2023 Tesla Model 3: loss of power steering

Filed Sep 10, 2026 · Suspension · CA

I am filing an official safety complaint regarding a severe, premature failure of the front lower suspension system on my 2023 Tesla Model 3. While operating the vehicle, the front lower compliance links (Part numbers: 2188359-10-B, 2188354-10-B) and the lower lateral links (Part number: 1044341-00-G) suffered critical mechanical bushing degradation and structural wear, rendering the front suspension unsafe and compromised.This mechanical breakdown occurred at only 63,584 miles on a three-year-old vehicle under completely normal, standard highway and suburban driving conditions. There has been absolutely no external impact, wheel strike, curb strike, or collision to explain a simultaneous, symmetrical breakdown of multiple heavy suspension components on both the left and right sides of the vehicle. My tires show zero sidewall damage and the wheels have no structural bends, proving the issue is an inherent component lifecycle defect rather than a road hazard.This issue directly correlates with the federal safety agency Preliminary Evaluation PE26006, which investigates nearly 1.2 million Tesla Model 3 and Model Y vehicles for front lower lateral and compliance link failures. When seeking service, Tesla Service Center personnel attempted to classify this wear due to structural degradation but deny warranty or goodwill coverage. This component vulnerability represents an acute safety risk, as a total failure or detachment of these specific lower links while traveling at high speeds could cause a catastrophic, immediate loss of steering control. I request that the federal safety agency include this vehicle in its ongoing investigation to push for a mandatory safety recall.

Filed Jun 8, 2026 · Steering · CA · crash · 2 injuries

While making a right turn from a near-stopped position, the steering wheel became stuck or extremely difficult to turn. The vehicle initially turned right normally, but when I attempted to steer back left/counterclockwise to complete the turn and straighten the vehicle, the steering wheel did not respond as expected. This caused the vehicle to continue in the wrong direction and resulted in a collision. I believe the electronic power steering assist system malfunctioned or failed. My concern is that the power steering assist experienced an overstress condition, causing a loss of power steering assist after the vehicle almost reached a stop and then accelerated again. This put my safety and the safety of others at risk because I was unable to steer the vehicle as intended during a low-speed turning maneuver.

Filed Jan 17, 2024 · Driver assistance, Steering · TX

I am writing to report several safety issues that I have experienced with my Tesla Model 3. These issues pose a significant risk to my safety and the safety of other road users. I kindly request that you investigate these matters thoroughly and take appropriate action to address them. 1. Steering Wheel Failure: On three separate occasions, the steering wheel of my Tesla Model 3 suddenly stopped working. Two of these incidents occurred while driving on the highway, which made it extremely difficult for me to maintain control of the vehicle. This sudden loss of steering functionality is a serious safety concern and could potentially lead to accidents and injuries. 2. False Forward Collision Warnings: The car's forward collision warning system has been providing false warnings, which has had a negative impact on my insurance premiums. Despite the fact that my insurance company is aware of the issue and acknowledges that it is a system failure, they have been automatically increasing my insurance rates on the leased vehicle. This has resulted in a significant financial burden, with my insurance premium increasing from $120 to almost $400 per month. Furthermore, I have been informed that next month, my premium will be raised to $600. I would like to emphasize that I have a clean driving record with no previous accidents or traffic violations. 3. Slow Charging Speed: Another issue I have encountered is the extremely slow charging speed of the vehicle. Despite the fact that the Tesla Model 3 is rated at 160 kW/h, it consistently charges at a maximum rate of 50 kW/h, regardless of the charging location or time. This significantly limits the usability. Took the vehicle to the Tesla service center twice. However, they said that they have been unable to replicate the steering wheel failure which would be crazy if they could replicate it every time the car is driven. and they have dismissed the slow charging speed as a normal variation and it's not. Disregarding safety!

Filed Jan 5, 2024 · Steering · FL

The car lost power steering while driving

Filed Dec 11, 2023 · Driver assistance, Steering · CA · crash

Summary: FSD malfunctioned, failed to disengage, causing loss of steering control, thus causing car to steer into wrong lane and resulting in an accident. Tesla Service Center refused to inspect unless car is fixed. Car was sent to Crash Champions ( autobody shop) and was quoted $35k to fix. Car was deemed as totaled by Tesla insurance. No response from [email protected] I suspect that the latest FSD software update has caused my car to lose control. Time of incident: 19:28 pm Location : [XXX] , [XXX] Entering from [XXX] . Weather condition: Clear night, well lit. Low traffic. What happened: My car has been driving in FSD on Lawrence Expressway and it was doing everything correctly. Approaching that upcoming tight bend, the FSD slowed down the car, and I took over by steering the steering wheel to the right to deactivate FSD and taking the tight turn, right before the white rows of triangles on the street. At this moment, the steering wheel forcibly turned to the opposite direction (i.e. left). I tried to correct the steering wheel by turning right even more, but the steering wheel wasn’t responding to my input for a split second. At this moment, my car is now on the wrong lane of Wildwood Ave and my car finally responded to my steering input. I had to swerve in the opposite direction to avoid the incoming traffic and ended up brushing against an SUV, followed by an impact on the curb, before finally slowing down. Seeing that there was incoming traffic from the back, I drove down to a residential street to park my car for safety reason. The SUV driver called the police to handle the situation, we had our information and testimonies recorded down. I have already followed the safe practices of driving with FSD according to the manual, but in this situation, I am not certain which technology is responsible for causing my car to override my manual steering input. This led to me to question the driver safety systems in this car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5

Filed Oct 17, 2023 · Steering · GA

Lost power steering while driving. Luckily this occurred while I was going less than 5mph and near a parking lot, so was able to muscle the steering to a safe place. Received a warning from the car that “steering assist is reduced” randomly. Luckily we were going slowly and able to find a safe place to park, so my wife and kids were safe. Could barely turn the wheel enough to park safely. Once restarted a few hours later power steering worked again. Car has now been in a manufacturers shop for a week to try and figure out the issue.

Filed Sep 22, 2023 · Driver assistance, Steering · GA

Power steering stopped working when the car starts up, Cannot steer the wheel at all in PDNR. Basically cannot steer the car at all and it is not drivable.

Filed Sep 20, 2023 · Steering · CA

The power steering failed while I was backing out of a parking space. I was unable to turn the wheel and almost ran into another car. I was able to use all my strength to turn the wheel and took it to the dealership Tesla said "there was a fault within the steering rack that caused the power steering to go out, therefore we had to replace this part" There was no warning messages about the problem before, during or after the steering went out. If this were to happen to anyone that did not have significant strength, it could have caused a major accident. If it went out while I was driving on any other road, I would have been in an accident for sure.

Filed Sep 14, 2023 · Steering · TX

Power steering is intermittently and unpredictably failing. The issue has occurred approximately 10 times in total and has occurred both while exiting parking spots and while driving on the road. The vehicle is available for inspection upon request and has been given to Tesla Service Center for review. The service representative was not able to reproduce the issue and the vehicle was returned. Especially while driving, loss of power steering could force me into an accident, as I'm not able to control the vehicle in a reliable manner. When the issue occurs, I receive an error that says "steering assist reduced, steering may require increased effort."

Filed Sep 13, 2023 · Steering · CA

Loss of power steering. Car started normally, but with no warning from the car, the steering wheel could be turned only with extreme effort. I tried to make a circle around the house, but barely avoided hitting other parked cars and called Tesla service.

Filed Aug 23, 2023 · Steering · AZ

Steering wheel locked up while operating not allowing me to turn the wheel. Loss of power steering and control. Screen displaying error "Steering assist reduced" when in reality was completely unable to steer. Vehicle still powered and accelerated however no control over steering.

Filed Aug 22, 2023 · Steering · AZ

Car lost power steering without warning