2018 Tesla Model 3: loss of power steering

Filed Oct 25, 2026 · Steering, Suspension · OH

The front left and right lower link assemblies suffered premature structural failure and required immediate replacement at 74,068 miles due to a loss of steering stability. The repair was completed at a Tesla Service Center out-of-pocket for a total cost of $1,564.04

Filed Sep 15, 2026 · Steering · 81,000 miles · CA

The contact owns a 2018 Tesla Model 3. The contact stated that while driving 4 MPH, the front sway bar detached from the vehicle, and the contact lost steering control. The vehicle was towed, and a service center was contacted but informed the contact that the repair was not covered because the VIN was not included in a recall associated with the failure. The failure mileage was approximately 81,000.

Filed Sep 8, 2026 · Suspension · CA

During a routine inspection by an independent mechanic, it was discovered that the front lower compliance link (control arm) bushings are severely cracked on both the left and right sides of my 2018 Tesla Model 3. Both the compliance links and the lateral links require immediate replacement to prevent a catastrophic structural failure. Tesla Service has provided a repair estimate of $2,012.00 to fix the issue, which they are refusing to cover under warranty or past recalls. Safety Consequence: Cracked and failing compliance link bushings compromise the structural integrity of the front suspension. If these suspension links completely separate or fail while driving at highway speeds, it could cause an immediate loss of steering control, severe wheel misalignment, or a wheel detachment, creating an extreme risk of a high-speed crash. Relevance to Active Investigations: I am filing this complaint specifically to be included in the federal safety agency's active Preliminary Evaluation (PE26006) regarding front lower suspension link detachments on 2018–2020 Model 3 vehicles. The failure of my vehicle's compliance links demonstrates that the front suspension components on early Model 3 production units are experiencing premature structural degradation and wear that goes well beyond the scope of Tesla's previously limited lateral link recalls (23V‑235 and 21V‑835).

Filed May 23, 2026 · Steering · NH

After an over the air software update this past week 2026.14.6 my Tesla Model 3 power steering has failed. EPAS shows ACTICE in service mode, calibration was successfully completed and there are no active EPAS/rack faults. Power steering assists at higher speeds but fails below 20mph. Tesla has a history of steering related software problems and needs to take ownership of the problem.

Filed May 18, 2026 · Suspension · CA

Tesla model 3 2018 long range 86k miles. While driving 50mph on freeway the lower control arm link separated from the frame. No impact, no damage, and no pothole/bump. Lost steering and was able to get to side of road. When I got out and look at vehicle the control arm was disconnected from the frame. The frame showed no damage and the control arm showed no damage. The mounting holes for each here intact and no damage. Appears that bolt fell out or sheared off and the control arm disconnected. This is a safety failure and was scary. I towed to Tesla and they claim that failure was form worn parts and tolerances. I stated how could this be worn parts when mounting holes are in excellent condition. They are refusing to help with cost of repair and quoted me $2800. They are not taking responsibility and I believe that others should know of this failure. I believe I am being wronged and would like to report. Thanks.

Filed Apr 21, 2026 · Body, Steering · CA

The front lateral links, compliance links, and stabilizer bar link on my 2018 Tesla Model 3 Long Range failed and required replacement in January 2026. Prior to failure, abnormal creaking and clunking noise from the front suspension began appearing weeks before the repair — no warning lights illuminated at any point. The failed components were replaced by a Tesla-certified Service Center and are no longer available for inspection. The failure was confirmed and repaired solely by the Tesla Service Center; no police, insurance representatives, or other parties inspected the vehicle. I was charged out of pocket for this repair. The lateral link separation risk directly endangers vehicle safety — if a fastener loosens sufficiently, the lateral link can detach from the subframe, causing sudden wheel misalignment and loss of steering control, which could result in a crash at any speed. Tesla issued recall 23V‑235 (the federal safety agency campaign 23V235000) in March 2023 for this exact condition on 2018-2019 Model 3 vehicles. My vehicle's VIN was not included in the recall population, yet experienced the identical failure mode. I am requesting this complaint be considered for recall expansion under 23V‑235 and seeking reimbursement for out-of-pocket repair costs for a defect Tesla has already acknowledged in identical vehicles.

Filed Feb 26, 2026 · Steering, Suspension · CA

The front lower lateral link (rearward lower control arm) fastener/bolt completely backed out and fell off the vehicle while in motion, causing the lateral link to separate entirely from the subframe. This is the exact mechanical failure described in Tesla Recall Campaign 23V‑235 (Service Bulletin SB-23-31-001), however, my specific VIN was not included in that recall. The vehicle and components are currently at an independent EV repair facility and are available for inspection upon request. Photographic evidence of the missing bolt and separated control arm has been retained. The separation of the lower lateral link caused an immediate and violent collapse of the front passenger-side suspension geometry. The affected wheel was no longer anchored to the vehicle frame, causing it to fold backward and grind heavily against the wheel well. To keep the vehicle moving straight, the steering wheel had to be turned to an extreme 45-degree angle. This resulted in a near-total loss of steering control. Had this fastener failed while traveling at highway speeds instead of low speeds, it would have resulted in an uncontrollable, catastrophic collision. Yes. The problem was physically confirmed and documented by an independent, EV-certified repair facility (EVFixMe/Shocker Motors in Costa Mesa, CA) once the vehicle was placed on a lift. The vehicle was physically inspected by an independent service center. The manufacturer (Tesla) was contacted via the Tesla App; however, they refused to perform a physical diagnosis without pre-authorization of a $2,600+ comprehensive suspension replacement estimate and stated the vehicle was out of warranty with no open recalls. There were no dashboard warning lamps, digital alerts, or error messages from the vehicle's computer system prior to the failure. The failure presented suddenly as a loud, painful metal-on-metal grinding noise accompanied by immediate, severe steering misalignment. Currently waiting on invoice from indy shop.

Filed Nov 5, 2025 · Steering · FL

I own a 2018 Tesla Model 3. The vehicle experienced a sudden loss of steering assist while driving, and the steering wheel became extremely difficult to turn, eventually locking up to the point where the vehicle could no longer be safely controlled. There were dashboard warnings related to steering and low-voltage system faults. The vehicle had to be towed because it was unsafe and not steerable. This is the second time within a few months that the vehicle has become inoperable and required a tow. The first failure involved a low-voltage electrical fault that prevented the car from charging or driving. The most recent failure involved the steering rack and a front-end controller component. Tesla diagnosed the issue as requiring replacement of the steering rack and a front controller assembly. The repair cost was quoted at approximately $4,200 out of pocket, and Tesla stated the failure was not covered under warranty and not related to the earlier electrical issue. No recall was listed for this VIN. There was no crash, but steering control was lost while the vehicle was in motion, which created a safety hazard. I am reporting this because a sudden loss of steering function while driving is a serious safety defect that could lead to a collision if it occurs at higher speeds or in traffic.

Filed May 5, 2024 · Steering · NJ

Power Steering stopped working suddenly while driving. This was a OEM part replaced on 2021 Aug 30. The car was unable to be controlled and luckily I was driving at slow speed when I realized this issue. This issue happened without any warning and there should be monitoring if this fails and warn the customer to take necessary precautions. Also wondering if the warranty of 1 year for a part like this is sufficient and customer to bear 2750$ cost to replace is a big burden to an average consumer especially if not his fault.

Filed Jan 9, 2024 · Steering · WA

Lost power steering. It started working again, but the dealership recommended a replacement due to corrosion which amounted to around 4k. Comprehensive insurance would not cover since the damage was gradual and not immediate.

Filed Jan 6, 2024 · Steering · ME

Power steering went out in August 2023. It would go back on temporarily intermittently after turning the vehicle off and then on, but ultimately went out for good.

Filed Oct 19, 2023 · Steering · CA

When driving couple of days back an alert "UI_a020 stating steering assist disabled" appeared on screen and the steering became stiff. Luckily I was on local road; so I slowed down and pulled over. This could cause a big safety issue if I am on a highway and unable to steer easily at high speed. I contacted Tesla; they suggested getting the steering rack replaced for ~$3000. This is a basic safety issue; fixing it should be covered by Tesla.