything in writting.
high pressure fuel system completely replaced after recall and it broke down again with same symptoms.
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated while driving 45 MPH, the vehicle lost motive power. The contact was able to pull into his driveway. Several unknown warning lights were illuminated. The contact stated that the vehicle failed to start as needed. The local dealer was contacted and advised the contact that the vehicle was unsafe to drive. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 170,000. VIN tool confirms parts not available.
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated on several occasions while driving the vehicle "Exhaust Filter Full" message was displayed and the vehicle lost motive power. The vehicle was taken to the local dealer who diagnosed that debris was present inside the fuel system and the fuel system needed to be replaced. The failure mileage was 128,000. VIN tool confirms parts not available.
I purchased this truck brand new and am the original owner. This truck has been in the dealers procession probably over 50 times and in the shop probably close to 200 days. Most all repairs have been about computer, smog, or other engine problems. Chrysler has extended my warranty out into 2025 and extended the miles to 125k . I currently have 82k miles. It just was in the dealer 1 month ago and currently has check engine light on again. They state it is for a recall they have no current fix for and it sounds like their not even working on one. I was told that this years model with the 3.0 diesel will be the last. I went to then ask for a trade in value from a Ram Chrysler dealer, and was told they could only give me low auction value. I have an additional over $7k in improvements that I will loose. Any help or suggestions would be appreciated. Thank you
The contact owns a 2015 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Ram 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history