Tesla Model 3 power steering loss problems

Filed Oct 30, 2026 · Steering, Suspension · CA

I am reporting a premature and severe multi-component front suspension failure on my 2020 Tesla Model 3 that poses a serious steering and control safety hazard. While driving and turning at low speeds (such as parking), the front end began emitting a loud mechanical clicking and popping sound. A certified technician diagnosed the vehicle and found that multiple critical suspension components had failed or worn prematurely at just 55,089 miles. The failures include the front lower lateral links, front lower compliance links, front upper control arms, stabilizer bar and front end hubs failing completely and simultaneously. This is a well-documented issue among 2018–2020 Model 3 vehicles and is currently the subject of an active the federal safety agency Preliminary Evaluation investigation regarding front lower lateral link detachment. Premature failure of these load-bearing suspension components compromises the vehicle’s structural integrity, accelerates extreme tire wear, and presents an immediate risk of component separation or sudden loss of steering control at high speeds. Tesla should issue a safety recall for these defective suspension components and compensate owners for out-of-pocket repairs.

Filed Oct 25, 2026 · Steering, Suspension · OH

The front left and right lower link assemblies suffered premature structural failure and required immediate replacement at 74,068 miles due to a loss of steering stability. The repair was completed at a Tesla Service Center out-of-pocket for a total cost of $1,564.04

Filed Oct 25, 2026 · Steering, Transmission · FL · crash

Subject: Vehicle Safety Complaint — 2024 Tesla Model 3 RWD — Sudden Loss of Steering Control and Total-Loss Crash I am submitting this complaint concerning a serious safety incident involving my 2024 Tesla Model 3 Rear-Wheel Drive. While driving manually on a wet highway in [XXX], my vehicle suddenly moved sideways and began to lose control. I was not using Autopilot or Full Self-Driving. Despite my attempt to maintain control using the steering wheel, I was unable to steer the vehicle back under control. The vehicle left the roadway and entered a pond, resulting in a total loss. I have video footage documenting the incident and surrounding road conditions. I am concerned that this incident may have involved a vehicle safety defect, potentially involving the steering system, electronic stability control, traction-control system, or another vehicle system responsible for maintaining directional control. I understand that wet-road conditions and hydroplaning are possible explanations; however, I believe the reported inability to regain steering control warrants a thorough technical investigation rather than assuming that weather alone caused the crash. I request that the federal safety agency review this incident for potential safety implications involving the 2024 Tesla Model 3 RWD and determine whether similar complaints or technical findings may indicate a broader safety issue. I also request that Tesla preserve all available vehicle telemetry, diagnostic logs, fault codes, steering-system data, wheel-speed information, and electronic stability-control records associated with the incident. Vehicle information * Make and model: Tesla Model 3 * Model year: 2024 * Drivetrain: Rear-Wheel Drive * Driving mode: Manual * Incident location: [XXX] * Weather: Wet roadway / rain * Outcome: Vehicle left the roadway and entered a pond; total loss * Evidence available: Video footage INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 16, 2026 · Steering · CA

The steering assist reduced alert popped up on the tesla screen. While attempting to turn into a parking garage, a "steering assist reduced" alert suddenly appeared on the tesla screen, and the steering wheel locked up/became extremely heavy and unable to steer left or right. Because the steering assist failed in active traffic at the entrance, the vehicle was temporarily stranded, exposing to oncoming traffic and created an immediate risk. Failed component: electronic power-assisted steering (EPAs) rack and steering gear assembly. The failed component was replaced by Tesla and is not available for personal inspection. Safety risk: The sudden loss of steering ability in active traffic prevented normal maneuvering, forcing the vehicle into a hazardous position where passing vehicles could have collided with it. The issue was confirmed by Tesla Service, who performed a full steering rack replacement. The vehicle was inspected and repaired directly by the manufacturer (Tesla Service Center). There were no warning lights or symptoms prior to the incident; the failure and "steering assist reduced" error appeared abruptly during the turn.

Filed Sep 15, 2026 · Steering · 81,000 miles · CA

The contact owns a 2018 Tesla Model 3. The contact stated that while driving 4 MPH, the front sway bar detached from the vehicle, and the contact lost steering control. The vehicle was towed, and a service center was contacted but informed the contact that the repair was not covered because the VIN was not included in a recall associated with the failure. The failure mileage was approximately 81,000.

Filed Sep 10, 2026 · Suspension · CA

I am filing an official safety complaint regarding a severe, premature failure of the front lower suspension system on my 2023 Tesla Model 3. While operating the vehicle, the front lower compliance links (Part numbers: 2188359-10-B, 2188354-10-B) and the lower lateral links (Part number: 1044341-00-G) suffered critical mechanical bushing degradation and structural wear, rendering the front suspension unsafe and compromised.This mechanical breakdown occurred at only 63,584 miles on a three-year-old vehicle under completely normal, standard highway and suburban driving conditions. There has been absolutely no external impact, wheel strike, curb strike, or collision to explain a simultaneous, symmetrical breakdown of multiple heavy suspension components on both the left and right sides of the vehicle. My tires show zero sidewall damage and the wheels have no structural bends, proving the issue is an inherent component lifecycle defect rather than a road hazard.This issue directly correlates with the federal safety agency Preliminary Evaluation PE26006, which investigates nearly 1.2 million Tesla Model 3 and Model Y vehicles for front lower lateral and compliance link failures. When seeking service, Tesla Service Center personnel attempted to classify this wear due to structural degradation but deny warranty or goodwill coverage. This component vulnerability represents an acute safety risk, as a total failure or detachment of these specific lower links while traveling at high speeds could cause a catastrophic, immediate loss of steering control. I request that the federal safety agency include this vehicle in its ongoing investigation to push for a mandatory safety recall.

Filed Sep 8, 2026 · Suspension · CA

During a routine inspection by an independent mechanic, it was discovered that the front lower compliance link (control arm) bushings are severely cracked on both the left and right sides of my 2018 Tesla Model 3. Both the compliance links and the lateral links require immediate replacement to prevent a catastrophic structural failure. Tesla Service has provided a repair estimate of $2,012.00 to fix the issue, which they are refusing to cover under warranty or past recalls. Safety Consequence: Cracked and failing compliance link bushings compromise the structural integrity of the front suspension. If these suspension links completely separate or fail while driving at highway speeds, it could cause an immediate loss of steering control, severe wheel misalignment, or a wheel detachment, creating an extreme risk of a high-speed crash. Relevance to Active Investigations: I am filing this complaint specifically to be included in the federal safety agency's active Preliminary Evaluation (PE26006) regarding front lower suspension link detachments on 2018–2020 Model 3 vehicles. The failure of my vehicle's compliance links demonstrates that the front suspension components on early Model 3 production units are experiencing premature structural degradation and wear that goes well beyond the scope of Tesla's previously limited lateral link recalls (23V‑235 and 21V‑835).

Filed Aug 20, 2026 · Steering · NJ

My 2022 Tesla Model 3 has experienced recurring intermittent loss/reduction of power steering assistance. The vehicle displays “Steering assist reduced – Steering may require increased effort.” The problem has occurred multiple times over a period of months and may disappear after the vehicle is power cycled or the alert clears. Tesla previously evaluated the vehicle for this condition. On July 8, 2026, Tesla documented the steering-assist-reduced complaint and recommended replacement of the RWD steering rack/steering gear, with an estimated repair cost of approximately $3,018. On August 20, 2026, the warning occurred again. Tesla Service Mode recorded fault EPAS3S_a005_sent2Mia, described as “Torque Sensor 2 signal not received,” with the potential impact listed as “Steering assist reduced.” The vehicle simultaneously generated UI_a020_SteeringReduced. The warning subsequently cleared again, but this is a recurring intermittent failure involving the vehicle’s electronic power-assisted steering system. I am concerned that the steering assistance could become reduced or unavailable while driving. Tesla has already determined that replacement of the steering rack is required, but the repair is customer-pay. I am reporting this because this appears to be a recurring safety-related steering defect and I am concerned that other vehicles may experience the same failure.

Filed Aug 4, 2026 · Suspension · CA

I own a Tesla Model 3 and have been experiencing concerning front suspension and steering issues that appear to be worsening over time. While driving and especially during low speed turns, parking and maneuvering, the front suspension produces loud screeching, squeaking, and rubbing noises. The steering has also become noticeably stiffer that normal at times, and the noises can be felt through the steering wheel. The sounds are coming from the front suspension area and occur repeatedly during normal driving. The issues raises significant safety concerns because I am worried there may be a defect affecting the front suspension of steering components. Unexpected steering resistance combined with loud suspension noises creates concern that a suspension component could fail while the vehicle is in motion, potentially resulting in loss of steering control or a crash. There were no warning lights or messages displayed before or during these symptoms. The vehicle has not been involved in any collision that would explain these symptoms. The problem has continued during normal operation and appears to be getting progressively worse. The vehicle is available for inspection upon request. I am submitting this complaint because I understand the federal safety agency is investigating front suspension issues involving 2018-2020 Tesla Model 3 vehicles, and my vehicle is experiencing similar symptoms. I believe this issue should be investigated to determine whether it is related to the front suspension components under investigation.

Filed Jul 10, 2026 · Airbags, Electrical · WA

I am getting an electrical fault which has disabled my front passenger seat airbags. They need to replace the wiring, which means they also now need to replace the passenger airbag itself because wiring has changed and the old airbag is not compatible with the new wiring. Replace Occupant Classification System (OCS) of Front Passenger Seat while Servicing Subcomponents Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat I had this same error 4 months ago and it ended up shorting out the entire electrical system, which disabled autosteer and eventually completely disabled power steering which made the car unusable. Tesla service center called it a water intrusion problem and had to replace the entire front electrical harness system and steering rack costing $4500. Now the problem has resurfaced and I'm afraid I might lose power steering again which is extremely dangerous and could happen any time, in addition to my airbags potentially not deploying.