The contact owns a 2022 Ram 1500. The contact stated that while driving on several occasions at various speeds, the ABS, brake, and other unknown warning lights illuminated, and the messages "Traction Control Disengaged", "Shift Knob Required Servicing", "Cruise Control Disconnected", "Video Display Need Servicing," and other unknown messages were displayed. The steering wheel was firm and difficult to turn. The vehicle was turned off and failed to restart immediately. The contact stated that after several minutes, the vehicle restarted. Additionally, while driving with the cruise control feature activated, the feature deactivated inadvertently and the message "Traction Control Disconnected" was displayed. The fuel gauge on the instrument panel was moving erratically and then became inoperable. The vehicle was pulled over to the side of the road, turned off, and then restarted. The vehicle was then taken to the residence. The vehicle was taken to the same dealer four times and was diagnosed with an unknown communication error. During the first visit, the ABS module was replaced. During the second, third, and fourth visits, the dealer was unable to duplicate the failure, but stated that there was a communication error. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.
Ram 1500 fuel gauge problems
195 of the 11,934 owner complaints about the Ram 1500 describe wrong fuel gauge reading, most of them for the 2014 model year.
- owner complaints
- 195
- worst model year
- 2014
- typical repair cost reported
- $900
- typical mileage
- 54,870
By model year
Often reported together
Check engine light 91Fuel pump 28Stalling 9Adaptive cruise 5Loss of power 4Fuel leak 3Won't start 2Power steering loss 2
Trouble codes mentioned
P0463 19U0155 1P0364 1
What owners say
Check Engine light came on with a code P0463. This indicates that the fuel level sensor is bad. This is a VERY common issue on these trucks. It causes the vehicle to no longer go into "ECO" mode which is wasting fuel. This happens every time I fill the gas tank and does not go away until the tank reaches 3/4 tank. The part is garbage and is known to fail.
While driving in traffic on the interstate with adaptive cruise control working, all lights on the dash illuminated for 1 to 2 seconds, adaptive cruise control kicked off, the dash then went totally blank for 2 to 3 seconds then slowly came back to life with the fuel gauge showing zero when there was ¾ of a tank prior to this event.
Vehicle reaches 50percent fuel level and drops to zero causing the operator to potentially run out of fuel. And disables remote start functionality. Also potentially run out of fuel at anytime and not being able to move vehicle to a safe location. Even the side of the road. Out of gas. Can not move at all. Dealership has replaced twice already the fuel level sensor. Multiple vehicles I’ve seen with this problem. Could leave someone in a dangerous situation.
The contact owns a 2023 Ram 1500. The contact stated that the vehicle was experiencing an inaccurate fuel gauge reading. Additionally, the contact stated that while driving 60 MPH, the fuel gauge displayed that the fuel mileage was 18, but the vehicle suddenly lost motive power, prompting the contact to pull over to the side of the road. The contact parked the vehicle and took an Uber to his destination. The contact later returned and added fuel to the vehicle. The vehicle was taken to the dealer on three occasions. The dealer reset the computer, and the module K1 fuel pump leveling unit was replaced, and the instrument cluster was reprogrammed as per TSB Number: 08-234-24; however, the failure persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 10,360.
The digital instrument cluster failed. All telemetry is shown on this cluster including speed, fuel level, rpm, odometer and more. The cluster was going totally black every two minutes and it would disable cruise, lane departure warning, blind spot warning and the check engine light was on. There was no indication prior that there was a problem, it just all of a sudden went black and beeped. Then it would come back after 5 seconds and do it again two minutes later. Also my odometer wasn't working or updating the miles. The dealer confirmed the cluster needed to be replaced. It sat at the dealer for 96 days before the repair was made.
The gas tank will not take fuel. Tried multiple pumps at multiple gas stations and the pump keeps turning off. You have to keep restarting the pump over and over again. If you look it up online, there are hundreds of people having the same issue and most cases seem to be a faulty rollover valve, the filler neck itself or a complete replacement of the gas tank. If someone isn’t monitoring the fuel level with the ignition on and they keep restarting the pump, they may over fill the tank and pump gas on the vehicle or themselves which is hazardous and could be potentially fatal.
The contact owns a 2016 Ram 1500. The contact stated that at start-up, the fuel gauge indicated that the fuel tank was on empty, even though the fuel tank was full. Additionally, the check engine warning light remained illuminated, with the message “Fuel Sensor Failure” displayed. The local dealer was not contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
Fuel level sensor failed. Truck will randomly display false fuel levels. This causes the fuel level to be unknown leading the potential of running out gas and being stranded. Dealer says fuel pump needs replaced and is in the process of doing so. Dealer also stated this is a common issue on the Ram trucks.
I presently have 92,200 miles on my Doge Ram. I have experienced 3 fuel pump/fuel sender failures. The first at 18,947 miles, second at 43,634 miles and third at 92,263.This last fuel pump replacement will have the defective pump available for inspection after the repair work is done. The failure of a fuel pump/sender could lead to stalling, power loss and failure to start. These deficiencies could lead to traffic accidents resulting in property loss and bodily harm or even death. The warnings persisted until I had the parts replaced. Because of the number of times (3)and the low mileage , 18k,43k and 92k miles, it appears that the fuel pumps used in this model of Dodge Ram are either defective or inadequately engineered. These failures were preceded by and check engine warning light followed by a fuel sensor failure light and fuel gauge malfunction.
Related recalls
Fuel system, diesel: delivery: fuel pump
- What is wrong
- Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Wrangler, Gladiator, and 2022-2023 Ram 1500 vehicles equipped with a 3.0L diesel engine. The high pressure fuel pump (HPFP) may fail.
- Risk
- Fuel pump failure can result in an engine stall, increasing the risk of a crash.
- Remedy
- Dealers will replace the HPFP and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact FCA US, LLC customer service at 1‑800‑853‑1403. FCA US, LLC's number for this recall is 01A.
Recall number 23V263000 · Recall details
Fuel system, diesel: delivery: fuel pump
- What is wrong
- Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.
- Risk
- Fuel starvation may result in an unexpected loss of drive power, increasing the risk of a crash.
- Remedy
- Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting January 11, 2024. Owner notification letters for Ram 1500 owners were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1‑800‑853‑1403. FCA US, LLS's number for this recall is Z46.
Recall number 22V406000 · Recall details
Fuel system, gasoline: storage: tank assembly: mounting
- What is wrong
- Chrysler (FCA US LLC) is recalling certain 2009-2012 Dodge Ram 1500 trucks currently, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Exposure to environmental conditions such as water mixed with road salt may cause the front fuel tank strap frame "T-Slot" bracket to corrode, possibly causing the fuel tank to drop and make contact with the ground.
- Risk
- If the fuel tank were to drop and contact the ground, a fuel leak may result. Additionally, in the event of a crash, the fuel tank may not remain secured to the vehicle, possibly causing a fuel leak. A fuel leak in the presence in an ignition source, can increase the risk of a fire.
- Remedy
- Chrysler will notify owners and dealers will bolt a bracket reinforcement to the frame, free of charge. The recall began May 2, 2018. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is U04.
Recall number 18V160000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- Chrysler (FCA US LLC) is recalling certain 2017 Ram 1500 trucks. The fuel tanks in the affected vehicles may have a broken fuel tank control valve which might leak fuel if the vehicle were to become inverted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 301, "Fuel System Integrity."
- Risk
- In the event of a rollover crash, leaking fuel in the presence of an ignition source can increase the risk of a fire.
- Remedy
- Chrysler will notify owners, and dealers will replace the fuel tanks, free of charge. The recall began on August 10, 2017. Owners may contact Chrysler customer service at 1‑800‑853‑1403. Chrysler's number for this recall is T45.
Recall number 17V434000 · Recall details
Questions about the Ram 1500 fuel gauge
Which Ram 1500 years have wrong fuel gauge reading problems?
The model years with the most reports are 2014 (81 complaints), 2016 (46 complaints) and 2015 (29 complaints).
How much does it cost to fix wrong fuel gauge reading on the Ram 1500?
Owners who mentioned a price put the repair at about $900 (median of 23 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ram 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history