2018 Ram 1500 technical service bulletins
498 technical service bulletins and manufacturer communications cover the 2018 Ram 1500.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The Customer May Complain About a Popping Noise, Grinding Noise, or an Intermittent No Reverse or Forward...
- Backup Camera Poor Image Quality Inspection
- Outside Power Fold Rearview Mirror Noise Or Loose At Pivot
- Squeak Or Squawk Noise Coming From Either Side Door Of The Vehicle, It Could Be Just One Door Or More
- The vehicle will exhibit a service transmission/check engine warning indicator for the following...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Service transmission/check engine warning indicator for the 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Water Pump & Chain Case Cover
- If Safety Recall Z46 has been completed, order 68632011AA.
- If Safety Recall Z46 has not been completed, order 68235275AB.
- Engine Oil Leak
- Shock absorber – suspension & shocks - rear
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Verify Reman part number availability
- Lamp - dome
- Washer Light On And Will Not Turn Off After Adding Washer Solvent."
- Rear Defogger Solder Terminals Detached.
- Canister
- CEL (Check Engine Lamp) C006A-49 Multi-Axis Acceleration Sensor Internal Electronic Failure And C10CC-00...
- Hard To Fill With Fuel Customers may experience one or more of the following: ● Hard, difficult, or unable...
- Radiator - engine cooling
- Camera - rear view
- Panel - b pillar lower trim
- Fuel vapor canister filter evap
- Dual EVAP System Extreme Duty Vapor Canister Filter Kit Customers operating fleet or severe/extreme duty...
- Plate
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Motor - windshield wiper & wiperunit - windshield wiper
- Suspected Engine Coolant Leak
- Valve
- Brush - vacuum
- SOS and Assistance Call Not Working After Radio Exchange Unit Installed
- Cooler
- Throttle Blade Icing Service Fix Customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Lifter
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- 8-Speed Transmission, Additional Transmission Fluid Leak Inspection/Repair Guidelines.
- Suspected engine coolant leak.
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- The Replacement CSWM/HSM Sets DTC?s U1446-00, B1EB4-1B, B1EB3-1B, B11DC-13
- The Heated Seats Do Not Meet The Customers Expectations
- Apple CarPlay Does Not Work Or Not Connecting
- CEL (Check Engine Lamp) Illuminated, P057B Brake Pedal Position Sensor Performance
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- Customer Satisfaction Notification ZD7
- Customer Satisfaction Notification ZD7
- Water Quality When Mixed With Engine Coolant
- Ambient Air Temperature Missing, Malfunction Indicator Lamp (MIL) Lamp On, Diagnostic Trouble Code (DTC)...
- Ambient Temperature Sensor Servicing.
- WiTECH Small Leak Verification Test (SLVT)
- CEL (Check Engine Lamp) Illuminates, Recent PCM Replace or Flash Update Performed, Diagnostic Trouble...
- Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level...
- Adapter
- Radio Remained On After Ignition Is Switched Off, Dead Battery From Excessive Radio Current Draw
- Adapter
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- UAS and UCS Radio Enhancements Customers may experience one or more of the following: Wi-Fi hotspot...
- Washer Light On And Will Not Turn Off After Adding Washer Solvent.
- UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? Wi-Fi hotspot...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Perceived Low Power/Acceleration Lag, And/Or Malfunction Indicator Lamp (MIL) Illumination, Diagnostic...
- Radio Over The Air Software Version Update to 22.66
- Radio Remained On After Ignition Is Switched Off, Dead Battery from Excessive Radio Current Draw
- Guidelines For The Use Of Alternative Diesel Fuels.
- Connector
- Approved Use of Weld Through Primers
- Cooler - EGR
- Connector/wiring
- Panasonic VP4R Wi-Fi New Enrollment Pause
- Malfunction Indicator Lamp (MIL) Illumination
- UAS, UAQ, UCS, UAV, UCV and UCQ Radio Over The Air Software Version Updates
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- Engine
- Complete Engine Assembly Replacements Arriving Without Engine Wiring Harness.
- No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting
- Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation...
- Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire
- Hard To Fill With Fuel
- Outside Power Fold Rearview Mirror Noise Or Loose At Pivot
- Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger
- Connected Services Will Not Work After Radio Replacement
- Customer concern includes Mil-On/Check Engine Lamp-On. There also may or may not be driveability-related...
- Engine Oil Filter Interchangeability
- Diesel Fuel Injector Cleaning Procedure
- Radio Lockup In The Software Installation Screen After Accepting FOTA Update (Incorrect "S2008000204"...
- 3.0L Ecodiesel Engine Oil Information
- Warranty Bulletin D-21-10 (X94) 3.0L Diesel Crankshaft Tone Wheel
- 3.0L Diesel Crankshaft Tone Wheel Loss of Signal
- Media Device Connection Guidelines For Bluetooth, Apple CarPlay, Android Auto Or USB To The Radio Head Unit
- UAQ and UCQ Radio Enhancements
- Head unit button stuck DTC code B14DA-2A
- UAS and UCS Radio Enhancements
- No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Vehicle Cranks But Does Not Start Additional Diagnostics.
- Customer Complaint May Include Engine Oil Leak Or Consumption
- Wiring
- Bubbles Or Delamination On The Radio Display
- Radio Reboot Continually
- Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection,...
- Apple Carplay Inoperative Or Not Working, Phone Not Pairing, Carplay Lockup, Freeze or Audio Concerns
- UAS, UAQ, UCS, UAV, UCV and UCQ Radio Over The Air Software Version Updates
- Noise From Under Seat With Occupant Seated.
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle,...
- Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
- Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- Battery Tester Warranty Code Procedures, Medtronic Update Process
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- Adapter
- Customer complaint may include engine oil leak/consumption.
- Air Suspension Inoperative And Or Compressor Freeze Up Or Sticking In Cold Weather.
- Outside Power Fold Rearview Mirror Appears Loose Or Shakes
- Chime Stuck On In The Audio System
- Radio Replacement Reset Routine, Radio Has Missing Icons Or Are Grayed Out
- Plate - clutch pressure
- Rattle Tapping Fluttering Noise From A Pillar Or Dash Driving At Highway Speeds
- Emissions Recall W91 Reprogram Powertrain Control Module
- Favorite Song On-Air Alert List Empty
- Safety recall W58 - loss of crank position
- Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians...
- Tailgate Cable Has Excessive Slack or is Loose
- Customer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM...
- Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire
- Cruise Control Inoperative.
- (Rev. A) Malfunction Indicator Light (MIL) Illuminated
- (Rev. B) Malfunction Indicator Lamp (MIL) Illumination
- (Rev. A) Power Inverter Load Ratings
- (Rev. B) Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant...
- Aluminum Body Panel Corrosion Repair
- Flash: Drivetrain Control Module (DTCM) Update
- External Fuel Pump Relay Kit Now Available
- (Revision A): P2463-00-DIESEL PARTICULATE FILTER
- Power Distribution Center If the PDC is being replaced due to a failed internal fuel pump relay, the relay...
- Intelligent Power Distribution Center If the PDC requires replacement due to a failed internal fuel pump...
- Flash: Powertrain Control Module (PCM) Updates
- (Revision A) Chime Stuck On In The Audio System
- Navigation Shows Incorrect Location
- (Revision A) Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ?...
- Radio UConnect GPS Based Trip Computer Missing
- Flash: Powertrain Control Module (PCM) Updates
- USB port
- (Revision A) Malfunction Indicator Lamp (MIL) Illumination
- No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle
- Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions...
- Condenser
- Blind Spot Or Park Assist Warnings, False Activation
- The Passenger Exterior Mirror Does Not Auto Dim
- Volume Uncontrollable Or Stuck On High
- Improperly Installed Exhaust Gas Recirculation (EGR) Valve
- Travellink Fuel Prices Are Incorrect
- Fast Feedback Program
- Malfunction Indicator Lamp (MIL) Illumination
- VP4 Panasonic Radio USB Software Update Error Codes And Guidelines For Recovery
- Oil Leak From The Front Timing Gear Housing Gasket
- Sound Distortion After FOTA Update Audio Sounds Muffled Has Too Much Bass or Flat Sounding
- Malfunction Indicator Lamp (MIL) Illumination
- Remote Phone App Does Not Communicate With Vehicle Radio
- CEL (Check Engine Lamp) Illuminates, Recent PCM Replace Or Flash Update Performed, DTC P057B Brake Pedal...
- Disinfectant Solution Recommended for COVID-19
- Error Code 20 Message On the Radio Screen
- Radio Issues With iPhone 11
- Charging System, Battery Diagnostic Tools and Warranty
- Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
- Valve Body Pressure Testing Plug Inspection
- Hands On Steering Wheel Message In EVIC
- Applique
- Vehicle is difficult to refuel
- Speed Control Operates Intermittently
- 3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure
- Tonneau Cover
- Single Pop Noise From Rear Of Sunroof While Opening
- Cable assy
- Key Programming, Security Pin Request, Pin Invalid
- Apple Carplay Inoperative Or Not Working, Phone Not Pairing, Carplay Lockup Or Freeze.
- Handle, Swivel Release and Grommet, Pivot Joint The box bed divider swivel release handle and pivot joint...
- Safety Recall VB1: 2014-2019 DS 3.0L EGR Cooler Customer Handling
- VB1 2014-2019MY ds 3.0L
- Parts Escalation Process (OD61336 Linked Document
- Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the...
- Authentic Mopar® Glass Replacement
- Use of Aftermarket Parts
- Repair Parts Used For Structural Repairs
- Use of Salvage/Recycled Parts
- UAS, UAQ, UCS and UCQ Radio Enhancements
- BOX, Pickup (assembly) This service part has additional brackets used in manufacturing that will need to...
- Seat belt
- GEN-2 and GEN-3
- UAS, UAQ, UCS and UCQ Radio Enhancements
- Condenser
- Glass
- Radio [res]
- PadKit- Front Disc Brake
- Caliper assembly
- Brake Transmission Shift Interlock (BTSI) Please contact Stacey Davis at (248) 260-6078 or...
- Mat Kit- Floor Front
- Bin- Storage
- Actuator-Multiaitr
- Warranty Operations Newsletter ? Volume 5, Issue 5
- Fan module
- Sensor-nitrous oxlde
- Run-Front Door Glass
- Power Transfer Unit
- Molding-Wheel Plane
- Latch- Front Door
- Safety Recall V47 / the federal safety agency 19V-325 Backlite Glass Parts Ordering Information
- Damper-Steering
- Head-Cylinder
- Tube- Fuel Filler
- Vehicles Eligible For CSN U07 And V08, V11 or V16 Important Update To U07 Dealer Instructions
- Engine Oil- OW20
- Adapter
- Outlet- Air conditioning & heater
- Module-Parking Assist
- Tailpipe - exhaust
- Transmission ? With Torque Converter
- Power distribution center - intelligent power
- Panel Assembly-Door Trim
- Fascia - rear
- Ash receiver - instrument panel
- Warranty Operations Newsletter Volume 5, Issue 4
- Common portion of a presentation provided to mutiple OEM customers concerning a potential issue and...
- Job aid
- A/C Pressure Transducer A/C inoperative and diagnosis leads to pressure transducer
- Radio Pre-Authorization Program
- Power Distribution Center For 2018 DS, prior to replacing the Power Distribution Center (PDC), you MUST...
- Nameplate
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Shop Certification Program Guidelines
- Door Hinge Assembly Side door hinge noisy
- Recliner
- Housing Assy
- Cover
- 04627694AA
- Molding Assy ?Frt door day light opening Rt/Lt: Return You have been identified as either having stock, or...
- Vehicle Restriction Program
- 55395241AG
- 04589131AG, 04589243AG
- Essential Flash Management
- R4801865AC
- DAPAP Requirements
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Inspect and Return: Lamp Assy
- Inspect and Return: Relay Assy
- P/n 68111384AB
- P/n 04573460
- 68103256AGReturn: Line Assy
- 68160775AB
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- Return: ALTERNATOR
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- 68085119AE,Inspect and Return: Exhaust Pipe Assy
- You have been identified as either having stock, or have stock in transit to your dealership
- Battery
- Hands Free Module
- A/C Compressor This applies to 2015 and 2016 UF and PF. Before replacing the AC compressor for noise,...
- Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold...
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- You have been identified as either having stock, or have stock in transit to your dealership
- Inspect and Return: Latch Seat, and Latch Seat Back You have been identified as either having stock, or...
- RE2 RE6 RB5 RB6
- Flash: 2.4L Powertrain Diagnostic and System Improvements
- Title 68245351AB: Switch
- Title Filter
- Title 05182600AC: Molding Assy
- Title 68260866AB: Module Kit
- Title 68146401AA: Tube
- Title Control Module
- Title MasterShield Products Start Date: 10/28/2015 7:00 AM End Date Message You have been identified as...
- Title Inspection and Return: Hydro-Booster
- Windshield Wiper Blade/Element Maintenance
- Title Win Kit
- Message You have been identified as either having stock, or have stock in transit to your dealership
- Title Latch Assy
- Title Inspection and return of PN 68210332AA
- Replacement Seat Covers And Seat Cover Repairs
- Inspection and Return: 68261532AA: Evaporator
- Molding Sill-Rear
- Inspection and Return: Motor
- Taillight.
- Mopar Trailer Tow Mirror Kit After installing the Mopar Trailer Tow Mirror Kit, configure the vehicle for...
- Spare Tire Kit For vehicles with Alloy Wheels, an adapter is required (not included) to connect the alloy...
- Stop sale
- 2014 KL 9-Speed service transaxle with 2015 common hardware This 9-speed transaxle must be ordered thru...
- Safety Recall R23
- RA3/RA4
- Inspection and Return:Brake Rotor-52121050AA
- Safety Recall R35 Reprogram Occupant Restraint Control Module
- HVAC Blower and Wheel HVAC blower motor is inoperative
- HVAC blower assembly Blower Motor either making noise or is inoperative (even intermittently)
- Inspection and Return:MOLDING ASSY-RR DOOR DAYLIGHT OPENING RT:04805838AD,MOLDING ASSY-RR DOOR DAYLIGHT...
- Tire pressure monitoring module Prior to replacing tire pressure monitoring module, for DTC's C151D,...
- Inspection and Return: Brake Rotor
- Shifter
- Fuel tank Before replacing this part, please call Keith Kerby on his Cell (248) 420-5540 OR Manuel Gandara...
- Headlamp Assembly If the headlamp assembly is being replaced, please also replace the harness attached to...
- Inspection and Return: Brake Rotor
- Compressor HVAC compressor is inoperative
- Power Transfer Unit Prior to replacing the PTU, please review the following .~ Check if the service 4WD...
- Inspection and Return: Brake Rotor
- Camshaft Position Sensor If replacing a camshaft position sensor for P0340 and/or P0344 fault codes,...
- Crankshaft Position Sensor Before replacing this part due to a P0335 fault code, please contact Andrew...
- Cruise Control Switch Before ordering or replacing this part please contact Dennis Gauthier at cell (248)...
- Battery Please call Bob Horn at cell (248) 231-3315 prior to replacing any battery
- Bumper Step Pad
- Radiator If vehicle comes in for transmission fluid leaking from trans-oil cooler fittings on the...
- Return: Molding Kit
- Pump
- Camshaft Position Sensor If replacing a camshaft position sensor for P0340, P0344, P0345, P0349, P0365,...
- Evaporative System Integrity Monitor switch (ESIM) Prior to replacing this component on a 2015 Dodge...
- Element Assy- Heated Seat If any of the Front Heated Seats are Inoperable
- Warranty Operations Newsletter Volume 1, Issue 6
- Seat belt retractor
- STAR receives on average 1,000 contacts per day ? that?s 300,000 annual contacts for technical assistance
- Summary to be provided on a future date.
- If replacing the steering linkage or drag link inner tie rod assembly at the pitman arm on a vehicle built...
- 82212076, 82203694
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Ram 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history