2021 Subaru Crosstrek engine problems

Filed Jul 16, 2026 · Engine · CO

- Rod #4 failure of unknown cause, although there is speculation that current failure may be related to a major repair in oil system a year ago. - My safety along with my unborn child’s, husband’s and brother in law’s were all at risk. Another driver had to take evasive action to avoid hitting us in an active fast lane on I-70 going between 65-70 mph. There was no shoulder available to pull off on until a half mile up the road. - Yes the problem has been confirmed from the dealership partially. They did not identify a cause for the sudden failure. However stated it could not be determined if this failure is or is not related to a previous major engine repair made a year ago. - The engine has been inspected by the dealership and warranty company. - There were no warning signals prior to either engine failures. The first one being a year ago for head gasket failure that allowed oil to mix with coolant. With the most recent failure the engine ticked briefly after braking to merge for construction, the oil pressure light followed by engine light turned on 5 seconds before engine completely lost power.

Filed Jul 6, 2026 · Engine · VA

Thermo Control Valve (TCV) causes a check engine light to come on and disables eyesight issue started May 29, 2026. The check engine would go on and off. Now it just stays

Filed May 20, 2026 · Electrical, Engine · CO

On [XXX] ~[XXX] PM, at highway speed on [XXX] eastbound near Frisco, CO (a mountain interstate), returning to Denver from Salt Lake City, my 2021 Subaru Crosstrek suddenly and without warning dropped into reduced-power limp mode and began lurching and shaking while the engine kept running. I lost the ability to accelerate or maintain speed. At the same moment the check engine light came on and multiple active safety systems automatically disabled: EyeSight, pre-collision braking, vehicle dynamics (traction/stability) control, and hill start assist. It took about two minutes to manage the lurching, power-limited vehicle across multiple lanes of traffic to reach the shoulder. My partner was in the vehicle. Had this happened on a bridge, a grade without a shoulder, a tunnel approach, or in heavier traffic, I believe a collision was a realistic outcome. The vehicle was towed to a Subaru dealer and diagnosed with a failed Thermo Control Valve. Sixteen trouble codes were stored, including P26A6, P0606, P060B, P2138, P2135, P2122, P2119, P2004, P2005, and P0191. Mileage was 49,983. There was no prior symptom. The vehicle had a full multi-point inspection at the same dealer only 11 days and ~1,400 miles earlier ([XXX]); nothing was flagged. This failure mode is already known to Subaru, addressed by Technical Service Bulletin 09-119-24 and a warranty extension to 15 years/150,000 miles; the dealer repair order confirms the TSB. I am concerned Subaru handles a safety-relevant failure, one that disables collision-avoidance systems at highway speed, through a quiet warranty extension rather than a recall or owner notification. Owners get no warning and discover it only when it fails dangerously. I request the federal safety agency open a formal safety defect investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 27, 2026 · Engine · OH

The vehicle shuddered violently when turning the ignition, and then failed to start entirely. The mechanic found that the engine coil was severely damaged, no external influence, just that it had become worn out remarkably fast. The vehicle has less than 60,000 miles and just 5 years in service. The repair will end up costing about 1500 with tows included and the vehicle has not gone without maintenance or care.

Filed Jul 21, 2025 · Electrical, Engine · 120,000 miles · MD

The contact owns a 2021 Subaru Crosstrek. The contact stated that while his daughter was driving at an undisclosed speed, the vehicle inadvertently lost motive power in the middle of the roadway. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the battery. The vehicle was repaired, but the failure reoccurred. The vehicle was towed to the dealer and diagnosed with head gasket failure. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 120,000.

Filed May 15, 2024 · Engine · CA

While driving down the freeway, all the warning lights came on and the engine sputtered and cut out. As we were in the left lane on a busy freeway, it put us at considerable risk. We were able to get to the left shoulder and get towed off the highway. This was caused, I later learned, by a faulty electronic thermostat which caused the system to fail.

Filed Sep 19, 2023 · Engine · 1,300 miles · FL · crash · 1 injury

The contact owned a 2021 Subaru Crosstrek. The contact stated that while parking and the brake pedal was depressed, the vehicle accelerated unexpectedly and collided with a wall. The collision was at the front of the vehicle. The air bags deployed. The driver sustained arm, leg, thumb, back, and nose injuries. Medical attention was needed. A police report was filed. The vehicle was towed to an impound lot. The manufacturer was not notified of the failure. The failure mileage was approximately 1,300.

Filed Sep 3, 2023 · Engine · NY · fire

Was driving on highway at approximately 65 mph. Check engine light came on. Engine started to stop responding to gas being given to car. Pulled off to exit highway approximately 1 minute after check engine light came on. At bottom of exit, car completely lost power. Attempted to put vehicle into park and wouldn't shift. Started to see smoke coming from engine and then shortly after started to see flames coming from engine. Immediately exited vehicle and called 911. No one was injured. Subaru indicated fire started as result of external influences. Insurance company's 3rd party auditors were not able to determine cause of fire.

Filed Aug 27, 2023 · Engine · WV

The issue is the Engine Coolant Bypass Valve. This causes the Engine to not take in as much coolant resulting in the engine getting much hotter than it should, thus putting those in the car’s safety at risk. This could ultimately lead to a fire and/or cause the car to suddenly lose power. My car already refuses to go above 3000 rpm’s and is very laggy when driving. The car itself shows a code that the bypass valve needs replaced & the check engine has come on. However, Subaru has failed to acknowledge that this is an issue amongst most of their vehicles since 2020. This issue also disables the Subaru Eyesight which is in control of adaptive cruise control, pre collision breaking, and sway warning. With those features now disabled, the car has lost the Safety Package that Subaru boasts. I have read on many online forums that this has been an ongoing issue now for many customers, a bulk of which experienced total engine failure. This lack of responsibly is putting many lives at risk on the road every day. I hope this helps shed light to this issue to Subaru & that this part is recalled so that Subaru must pay for the repairs instead of the car owners. Also, the repair part is around $500 & maintenance must be done by Subaru which is another $400-500 for labor. My opinion is they are using this defect as a way to make easy money on many customers since 2021. Here’s a link to the Service Bulletin that has been created about this issue:

Filed Mar 22, 2023 · Engine · MA

Engine shut off at a stop sign and the dashboard lit up like a Christmas tree with alarms sounding. Couldn’t get car restarted. Towed to Subaru dealer and they said there was a connector cable to the starter that was defective. Replaced at no cost.