2025 Subaru Forester: gas smell in the cabin

Filed Aug 13, 2026 · Fuel system · TX

Purchased new 2025 Subaru Forester Hybrid Sport on 01 May 2025 (owned 19 months). Approximately 156 DAYS (a little over 5 months) after purchase we began having trouble with an unknown fuel system defect which prevents the vehicle from being refueled, disables our hybrid system, disables safety features such as the vehicles eyesight system, cruise control, and RAB. Vehicle leaking strong gas smell. Issue has been increasing in frequency, occurring more often, and now escalating to leaking fuel all over the side of my car. I took my vehicle to the Subaru service center at the dealership for repairs on: 06 OCTOBER 2025 (~14,700 miles), 22 OCTOBER 2025 (17,394 miles), 09 MARCH 2026 (27,470 miles), 02 JULY 2026 (35,782 miles), 23 JULY 2026 (35,782 miles) To date, Subaru has been unable to identify the direct cause of the problem and replacing the gas cap is a bandaid on the unknown issue.

Filed Jul 19, 2026 · Fuel system · VA

the gas cap O ring recall was repaired previously by Casey Subaru of Newport News, VA. (I live in [XXX], purchased the vehicle in [XXX] at Ourisman Subaru) I filled my gas tank the night before this leak occurred. I noticed the smell of gasoline in my car at approximately 08 AM on the way to work. It was mild No obvious exterior leak. I drove my 25 commute to Williamsburg, Va. Upon leaving work I noticed a strong smell of gasoline inside the vehicle. Inspection of the exterior revealed an obvious gas leak (the fuel door to the gas cap was not opened at this time). the paint was wet and the paint adjacent to the plastic guard on the bumper side had bubbled due to the leak. The outside temperature was nearing 100 with a heat index of 105. I drove the vehicle to the dealership in Newport News (not aware I should have had it towed due to the leak). It has not been driven since. The fuel door was opened and there was an obvious leak as the well in the gas cap space was wet and the odor of gasoline was very strong. I twisted the gas cap and it did not close any farther. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 7, 2026 · Fuel system · 2,700 miles · VA

The contact owns a 2025 Subaru Forester. The contact stated that a few days after the dealer had serviced the vehicle under the federal safety agency Campaign Number: 26V106000(Fuel System, Gasoline), the contact refueled the vehicle at the gas station. The contact stated that upon entering the store and returning to the vehicle, the contact noticed both a strong fuel odor and fuel leaking from the fuel tank onto the ground. The contact used soap and water to clean up the area. The vehicle was driven and parked outside the residence's garage. The contact stated that if the fuel leak had gone unnoticed, the vehicle would have been parked inside the garage near a water heater's open flame, leading to a catastrophic fire that could have affected both the contact's family and nearby neighbors. The contact attempted to reach the dealer to report the failure, but had not yet received a return call. The manufacturer was notified of the failure and filed a case. The vehicle was not repaired. The failure mileage was approximately 2,700.

Filed Mar 19, 2026 · Engine, Fuel system · NM

Exhaust gas smell from the engine compartment when parked after driving. Garage smells like exhaust gases when left in enclosed garage - ongoing problem. Smell dissipates overnight. It has been inspected by Subaru dealers in Albuquerque and Santa Fe New Mexico. They report no error codes and so no problem. Have not had this issue on any other vehicle we've ever owned. There are no warning lamps or messages.

Filed Mar 13, 2026 · Fuel system · FL

I purchased a 2025 Subaru Forester Hybrid VIN [XXX] on July 26, 2025 from Schumacher Subaru, 3031 Okeechobee Blvd. West Palm Beach, Florida 33409. On March 11, 2026 I filled the gas tank to 100% capacity. The ambient temperature was 72 degrees Fahrenheit. I parked the vehicle in our garage with the door closed. Two hours later my wife notified me that there was a strong smell of gasoline throughout our four bedroom home. I opened the door to the gas filler recess and verified that the gas cap was correctly closed. Gas was spilled into and over the recess area below the gas cap, down the right side of the right back quarter panel and in a large puddle on the garage floor. I backed the Subaru out of the garage and onto the front driveway. Using multiple sheets of paper towels we mopped up the spilled gasoline from the vehicle and garage floor. I placed all the soiled paper towels in a sealed double garage bag and put it in our garden away from the house. I called Schumacher Subaru and talked with Dylan Wagner who sold us the car. I was shocked to hear that he knew of the gas cap defect and also knew that we should not fill the tank more than 50%. I asked him why he didn't notify us and he said that Subaru was going to notify us at the end on March 2026. In my view this is clear cut negligence on the part of Schumacher Subaru of West Palm Beach, Florida. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)