Ram 3500 tire blowout problems

Filed Aug 25, 2026 · Brakes, Electrical · IL

On multiple occasions the U-Connect system in the listed 2026 RAM 3500 has gone completely black and was inoperable until a reset was performed. The trailer brake gain control and exhaust brake are accessed and controlled via the touch screen U-Connect system. This failure poses a significant safety issue when the screen goes black and the controls cannot be accessed when pulling a trailer. This can lead to failure to slow/stop the vehicle while in motion, tire failure on the trailer etc. The only method to regain access to the brake controls is to perform a reset of the U-Connect system which can take 2-3 minutes to complete. Stelantis is and has been aware of this issue for some time and has no resolution at this time.

Filed Aug 18, 2026 · Steering, Suspension · PA

Pursuant to a manufacturer-issued safety recall (V06) on a steering assembly component, the manufacturer's remedy permanently damaged an otherwise functioning, adjustable steering component and created a financial barrier to basic vehicle maintenance. The component, post remedy, now would have to be replaced in order to allow adjustment to put the vehicle steering system into correct alignment. Driving a vehicle without proper front end alignment can cause premature tire wear contributing to tire failure and/or pulling to the right or left contributing to a possible accident condition. The manufacturer is refusing to pay for the replacement parts/repairs that, but for the recall remedy, would be necessary.

Filed Aug 12, 2026 · Wheels · AZ

From the first day i bought the truck i noticed it had a very tight vibration coming from the rear. I thought its may just be the Firestone tires that were put on at the factory. I had to drive out of state to a small town in Nevada. After around 3500 miles the vibration became severe and felt like i had a tire seperating. I called the nearest tire centers/shops within about 100 miles of my location. None carried the firestone transforce tires. So i traveled to the Nearest shop around 60 miles and the certified tech and managed assisted me. The did an inspection and found the tire was scalloped and damaged. Due to the size difference in the tires the shop had available, i had to purchase 4 tires they had in stock. When the tech and manager roadforced the wheels and tires he discovered one of the wheels had a defect and was not actually round and had a slight “out of round” defect starting from the hub mount center bead that extended to the outer circumference causing the rim”wheel” to be out of round which is how the tire was severely damaged. An out of round wheel can cause tire failure and thus, a safety issue. To date as i write this report, i have tried twice with a dealership to try to resolve this issue under the warranty.

Filed Jul 16, 2026 · Tires · OH

Nexen Roadian HTX RH5 LT235/80R17E 120R/117/R At approximately 70 mph, I experienced a severe vibration in the steering wheel. Shortly thereafter, the tread separated from the carcass sending pieces of rubber flying. I was able to pull onto the shoulder and change the tire. These are the OEM tires with about 25000 miles. They have never been under or overinflated and I was not hauling or towing anything.

Filed May 5, 2026 · Tires · FL

Tire size: 275/ 70 r 18. Item is available for inspection. Tire can potentially explode/blow out. Have reached out to dealer, waiting on call back. Vehicle has not been inspected by anyone. No warning lamps or messages. First noticed issue on may 2, 2026. Sidewall of tire has a "perfect circle" all around the tire where the thread is separating.

Filed Mar 9, 2026 · Tires · TX

Well this is 2 nd report , got truck in sept , 1 tire blew at 625 miles , did not waste time at dealer this time , came off the ranch got about 10 miles down road tire was losing air ,pulled over was leaking bad ,now remember this is a 1 ton dulley Tk with 6 , six tires , same set of Goodyear tires , feb 26, 4100 miles then , now ok after this I came home went to discount Tire bought 6 new tires have my 6 tires off new Tk in barn , I can't take the risk of killing somebody are myself with another blow out !!! 3 tires off new dealers again said these should not be on this truck

Filed Jan 29, 2026 · Tires · SC

Trailer King RST 235/80R16: six of them on a triple axle boat trailer. Was towing a boat and experienced a blowout on the passenger rear trailer tire, of which we did not hit a pothole or strike debris. It bent the boat trailer fender and damaged several components of the trailer. It was identified by Discount Tire that the passenger side lead tire experienced belt separation, which is a manufacturer defect and was most likely the cause of the passenger side rear trailer tire to blow out and cause excessive damage to the trailer. There are numerous other customers of this tire who experienced significant blowouts on their trailer, which poses a safety risk to all who own trailers with these Trailer King RST tires and those who travel the roads with them. The belt separation was confirmed by a third-party tire shop recognized nationally. I submitted a claim for the blown out tire with the company manufacturer, and they claim it was not due to manufacturer defect. Unicorn tire does not accept responsibility for the manufacturer defect, even though it was confirmed by the company discount tire. These trailer tires are unsafe. Bottom line: two of six trailer tires that were two years old and had less than 3000 miles on them experienced belt separation, one of which had a significant blowout that could’ve caused serious accidents. This is not an isolated case as other reviews have shown these tires to be unreliable and unsafe disregard the VIN associated with this complaint as it would not accept my trailer VIN.

Filed Sep 4, 2025 · Tires · 14,000 miles · NJ

The contact owns a 2017 Ram 3500 equipped with Nexen Tires, Tire size: 235/80/R17, Tire Line: Roadian ATX, DOT Numbers: 8EX6CMDL4517, 8EX6CMLL1616, 8EX6CMDR1017, 8EX6CMDL1017 and 8EX6CMCL1017. The contact stated while driving at various speeds, two of the tires exploded into pieces on different occasions. The contact was able to pull over to the side of the road. The vehicle was taken to a tire shop, where the tires were replaced. The contact stated that a third tire exploded while driving. The vehicle was taken to a tire shop, where it was recommended to replace all four tires because the tire brand and line was defective. The contact was informed that the tires were separating from inside out. The contact stated that the failure mainly occurred while hauling a camper. The manufacturer was contacted and advised the contact to install a gauge on each tire. The contact followed the manufacturer's instructions; however, the failure persisted. The contact filed a refund claim with the manufacturer and was informed that the claim was approved. The manufacturer advised the contact to destroy the tires and to send a picture of the destroyed tires. The contact followed the manufacturer's instructions but was later informed that the pictures were not received. The contact had not received a refund from the manufacturer. The tires were replaced with a different brand tire. The tires were original tires. The tire failure mileage was approximately 14,000. The vehicle mileage was approximately 14,000. The VIN was not available.

Filed Aug 30, 2025 · Tires · CO

I purchased a dodge 3500 truck on October 16th 2024. My truck as of today has 4900 miles on it. It is a one ton dually. I noticed this week two of the rear outside tires have cracks and defective tread. I took it to a tire shop and they confirmed these tires are bad. I tow a 40 foot fifth wheel trailer. If I had had a blowout it could of been a huge problem for myself and those on the road around me. I spoke to the dealership I bought the truck from and they informed me they would have to see the tires and file a report with the manufacture of the tires. I had to buy all 6 new tires because I didn't want to chance a blow out with my trailer on the truck. I googled Nexen tires LT235/80R17 which are my tires. It says these are not rated for a 1 ton dually truck. When used on a dually it says its not the best choice for a 1 ton especially when towing heavy loads. The reason I bought this truck was for the purpose of towing my RV. I made that clear to the sales man at the dealership when I bought this truck. I assumed these tires were rated for this truck. If it's a defect I should be reimbursed from the manufacture for all 6 tires. If it's the dealers fault they should reimburse me. This is definitely a road hazard, a accident waiting to happen.

Filed May 19, 2025 · Tires · FL

Nexen LT235/80R17 2 blow out's and one tire failure. factory installed tires. I have had 2 blowouts on the right front of my Ram 3500. I had discount tire unmount and re mount my spare on the blown-out tire wheel (for appearance purpose) so my spare is now another brand, the spare Nexen that replaced the blow out also blew out within ~2000 miles. I took the vehicle to Walts Live Oak Ram to inspect the vehicle for a cause of 2 tires blowing in the same position on the vehicle, they also checked the alignment and found nothing. yesterday [XXX] pulling a trailer to Jacksonville I noticed about 50 miles into the trip a slight shudder in the steering wheel and I pressed on. On the return trip the shudder in the steering was substantially profound and the driver side view mirror was bouncing up and down, the passenger side was not, and my hands were getting numb, I slowed to 50 from 70mph and continued, the shuddering eased but was clearly still there. today I took the truck to discount tire Lake city Fla. and asked them to replace the Nexen as I felt it was failing from looking at the tire and running my hand along the tread it didnt feel normal and the tire was hot compared to the passenger side. I asked discount to spin the Nexen on the balancer and they did, it confirmed the tire was failing and was unable to be balanced. the new tire cured the problem. the truck today clocked 37k miles to give you some perspective on mileage and primary use is for towing trailers, 42' 5th wheel, 16' box or flatbed trailer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6