The contact owns a 2007 Saturn Ion. The contact stated that while he was attempting to start the vehicle failed to start. The contact stated no warning light was illuminated. The contact stated he began to smell a fuel odor inside and outside the vehicle and also saw a fuel leak between the rear tires. The contact took the vehicle to an independent mechanic and was informed that the fuel pump module needed to be replaced. The contact called and made the local dealer aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with the federal safety agency Campaign Number: 12V459000 (Fuel system, Gasoline) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 80,000.
2007 Saturn Ion: fuel pump failure
111 of the 876 complaints about the 2007 Saturn Ion describe fuel pump failure.
- owner complaints
- 111
- of this car's complaints
- 13%
- typical repair cost reported
- $609
- typical mileage
- 71,214
- recalls
- 2
Fuel pump failure by model year
What owners say
Gas leaking from fuel pump/gas tank. A strong odor of gasoline is permeating the cabin. My eyes burn and lips are numb. Second day gas can be seen dripping off of the fuel filter, the fuel filter is coated with gasoline. Gasoline pours from underneath the rear passenger side of the vehicle any time its started.
Car cuts off A/C wont work unless on max and makes noise when turning. Cpu issue like RPM fluctuates I think its the fuel pump and gas pedal assembly cpu problem and its jerks alot dealer said aint nothing the can do bout it but they suppose to fix it with in 30 days of purchase time. So it cuts off while riding and jerks while im on the breaks
Fuel leaking from top of fuel tank, coming from broken port on the fuel pump. This is the same issue as documented in gm recall 09226c, but because this vehicle isn't in any of the states listed I have to pay for it out of pocket. How can a recall only cover vehicles in certain states.
The vehicle suddenly lose of fuel while driving. After access suspect fuel pump problem
Tl* the contact owns a 2007 saturn ion. The contact stated that the vehicle was serviced by a dealer (horne motors of show low, 1‑888‑522‑8962, 1700 s white mountain rd, show low, az 85901) for a manufacturer recall concerning the electrical system. The recall remedy caused a failure and no solution pertaining to the ignition switch, which also affected the steering. The dealer replaced the fuel pump, steering column, and ignition. The dealer also provided two keys that were to be reprogrammed; however, they failed to lock and unlock the doors. The contact had to use the key fob. In addition, the steering wheel locked when making a left turn and the vehicle stalled several times intermittently. The vehicle was inspected by three locksmiths. One of the locksmiths stated that the steering column was loosely connected. The vehicle was also serviced by (molle chevrolet, (816) 229-8800) who stated that there was no warranty and recall to provide a solution. The manufacturer was notified of the failure. The federal safety agency campaign number was unknown. The approximate failure mileage was 130,000.
Had to have fuel pump module replaced for exact problem as described in recalls of same model year ion's but not for this VIN. Have retained photos and failed pump module assembly. Fuel odor from rt rr of vehicle first noted, then within days started dripping fuel from just in front of rt rr wheel well - found to be cracked pump module
Tl* the contact owns a 2007 saturn ion. While the vehicle was parked, the contact noticed fuel leaking out of the vehicle onto the ground. On several other occasions, the contact noticed a strong fuel odor. The vehicle was taken to dick genthe chevrolet (15600 eureka rd, southgate, mi 48195) where it was diagnosed that the fuel pump failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and stated that the VIN was not included in the federal safety agency campaign number: 12v459000 (fuel system, gasoline). The approximate failure mileage was 174,000.
Tl* the contact owns a 2007 saturn ion. The contact stated that there was premature rust and corrosion associated with the heat shield around the supply lines on the rear driver's side wheel. There were also strong fumes entering the vehicle due to the failure. The dealer stated that the supply and return lines needed to be replaced. The manufacturer had a service campaign for the fuel pump, but the remedy provided no solution. The manufacturer was notified of the failure and provided no solution. The approximate failure mileage was 74,000. Updated 02/22/2017*ct consumer stated the heat shield (fiberglass w/aluminium covering) was wrapped around both the fuel and brake lines where they run close to the exhaust by left rear wheel. It appears the brake lines weren't affected because of some type of black coating. Fuel lines were lightly plated with some type of metal and it didn't work very well. The heat shield created this problem. Updated 6/22/18
The car wouldn't start right away after not running for awhile. It also smelled like gasoline. Upon taking it to the dealer, it was discovered there was a fuel leak and the fuel pump was replaced. After investigating recalls on the 2007 saturn ion I discovered a recall in effect for cars in certain states, ohio was not one of them. The recall mentioned that it was for cars registered or sold in the "hot" states. The dealer wouldn't even let my daughter drive it while waiting for parts. This recall should have been more widespread.
2007 saturn ion. Consumer writes in regards to vehicle VIN not listed in fuel odor-fuel pump module service bulletin. Consumer requests reimbursement for fuel pump repairs. *smd consumer sent additional correspondence. *smd the consumer stated the vehicle was taken in for repair, immediately upon detecting a smell of gas.
Tl* the contact owns a 2007 saturn ion. The contact had not experienced any failures with the vehicle until the dealer repaired it per a fuel pump assembly recall. Months later, the contact noticed strong fuel fumes emitting inside the vehicle. The manufacturer was not notified. The VIN was not available. The approximate failure mileage was 83,000.
Service bulletins that may apply
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
- Risk
- Fuel leakage in the presence of an ignition source may result in a fire.
- Remedy
- GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1‑800‑521‑7300.
Recall number 12V459000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General motors is recalling certain model year 2006 chevrolet cobalt and saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 chevrolet cobalt, pontiac g5 and saturn ion vehicles originally sold in or currently registered in the states of arizona, california, florida, nevada and texas. The plastic supply or return port on the modular reservoir assembly may crack. If either of these ports develops a crack, fuel will leak from the area. If the crack becomes large enough, fuel may be observed dripping onto the ground and vehicle performance may be affected.
- Risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina, tennessee and texas and model year 2007 vehicles registered in: alabama, arkansas, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina and tennessee. The safety recall is expected to begin on or before february 4, 2010. Owners may contact chevrolet at 1‑800‑630‑2438, saturn at 1‑800‑972‑8876 and pontiac at 1‑800‑620‑7668 or at the owner center at www.gmownercenter.com.
Recall number 09V419000 · Recall details
Questions about the 2007 Saturn Ion fuel pump
Is fuel pump failure a common problem on the 2007 Saturn Ion?
111 of 876 owner complaints about the 2007 Saturn Ion (13%) mention fuel pump failure. The model year with the most reports is 2006.
How much does it cost to fix fuel pump failure on the 2007 Saturn Ion?
Owners who mentioned a price put the repair at about $609 (median of 10 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
Is there a recall or service bulletin for this on the 2007 Saturn Ion?
There are 2 recalls and 3 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2007 Saturn Ion
Power steering loss 148Fuel smell 92Fuel leak 69Loss of power 47Steering lock-up 31Check engine light 29Stalling 29No deployment 21Airbag light 19Engine failure 18Won't start 17Ball joint 13Jerking 9Fire or smoke 7Door locks 6Grinding brakes 5Steering noise 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 Saturn Ion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history