2018 Tesla Model 3: ball joint or control arm failure

Filed Oct 26, 2026 · Steering, Suspension · CA

I drove over a bump in the road and all of a sudden the car started making a very loud clunky noise in the front suspension. I was close to home so I turned around and drove it back home for inspection. I found the lower control arm on the suspension is completely disconnected because the bolt is backed out of the joint. The steering had occasionally made some creak sounds in the past but it never felt loose. Seeing the lower control arm disconnected could have severely limited the steering of the vehicle thus this seems like a serious safety issue. I have scheduled an appointment for repair with Tesla Service.

Filed Oct 17, 2026 · Steering, Suspension · OR

This is to serve as a registered complaint in conjunction with the premature component failure and degradation of front lower lateral links and suspension parts under the federal safety agency investigation PE26006. In August 2026 while operating my 2018 Tesla Model 3 while driving at all speeds experienced a failure of the front suspension system. There was an intense creaking/groaning/clunking noises from the front wheels and/or front suspension that we felt extremely uncomfortable operating the vehicle fearing for the safety of the passengers. Upon taking the vehicle to the Tesla Service Center, technicians diagnosed the vehicle with severely degraded and failing front lower arms, compliance links, and control arm bushings. My vehicle only had a little over 29,000 total miles on the odometer. This premature degradation represents a critical component failure rather than standard wear and tear. A failure or detachment of the lower lateral link at highway speeds presents an immediate safety risk due to potential loss of directional steering control. This failure is directly identical to the conditions outlined in the federal safety agency Office of Defects Investigation Preliminary Evaluation PE26006, opened on July 29, 2026, targeting front lower lateral link failures on 2018–2020 Model 3’s. The issue has since been repaired by Tesla Service on October 6, 2026. I am filing this complaint to formally document this premature safety component failure for the ongoing PE26006 federal investigation. We stopped driving the vehicle and used our other cars, waiting for appointments at Tesla, as well as waiting for the parts to arrive, which took quite a while. Thankfully, we had a couple other cars that we were able to use while we were waiting for the repair to be performed.

Filed Oct 2, 2026 · Suspension · CA

There was a clicking noise that was heard as my wife (along with our [XXX] son) was driving on the freeway. She reached her destination and once she parked and tried to move out of the parking lot, she could not turn the wheel. The suspension control arm (specifically, the inner mounting eyelet and bushing of a front lower link) has detached and dropped down beneath the underbody shield. After taking it to Tesla Collision, it is reported that the front lateral link completely disconnected from the subframe while driving. Tesla has acknowledged this as there is an active bulletin (Service Bulletin SV-23-31-001) for torque check on this component. This issue is also identical to the HTSA Recall 23V‑235, however, our VIN is not included in the batch. Tesla is quoting around $7k for repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 8, 2026 · Suspension · CA

During a routine inspection by an independent mechanic, it was discovered that the front lower compliance link (control arm) bushings are severely cracked on both the left and right sides of my 2018 Tesla Model 3. Both the compliance links and the lateral links require immediate replacement to prevent a catastrophic structural failure. Tesla Service has provided a repair estimate of $2,012.00 to fix the issue, which they are refusing to cover under warranty or past recalls. Safety Consequence: Cracked and failing compliance link bushings compromise the structural integrity of the front suspension. If these suspension links completely separate or fail while driving at highway speeds, it could cause an immediate loss of steering control, severe wheel misalignment, or a wheel detachment, creating an extreme risk of a high-speed crash. Relevance to Active Investigations: I am filing this complaint specifically to be included in the federal safety agency's active Preliminary Evaluation (PE26006) regarding front lower suspension link detachments on 2018–2020 Model 3 vehicles. The failure of my vehicle's compliance links demonstrates that the front suspension components on early Model 3 production units are experiencing premature structural degradation and wear that goes well beyond the scope of Tesla's previously limited lateral link recalls (23V‑235 and 21V‑835).

Filed Aug 12, 2026 · Suspension · FL

While driving, I noticed that the vehicle suddenly began pulling to the right. There were no warning lights, warning messages, or alerts displayed on the vehicle's screen before I noticed the problem. I took the vehicle to the Tesla Service Center and reported that the vehicle was pulling to the right. The service center determined that the issue was likely related to the front suspension and recommended replacement of the front lower lateral links, front lower compliance links, and front upper control arms, along with a four-wheel alignment. The vehicle had approximately 80,000 miles at the time of the repair. The service center explained that these suspension components can wear at higher mileage, particularly because of the weight of the vehicle and its battery. I paid out of pocket for the recommended suspension repairs and four-wheel alignment. The repair invoice is available for inspection upon request. Before the repairs were completed, I was driving the vehicle without knowing that there was a potential problem with the front suspension. The vehicle pulling to the right affected its handling and steering and created a safety concern for me and others on the road. There were no warning lights, messages, or other indications from the vehicle alerting me to a potential suspension problem. I was also not warned by the Tesla service center that the issue could be related to a known or potentially widespread suspension problem. A few days after having the repairs completed, I became aware of an the federal safety agency investigation concerning front suspension issues involving Tesla vehicles, including the same make, model, and model year as my vehicle. I had already paid out of pocket to have the affected front suspension components replaced. I am submitting this complaint to document the suspension problem, the safety risk I experienced, and the out-of-pocket expense I incurred to correct the issue. I am concerned that I was placed at risk by a potential su

Filed Aug 10, 2026 · Suspension · NY

Lots of creaking and grinding noises coming from both front upper control arm bushings. Steering starting to become less stable.

Filed Jul 31, 2026 · Steering, Suspension · 76,000 miles · CA

The contact owns a 2018 Tesla Model 3. The contact stated that while driving at an undisclosed speed, the vehicle was shaking uncontrollably. The contact pulled over and had the vehicle towed to the dealer. The dealer determined that the front control arm had detached from the front passenger’s side wheel. The dealer replaced the front control arm, lateral link, and steering column. The contact stated that there was no impact to the vehicle to have caused the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 76,000.

Filed Jun 23, 2026 · Suspension · CA

My vehicle should've been included in a recall. While exiting my garage to pick up my son from school, a loud mechanical banging noise came from the front of my car. I abruptly stopped and proceeded to reverse back into my garage to inspect my vehicle. While inspecting my vehicle and the surrounding area, I discovered a large bolt on the ground. A quick image search says "on a Tesla Model 3, this specific high-strength 10.9 Class metric hex flange bolt is a critical structural component that almost certainly backed out of [my] front suspension lower control arm/ lateral link assembly or the front subframe structural mounts." So the loud banging noise came from my suspension falling apart after the bolt fell out. Upon further inspection, I confirmed that this was the issue and that a second bolt on the same side had partially backed out as well. My vehicle was not safe to drive, so I had to have my vehicle towed to the nearest service center for repairs. I took photos and video of the areas, as well as the bolt, which showed no signs of any damage to the head or threads - so the bolt simply backed out and appears to be a manufacturing/ assembly issue. After a quick search, we learned that there were previous the federal safety agency recalls (ie Part 573 Safety Recall Report 23V‑235) for this particular issue, including for my same vehicle make, model, year (2018 Tesla Model 3) and production dates (Jan 5, 2018 - Mar 30, 2019). Unfortunately, I never received a recall notice. I barely drive my car, so bolts shouldn't just be backing out on their own. Unfortunately, my car is no longer under warranty, but was advised by the service managers to file a report and to get reimbursed thru NCDS. This is a huge safety issue. I had no warnings or alerts from the car. My alignment was checked a year ago. My wheels and tires get checked often and are well maintained, so I didn't even need air or rotation, yet my suspension just fell apart on its own before 60K miles.

Filed May 18, 2026 · Suspension · CA

Tesla model 3 2018 long range 86k miles. While driving 50mph on freeway the lower control arm link separated from the frame. No impact, no damage, and no pothole/bump. Lost steering and was able to get to side of road. When I got out and look at vehicle the control arm was disconnected from the frame. The frame showed no damage and the control arm showed no damage. The mounting holes for each here intact and no damage. Appears that bolt fell out or sheared off and the control arm disconnected. This is a safety failure and was scary. I towed to Tesla and they claim that failure was form worn parts and tolerances. I stated how could this be worn parts when mounting holes are in excellent condition. They are refusing to help with cost of repair and quoted me $2800. They are not taking responsibility and I believe that others should know of this failure. I believe I am being wronged and would like to report. Thanks.

Filed May 8, 2026 · Steering, Suspension · OK

The control arms on all make and models of tesla have a horrible design that all water off of the car flows down the sides of the front hood and down onto the control arm bushing. This could be a simple fix for tesla to out a boot on it to cover the bushing. The control arms start to fail at any given time. This is costing owners thousands of dollars. I have had to had them replace once under warranty and now they want me to pay 2000 since I am out of warranty. Owners with newer vehicles sometimes start to have problems within the first year. This part design needs to be recalled and all persons have free repairs. According to sources, driving with severely worn control arm bushings can lead to a fatal accident. While bushings often start as a minor nuisance, complete failure compromises the structural integrity of your vehicle's suspension. Don't wait till deaths start happening. Protect the customer and others and send a recall on this. Yiu can Google tesla control arm issues and and see over and over in videos and forums that this is a major issue.

Filed Feb 26, 2026 · Steering, Suspension · CA

The front lower lateral link (rearward lower control arm) fastener/bolt completely backed out and fell off the vehicle while in motion, causing the lateral link to separate entirely from the subframe. This is the exact mechanical failure described in Tesla Recall Campaign 23V‑235 (Service Bulletin SB-23-31-001), however, my specific VIN was not included in that recall. The vehicle and components are currently at an independent EV repair facility and are available for inspection upon request. Photographic evidence of the missing bolt and separated control arm has been retained. The separation of the lower lateral link caused an immediate and violent collapse of the front passenger-side suspension geometry. The affected wheel was no longer anchored to the vehicle frame, causing it to fold backward and grind heavily against the wheel well. To keep the vehicle moving straight, the steering wheel had to be turned to an extreme 45-degree angle. This resulted in a near-total loss of steering control. Had this fastener failed while traveling at highway speeds instead of low speeds, it would have resulted in an uncontrollable, catastrophic collision. Yes. The problem was physically confirmed and documented by an independent, EV-certified repair facility (EVFixMe/Shocker Motors in Costa Mesa, CA) once the vehicle was placed on a lift. The vehicle was physically inspected by an independent service center. The manufacturer (Tesla) was contacted via the Tesla App; however, they refused to perform a physical diagnosis without pre-authorization of a $2,600+ comprehensive suspension replacement estimate and stated the vehicle was out of warranty with no open recalls. There were no dashboard warning lamps, digital alerts, or error messages from the vehicle's computer system prior to the failure. The failure presented suddenly as a loud, painful metal-on-metal grinding noise accompanied by immediate, severe steering misalignment. Currently waiting on invoice from indy shop.

Filed Feb 6, 2026 · Suspension · CA

2018 Tesla model 3 front chassis subframe welded nut to the chassis is come off now left side control arm keep getting loose