2022 Ram 3500: complete transmission failure

Filed Jul 23, 2026 · Transmission · 46,000 miles · TX

The contact owns a 2022 Ram 3500. The contact stated that while parking the vehicle, the contact unhooked the camper that was being towed and shifted the vehicle to drive(D) but the vehicle failed to move forward or backwards while in reverse(R). The contact associated the failure with the federal safety agency Action Number: PE24009 (Power Train). The vehicle was towed to the dealer and was diagnosed with transmission failure. The vehicle was repaired; however, the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 46,000.

Filed Apr 18, 2026 · Transmission · WA

While travelling in Southern California, I came to a stop to enter I8 on ramp. When I tried to start down the on ramp the truck didn’t want to move and a check engine light came on. The truck went into limp mode so would travel slowly along. I called Mango Auto who could diagnose it the following morning. I did not make it to the shop before the transmission failed completely and the truck wouldn’t move leaving me in traffic in a dangerous spot. Eventually I was towed to the shop in Yuma AZ. They diagnosed it as a complete transmission failure requiring a $10,000 replacement. FCA has issued an extended warranty, but my mileage is 16700 miles over. FCA has a technical bulletin on the issue with the Austin transmission, but has not but should have issued a recall. This failure To issue a recall left me stuck in a dangerous situation and could have resulted in a crash.

Filed Jan 21, 2026 · Transmission · TN

I have had the seal between the transmission and transfer case replaced 3 times due to leaking since new and after each repair within miles of each repair and all prior to the vehicle reaching 50,000 miles. The last time it was repaired at 65,000 miles they decided to replace the transmission with a new transmission - it also leaked between the transmission and transfer case within 1 day and less than 100 miles.

Filed Sep 16, 2025 · Transmission · IN

While driving on interstate leaving a construction zone started to accelerate to maybe 40mph and heard/felt a hard clang and lost all forward motion costed to side of interstate. Looked underneath truck, nothing visible broken or leaking. Restarted truck tried to move forward with no luck. Reverse worked, put back in drive loud noise again stomped on the accelerator and started moving forward very slow and difficult. Made it to an exit to look at things in a safer location than the busy interstate. Figured out that I had reverse and 5th gear so it was very hard/ slow to get moving. Check engine light on, gear ration incorrect, code P0731, Tran sensor failure, no 4x4 Transmission failure 1-4 gears not working

Filed Jul 9, 2025 · Transmission · CA

The transmission in my vehicle failed suddenly on May 31, 2025, entering “limp mode” and losing the ability to shift properly. The vehicle became immobile and was towed to the dealership. Initial diagnostics revealed difficulty shifting between 3rd and 4th gears. Service technicians attempted repair in June based on RAM TSB MC-10231775, which indicated snap ring failure in the Aisin transmission. Repairs prescribed in TSB were attempted but unsuccessful, as the vehicle still could not shift into 4th gear. Additional parts were ordered, and another repair was unsuccessfully attempted in late June. Ram has shipped a new transmission which we are waiting on the dealership to install.

Filed Jun 13, 2025 · Transmission · KY

Transmission failure while driving not allowing to go in park after we got stopped. Truck un operable to get out of traffic.

Filed Oct 6, 2024 · Transmission · MD

Transmission failed in heavy interstate traffic while towing 35 ft 15,000 lbs RV. My RAM 3500 only has 19,000 miles and is still under new vehicle warranty. The event: While travelling on Washington DC beltway in lane 3 of 4 without warning my transmission starting slipping. No abnormal noise, no dash lamps warning of an issue. As I pressed on accelerator my speed continued to decrease. I quickly signaled to right lane in an attempt to get off the road. I was slowing at a rate I was concerned I may be stopped on highway with vehicles traveling 55 mph approaching. I did make the shoulder in between an exit and entrance ramp with barely enough room for a tow truck to be in front. I had 3 ft on my left with 55mph traffic passing constantly. The vehicle was towed to a local RAM dealer as my wife and I waited on the highway with RV for second tow service. This all could have been avoided. Why was a TSB or recall already in place? RAM has many transmission failures on the 2022 Aisin transmission noted on RAM truck forums. I had read about it but considered myself lucky as I was almost 2 years driving truck without any problems. My safety, my wife and tow truck drivers safety were put at considerable risk due to Stellantis not alerting RAM dealers of a potential transmission failure. Research Noah Leotta Police Officer Montgomery County Maryland. The circumstances we experienced were exactly how he lost his life. I have not received work ticket from dealership, I will follow up with documentation when requested.

Filed Sep 16, 2024 · Driver assistance, Transmission · CO

While driving around 20 mph, suddenly heard a clunk, then several dashboard warning lights came on. Truck suddenly had no torque- would only move forward if the engine was revved at much more than normal amount. Nearly complete loss of ability to accelerate from a stop/low speeds. Took to an independent service center who ran the ODB codes, showing the now well-known issue of "transmission failure gears 1-4" Warning lamps include the lane sense and check engine lights, and a message on the dash that reads ACC not available, Automatic high beams not available. Prior to this, no problems with the truck at all. I am trying to arrange getting it towed to a dealership.

Filed Aug 9, 2024 · Transmission · NJ

My truck experienced a total transmission failure while at Highway Speed towing a 5th wheel camper on Interstate I95. This transmission failure is a known issue and has a TSB 21-002-23. A k1 clutch clip becomes dislodged and the transmission will not function. Being stranded and unable to move on a busy highway is unsafe and terrifying. Aisin Transmission and RAM are well aware of this failure however I was never notified about the potential failure nor has a recall been issued. The failure occurred instantly with no warning in a vehicle with 16,000 miles and less than 2 years old. My vehicle has been repaired and the failure was confirmed as the K1 clutch clip failure. There should be an immediate recall for this known failure to be repaired prior to being stranded on the side of the highway, 400 miles from home with my wife and kids. It's shameful RAM has ignored this problem!

Filed May 9, 2024 · Transmission · IN

This vehicle left me stranded due to Aisen transmission failure with only 2000 miles on the vehicle. Has been at dealer for 3 months awaiting rebuild due to faulty clip. Why is nothing being done? Why am I not getting a new transmission? or better yet forced buy back

Filed May 1, 2024 · Transmission · MI

Transmission went out. Lost 1-4th gear. It was the K1 snap ring in the transmission. Lost power going up a mountain in a National Park exhaust brake either to slow vehicle. Check engine light came on

Filed Apr 11, 2024 · Transmission · MA

1, The Aisin AS68RC transmission failed. The dealership had to ship the defective complete back to Aisin . 2. On [XXX] with only 2,886K miles while on Interstate [XXX] in Boston Massachusetts . I just entered the highway and was getting into the middle lane getting up to high way speed. The Tachometer shot up in rpm’s and there was no more forward gear. I was doing about 50-60mph. I had to cost from the middle lane to the brake down lane with my 20’ trailer in tow in heavy traffic. Once in the brake down lane I was able to go in reverse but couldn’t go forward. Loud clunking when put into gear and trying to move forward. 3. The vehicle was towed to the dealership from [XXX] that night to Herb Chambers Millbury Ram and confirmed transmission failure. 4. Aisin sent a complete transmission assembly to the dealership for installation. So the dealership inspected it. 4. There were NO warning lights before transmission failure. I did notice the truck felt Rough over 40 mph before transmission failure since I picked it up brand new from the dealer. Absolutely NO warning light/ indicator prior to Transmission failure!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)