2023 Ram Promaster electrical problems

Filed Oct 9, 2026 · Electrical, Steering · OH

Power steering became inoperable requiring force to steer, with pulsing resistance against the direction being turned. Wasn't a large safety concern, as I was trying to maneuver in a parking lot. Happened suddenly.Lights showed power assistant needs serviced. Had it taken to a dealer where it was determined that water intrusion was the cause. Quoted at $6,500. Can't afford that. Had it taken home

Filed Sep 17, 2026 · Electrical, Steering · 5,604 miles · PA

The contact owns a 2023 Ram ProMaster 2500. The contact stated that the emergency control system was inoperable. While driving 3 MPH over a bump in the roadway, the steering wheel locked up. While driving 65 MPH, the failure recurred. Additionally, while reversing, the vehicle stopped suddenly. Prior to and after the failures, an unknown yellow warning light illuminated accompanied by an abnormal dinging sound. Additional warning lights illuminated associated with the steering, hill assist, and emergency control system, and an abnormal brake odor emanated from the vehicle. The contact stated that the failure was scary and dangerous. The vehicle was taken to a local dealer, where the contact was informed that there was a reset switch, and that the contact might have jerked the steering wheel. The dealer informed the contact that the vehicle was fully inspected. The approximate failure mileage was 5,604.

Filed Aug 13, 2026 · Driver assistance, Electrical · NJ

Sometimes while driving I experienced my powered steering cut out while taking a ramp on/off of the highway, and sometimes when i was trying to park and back up into a parking space while steering at the same time. When the power steering cut out I got lights for "Service Power Steering", "Service ESC", and "Service Hill Assist" all at the same time, and once i got a power steering light. I looked up the issue and found that there is an active preliminary investigation going on for the same issue on the same vehicle, the investigation coded PE26002. Once I handed the vehicle over to the dealer, they found that the power steering had an open circuit on the steering gear. Once they took the connector off they found that the connector was corroded and the wires were burned on the steering gear and main harness side. I had to have them replace both the steering rack, and the main harness.

Filed Aug 7, 2026 · Electrical · AZ

Factory-installed Onan generator repeatedly throws fault codes causing complete air conditioning system shutdown. Defect present since early ownership. Three failed repair attempts at authorized Thor Motor Coach dealer La Mesa RV. Generator has never reliably held a load. Creates dangerous condition in extreme heat. Thor Motor Coach has refused to honor warranty.

Filed Jul 27, 2026 · Electrical, Steering · WA

Due to the loss of power steering the tech at Rainier Dodge of Olympia performed electrical testing per diagnostic chart and found water intrusion into steering harness that has corroded wiring from the body harness into electric steering gear motor/module unit. The electric power steering gear assembly and harnesses must be replaced. The vehicle recieved a fault code U0140 stating loss of communication with body control module.

Filed Jul 20, 2026 · Electrical, Steering · 40,000 miles · FL

The contact owns a 2023 Ram Promaster 2500. The contact stated that while driving approximately 65 MPH, the message “Power Steering Service” was displayed with a high-pitched whining sound coming from underneath the hood and the dashboard. The vehicle was taken to the dealer, who diagnosed that the steering gear EPS module and jumper harness needed to be replaced, and the vehicle needed an alignment. The vehicle was not repaired. The contact researched online and associated the failure with the federal safety agency Action Number: PE26002 (Steering, Electrical System). The manufacturer was not informed of the failure. The failure mileage was approximately 40,000.

Filed Jul 18, 2026 · Electrical · FL

At 40,000 miles the Service Power Steering light came on solid red with "!". Hill Kelly Ram Dealership in Pensacola done a diagnostic test and stated Steering gear/EPS Module and jumper harness needs replaced with an alignment. There is an investigation going on or has been with this same issue. My original warranty says it is not covered, my extended warranty with ProGuard is not helping to fix the issue as well. I am retired single female on Social Security and just purchased this vehicle from Auto Basics on [XXX] XXX. My van needs to be fixed and I do not have over $1,233.00 out of pocket for Labor cost. This is my only vehicle and I want it fixed free of charge due to this being a well known safety issue with Ram Manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 17, 2026 · Electrical, Steering · CO

While driving, a “Service ESC” warning message appeared and the vehicle suddenly lost power steering assist, causing the steering to become extremely difficult and creating a serious safety risk while the vehicle was in motion. The vehicle was taken to a service center, where technicians found multiple loss-of-communication codes involving the electronic power steering system. Further inspection found the main electronic power steering connector full of water and corroded. The technician documented that water intrusion caused excessive damage to the electronic power steering terminals at the rack-and-pinion assembly. The water intrusion appears consistent with a failure or inadequacy of the sealing intended to protect the electronic power steering connection from moisture. Due to the extent of the corrosion and damage, the affected wiring harnesses and rack-and-pinion assembly had to be replaced, followed by a wheel alignment. This failure resulted in a sudden loss of power steering assist while the vehicle was being driven.

Filed Jun 24, 2026 · Electrical · GA

2023 RAM ProMaster VIN [XXX]. the federal safety agency Recall 25V‑720 / FCA 67C Cooling Fan Fire Risk. Dealer : Landmark Chrysler Dodge Jeep Ram FIAT Of ATLANTA .. ( 5745 Peachtree Blvd Chamblee GA - 30341 confirmed BCM failed due to recall. THINKCAR 05/25/2026: "B1081-86 ECM Fire Protection Strategy Failure - Active". FCA refused free recall repair, demanded customer pay. Vehicle at dealer since 05/21/2026, 30+ days, no loaner. I paid $571.73 battery on 06/03/2026 and dropped at dealer. FCA violating 49 U.S.C. 30120. Request the federal safety agency force FCA to repair BCM free, reimburse $1001.73, provide loaner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 15, 2026 · Electrical · KY

Manufacturer has not timely completed the following recall in a manner that promotes safety or the urgency to protect lives. My particular vehicle is a class B recreational vehicle that cannot be used since this recall. I request the federal safety agency exert its authority to compel the manufacturer to expedite immediate recall safety repairs.