2018 Tesla Model 3: harsh or hard shifting

Filed Oct 31, 2026 · Steering, Suspension · TX

Heard a clunk noise when the vehicle turned at a low speed. Inspected the vehicle but nothing seemed amiss. No digital warnings either. Started driving but the steering was weird and pulled to the left. Then the front left tire started shredding and the wheel was displaced. The tow truck guy said that the suspension seems to be the culprit. The car is now on just the wheel. Tesla collision has still not looked at it but gave a quote of 5-6K to start and going up to 12K or more (if the HV battery got damaged). FYI, tire pressures were normal when this happened.

Filed Oct 26, 2026 · Steering, Suspension · CA

I drove over a bump in the road and all of a sudden the car started making a very loud clunky noise in the front suspension. I was close to home so I turned around and drove it back home for inspection. I found the lower control arm on the suspension is completely disconnected because the bolt is backed out of the joint. The steering had occasionally made some creak sounds in the past but it never felt loose. Seeing the lower control arm disconnected could have severely limited the steering of the vehicle thus this seems like a serious safety issue. I have scheduled an appointment for repair with Tesla Service.

Filed Oct 17, 2026 · Steering, Suspension · OR

This is to serve as a registered complaint in conjunction with the premature component failure and degradation of front lower lateral links and suspension parts under the federal safety agency investigation PE26006. In August 2026 while operating my 2018 Tesla Model 3 while driving at all speeds experienced a failure of the front suspension system. There was an intense creaking/groaning/clunking noises from the front wheels and/or front suspension that we felt extremely uncomfortable operating the vehicle fearing for the safety of the passengers. Upon taking the vehicle to the Tesla Service Center, technicians diagnosed the vehicle with severely degraded and failing front lower arms, compliance links, and control arm bushings. My vehicle only had a little over 29,000 total miles on the odometer. This premature degradation represents a critical component failure rather than standard wear and tear. A failure or detachment of the lower lateral link at highway speeds presents an immediate safety risk due to potential loss of directional steering control. This failure is directly identical to the conditions outlined in the federal safety agency Office of Defects Investigation Preliminary Evaluation PE26006, opened on July 29, 2026, targeting front lower lateral link failures on 2018–2020 Model 3’s. The issue has since been repaired by Tesla Service on October 6, 2026. I am filing this complaint to formally document this premature safety component failure for the ongoing PE26006 federal investigation. We stopped driving the vehicle and used our other cars, waiting for appointments at Tesla, as well as waiting for the parts to arrive, which took quite a while. Thankfully, we had a couple other cars that we were able to use while we were waiting for the repair to be performed.

Filed Sep 21, 2026 · Suspension · KY

Clunking noise when in reverse and turning.

Filed Sep 19, 2026 · Suspension · CA

On August 6, 2026, my spouse was driving our 2018 Model 3 at low speed while making a U-turn out of The Village at Pacific Highlands Ranch when she heard a clunk from the front of the car and the car felt as though it had dropped down. Steering was not affected. The car began to slow, and she drove it at low speed into a nearby parking lot, where it stopped and would not move forward even with the accelerator pressed. It had to be towed. She did not strike a curb, pothole, debris, or any other object, and there was no impact of any kind. Inspection at the scene showed that the driver's side front lower lateral link had separated at its inboard, subframe end. The link was hanging down and resting on the pavement, still attached at the wheel end. A close-up photo shows the bushing inner core with two bolt ears and empty bolt holes: no fastener present and no broken fastener remnant. The link is not bent, gouged, or scraped. The left front wheel was pushed rearward in the wheel arch and was pressed against the rear edge of the fender, which damaged the fender and a brake line. The tire and wheel have no curb rash or impact marks. The vehicle was not included in recall 23V‑235, and Tesla's VIN recall lookup shows all recalls issued for it as completed. Mileage at the time was approximately 108,043 miles. The vehicle was declared a total loss and has since gone to salvage. This failure appears to match Preliminary Evaluation PE26006.

Filed Aug 15, 2026 · Suspension, Transmission · CA

I am reporting a front suspension failure on my 2018 Tesla Model 3 Dual Motor, that appears relevant to the federal safety agency Preliminary Evaluation PE26006 and similar to Recall 23V‑235. While driving slowly in a parking lot, I heard a clunk and felt the front wheel/steering alignment become slightly skewed. After entering the highway, the vehicle developed severe vibration and became unstable and difficult to control. I exited and stopped as soon as safely possible. While attempting to park it at a curb, during reverse, the suspension entirely collapsed and left front wheel was then severely displaced and the tire was rubbing the wheel well. Tesla inspected the vehicle and confirmed: “The left lateral link was found detached with missing hardware.” Tesla also found the left front halfshaft detached from the drive unit. Tesla replaced the front subframe, both front lower lateral links, both front lower compliance links, the left front halfshaft, and performed an alignment. Total cost was $6,328.96. The failed parts were replaced by Tesla; I do not know whether they remain available for inspection. This failure created a serious risk of loss of vehicle control at highway speed and could have endangered me and surrounding traffic. The problem was confirmed and inspected by Tesla Service. There was no collision or other discrete impact event that I recognized as causing the failure. There were **no warning lights, warning messages, or other vehicle alerts before or during the failure**. The first noticeable symptom was the clunk in the parking lot, followed by the skewed steering/wheel position and later severe highway vibration. I have pre-repair photos showing the displaced wheel, tire contact, and detached suspension component, as well as Tesla’s final repair documentation. I request that this incident be considered in connection with PE26006 and Recall 23V‑235.

Filed Jul 3, 2026 · Suspension · CA

My car experienced a loud clunking noise when turning for the past few weeks. After doing some research and inspecting behind the front right tire, I found a front suspension lateral link bolt nearly falling off. It was only being held on by a few threads. It was so loose I could unscrew it completely or tighten it more by hand with no resistance. It sounds related to an existing recall for 2018 Tesla model 3’s (my year and model), but my car is not included in the recall. The other joints around it appear prematurely worn as well. See picture to show exactly how loose it was upon inspection. Requesting to review and likely expand the existing recall to more 2018 Tesla Model 3s

Filed Apr 21, 2026 · Body, Steering · CA

The front lateral links, compliance links, and stabilizer bar link on my 2018 Tesla Model 3 Long Range failed and required replacement in January 2026. Prior to failure, abnormal creaking and clunking noise from the front suspension began appearing weeks before the repair — no warning lights illuminated at any point. The failed components were replaced by a Tesla-certified Service Center and are no longer available for inspection. The failure was confirmed and repaired solely by the Tesla Service Center; no police, insurance representatives, or other parties inspected the vehicle. I was charged out of pocket for this repair. The lateral link separation risk directly endangers vehicle safety — if a fastener loosens sufficiently, the lateral link can detach from the subframe, causing sudden wheel misalignment and loss of steering control, which could result in a crash at any speed. Tesla issued recall 23V‑235 (the federal safety agency campaign 23V235000) in March 2023 for this exact condition on 2018-2019 Model 3 vehicles. My vehicle's VIN was not included in the recall population, yet experienced the identical failure mode. I am requesting this complaint be considered for recall expansion under 23V‑235 and seeking reimbursement for out-of-pocket repair costs for a defect Tesla has already acknowledged in identical vehicles.

Filed Oct 21, 2025 · Steering, Suspension · IA

The front upper control arms on my 2018 Tesla Model 3 have failed multiple times, producing loud clunking, popping, and binding noises during steering. The issue has worsened and poses a serious risk of loss of control while driving. Tesla replaced these parts under goodwill in the past, but the failures have returned. The most recent incident occurred around 03/05/2025 at approximately 106,867 miles. The failure has been confirmed and documented by Tesla Service Centers, and I have multiple invoices showing repeated replacements of the same components. The problem directly affects steering and suspension safety.

Filed Dec 27, 2024 · Suspension · CA

Under-torqued Lateral link bolt These bolts are known to fall out or cause damage to bushings from being installed improperly Failure of the suspension would result in the suspension collapsing and the car becoming uncontrollable, with serious risks at higher speeds Out of pocket repair has been made by Tesla Component has been inspected and tightened to spec No warning sings, other than loud, clunking noises At 40k miles on smooth roads, this is not a driver issue, but a manufacturer assembly issue. They already have a recall for other VINs in other years, but I believe this should be expanded to more VINs and years, as this appears to be a common issue.

Filed Oct 3, 2024 · Suspension · TX

Car was making clunking sound, so made an appointment with service center. Before appointment, clunking sound stopped. Around the same time the clunking stopped we found a bolt in the driveway. Took into service and was told a bolt was missing from the lower lateral link which sounds quite concerning. I'm told by others had both bolts fallen out the wheel would have tipped inward or outward and damaged the fender and possibly caused an accident. I searched recall notices and I found recalls and/or bulletins with the same problem in similar but not the same VIN range as our vehicle and have read of others with similar problems not covered by recalls. There had been no previous work done on the front suspension.

Filed Feb 8, 2024 · Suspension, Wheels · CA

Clunk and popping sound while driving, especially while turning the wheel or going over bumps in road. Maneuverability and control of vehicle felt impacted which could have resulted in an accident, damage to property, and injury and/or death of people. The issue was reproduced at the vehicle's Service Center and identified as a lose bolt that connects the front suspension lateral links to the subframe. This issue sounds very similar to a previous recall for the same make, model, and year of this vehicle, but the VIN for this particular vehicle was not included in that recall.