Tesla Model 3 grinding brakes problems

Filed Oct 27, 2026 · Steering · SC

The steering wheel makes a grinding noise when it automatically adjusts (when the car starts). It also makes the same grinding noise when I adjust it

Filed Oct 22, 2026 · Steering, Suspension · VA

2021 Tesla Model 3 with approximately 110,000 miles. Loud creaking/squeaking noise from the front suspension (primarily passenger side) when driving at low speeds over bumps and during slow turns. The noise matches the known front upper control arm ball joint water intrusion issue documented in Tesla service bulletin SB-20-31-006 and widely reported by other Model 3 owners. No warning lights, messages, or other symptoms. The component is available for inspection. I have scheduled a service appointment with Tesla but the vehicle has not yet been inspected or repaired by the manufacturer or any independent shop. While currently only a noise (NVH) issue, progressive wear of this ball joint can lead to play in the suspension, uneven tire wear, degraded steering feel, and potential loss of control if the joint fails.

Filed Oct 9, 2026 · Suspension · NY

The owner reported a grinding noise coming from the front of the vehicle. The vehicle was taken to the Tesla Service Center in [XXX], where it was diagnosed on XXX, at 47,821 miles. Diagnosis found the front suspension required replacement of the front lower lateral links (left and right), the front lower compliance links (pair), and both front upper control arms. The repair was performed onXXX. The owner paid $2,035.20 because Tesla said the basic warranty had expired by time on XXX, although the vehicle was under the 50,000-mile limit. There was no crash, no fire, and no injury. The concern is premature failure/wear of the complete front suspension link set at under 50,000 miles. These suspension links are safety-critical components affecting steering and vehicle control, and failure or detachment could affect handling. The problem was confirmed and repaired by the Tesla service center. The symptom prior to repair was the grinding noise from the front; no warning lamps are known. Whether the replaced components are available for inspection is UNKNOWN. The failed components are the same front suspension lateral links addressed by the federal safety agency recall 21V835 (this vehicle was checked and is NOT in that recall population) and the front lower lateral link detachment under the federal safety agency investigation PE26006. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 10, 2026 · MD · crash

Tesla Full Self Driving (FSD) failed us, resulting in a side swipe with a tractor trailer and the likely total loss of our Model 3. We were under FSD for much of our trip from [XXX] to [XXX]. We were in [XXX], traveling north on [XXX] in the right lane with a tractor trailer in the center lane. The car made a sudden, violent turn to the right. The startled driver grabbed the wheel to bring the car back to the lane center, which resulted in a major grinding noise. The driver then brought the car to a safe stop on the shoulder. It became clear the left side of our vehicle had contacted the trucks right front wheel. The truck left the scene. I believe the truck either came close to its lane right line or actually was changing lanes. The car took evasive action. However, the car failed to communicate the situation to the driver, which is the reason for filing this report. It is possible that had FSD activated the horn, both driers would have acted more appropriately and the loss of our car might have been avoided. Other possibilities are for FSD to have some method to communicate what was happening or had refused to permit the driver to bring the car into contact with the truck. It may be beneficial for the federal safety agency to request a copy of the car’s data before it is deleted after the car is declared a total loss; especially since there isn’t any Dash Cam video of the incident. The dash cam’s most recent video was several weeks previous and includes GB of video taken in our garage. But nothing from the trip. I believe Tesla will record this as driver fault rather than FSD’s fault. Technically, at the time of contact, the driver was in control because, from the drivers point of view, FSD acted randomly. The real cause, in my opinion, was a failure of communication and poor handoff of control. There is a Pennsylvanian State Police report and we have filed with our insurance company, but I don’t expect either to investigate FSDing’s role in this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

Filed Aug 15, 2026 · Suspension · TX

My 2021 Tesla Model 3 with approximately 70,000 miles developed front suspension problems. It began with squeaking, creaking and groaning, similar to a rusty playground swing, especially while turning or when the suspension moved. The noise was worse in hot weather and progressively became extremely loud and constant during normal driving. I also began hearing intermittent knocking/"bonking" or clunking. I could even hear the suspension when the vehicle compressed as I sat in the driver's seat. There were no warning lights or messages. Tesla inspected the vehicle and diagnosed both front lower lateral links and both front lower compliance links as needing replacement, along with an alignment. Tesla estimated approximately $1,960. CPR EV Repair replaced the diagnosed lower suspension components. After removal, the bushings showed significant visible deterioration, including cracked, torn and separated rubber around the inner sleeves. CPR EV also advised that the front upper control arms were worn and would need replacement. I was concerned for my safety because failure or separation of a deteriorated front suspension component while driving could affect steering or vehicle stability and potentially cause loss of control. Although I did not experience a complete separation or crash, the rapidly worsening and eventually constant symptoms made me concerned about continuing to drive. I have Tesla's estimate, CPR EV documentation and photographs of the deteriorated components after removal.

Filed Aug 10, 2026 · Suspension · NY

Lots of creaking and grinding noises coming from both front upper control arm bushings. Steering starting to become less stable.

Filed Aug 4, 2026 · Suspension · CA

I own a Tesla Model 3 and have been experiencing concerning front suspension and steering issues that appear to be worsening over time. While driving and especially during low speed turns, parking and maneuvering, the front suspension produces loud screeching, squeaking, and rubbing noises. The steering has also become noticeably stiffer that normal at times, and the noises can be felt through the steering wheel. The sounds are coming from the front suspension area and occur repeatedly during normal driving. The issues raises significant safety concerns because I am worried there may be a defect affecting the front suspension of steering components. Unexpected steering resistance combined with loud suspension noises creates concern that a suspension component could fail while the vehicle is in motion, potentially resulting in loss of steering control or a crash. There were no warning lights or messages displayed before or during these symptoms. The vehicle has not been involved in any collision that would explain these symptoms. The problem has continued during normal operation and appears to be getting progressively worse. The vehicle is available for inspection upon request. I am submitting this complaint because I understand the federal safety agency is investigating front suspension issues involving 2018-2020 Tesla Model 3 vehicles, and my vehicle is experiencing similar symptoms. I believe this issue should be investigated to determine whether it is related to the front suspension components under investigation.

Filed Aug 3, 2026 · Suspension · DC

Over a period of several weeks, the front suspension increasingly made noise (squeaking and groaning) and felt loose when turning and going over bumps. The front control arms were replaced 10/31/24. The problem has begun recurring over the last few months, with the same noise occurring and progressively worsening.

Filed Aug 2, 2026 · Suspension · IA

I am filing this complaint in direct relation to the federal safety agency Preliminary Evaluation PE26006 regarding Tesla front suspension lower lateral link failures. I am the owner of a 2018 Tesla Model 3. On XXX, at approximately 101,728 miles, my vehicle experienced a severe suspension issue. The vehicle began producing a loud, frequent squeaking and rattling noise originating from the front passenger-side wheel area while driving under 40 mph. Due to the clear mechanical risk and safety concerns associated with a suspension failure, I brought the vehicle to the Tesla Service Center in [XXX]. Tesla technicians diagnosed the problem and confirmed a failure in the front suspension. The repair required the complete removal and replacement of both front lower lateral links (Tesla Part Number: 1044341-00-E) and accompanying hardware. Because the vehicle was past its standard warranty mileage, I was forced to pay $1,291.75 out of pocket for the total repair, which included $583.68 explicitly for the lower lateral link parts and associated labor/alignment. While my lower lateral link did not completely separate while driving at high speed, the component failed prematurely and exhibited the exact structural degradation currently being investigated by the federal safety agency Office of Defects Investigation. I have retained the official Tesla service invoice (Invoice # XXX) to verify this failure, the diagnosis, and the out-of-pocket repair costs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 1, 2026 · Lights, Suspension · CA

Suspension is grinding. I had it replaced once at Tesla and it began grinding again in less than 18 months. I took it to Tesla and was informed the lower control arm failed and the price had more than doubled from the prior replacement. No warning lights have come on regarding this issue. The original replacement was 3/7/2024. I noticed the grinding between 12-18 months later. Also, the rear brake light gets condensation in it somehow. I had noticed this about 1 year ago.