Tl* the contact owns a 2002 toyota 4runner. The contact stated that fluid was leaking under the vehicle. The vehicle was taken to an independent mechanic. The technician diagnosed that the rear differential housing was rusted, leaked fluid intermittently and there were multiple holes to the point that the component may fracture. The rear differential needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was not available.
2002 Toyota 4RUNNER transmission complaints
Page 2 of 2: complaints 11 to 33 of 33, newest first, as owners wrote them.
Rear differential has rusted through, the whole thing has to be replaced because there is no separate cover the repair cost may be high.
4 wheel drive would not work. Vcs lites and check engine lites on. Car engine filled with black smoke and was towed to repair shop. Details: drove on freeway and lost traction and than on shoulder with above problem. Differential repaired. Two days later lites on again and oil leak.
I filed a the federal safety agency complaint (odi number 10569206 was assigned) on 13 march 2014 about this vehicle. On 14 march 2014, I took my 4runner to my local toyota dealership after contacting toyota customer service and logging a complaint ( case number [xxx] ) with them on the 14th of march 2014 at their office in california and the customer service rep telling me documentation of the issue at my dealership would help me. This vehicle was bought in ny and remained up north for 10 years and according to emerson toyota auburn, me records at 85,199 miles on 07/11/2012. Service adviser, [xxx] condition1 at 85,199 miles . Used car prep. Vehicle being wholesaled per rich. Needs engine light on, A/C inop, rear axle housing very rusted and cracked, hood latch inop, radiator leaking, frame is soft. It had 85,404 miles when it came to florida on 07 september 2012 my 2002 toyota 4runner sr5 with only 112109 miles at coggin toyota at the avenues dealership on philips hwy in jacksonville, florida at 12:20pm on 14 march 2014 my complaint at the dealership on 14 march 20014 at 12:20.........customer states rear subframe is rusted. Check and advise. Their findings at 12:55pm on 14 march 2014... Case number [xxx], found severe frame rust, holes in frame on right side, holes rusted through frame by gas tank on left side.holes rusted through gas tank and leaking fuel. Upper rear track bar bracket rusted off of rear end housing, rear shocks rusted off. Front brake rotor backing plates rusted through. The vehicle is unsafe to drive due to fuel leak and extreme rust through of frame. I want this vehicle frame and axle fixed or bought back by toyota. A toyota dealership in auburn, me knew of this problem almost 2 years ago and sent it out the door. Totally unsatisfactory. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Vehicle frame, front & rear bumpers and undercarriage have excessive / unsafe rust corrosion.
Rear axle assembly rot! Now leaking on rear non replaceable yoke cover. 1800-2000 dollar fix. To make things worse axle assembly has no tags!!!! Told by dealer door tags are often wrong so ordering recycled (if you can find one in better shape) is a gamble!!!! Has been a dependable truck other wise but now it seems as though they are profiting from there design flaws.
(there was no category offered for frame). During a recent automotive service for brakes on 9-26-13 for my 2002 toyota 4runner, I was notified of a rust perforation in the frame body near a rear support mount for the axle making it unsafe for operation. This is a situation where rust forms in the interior of the frame and works its way out destroying the structural integrity of the vehicle. It seems the service technician used to work at a toyota dealership and knew exactly where to look from his prior experience with other 4runner failures. The toyota dealer informed that this would not be covered. My ?02 4runner is from the same generation (3rd) and of similar design to the tacoma that was recalled for this the dealer instructed me to contact the torrance, ca toyota customer service as his dealership would be unable to assist in anyway. It was clear they had encountered this before. Through discussion with toyota ca they have no intention of providing any means of relief for a known and well documented safety problem. One rep did comment that the tundra and sequoia had been recently added to the recall but the 4runner was ?not yet? On the recall list. It seems toyota views the products to be different due to the body style differences or us vs japanese built products. They also clearly have no intention to escalate internally. I was instructed to file a complaint with the federal safety agency and ntsb. Research on line shows that there is a very widespread issue that toyota is clearly choosing to ignore. Web information suggests that cold climate and the axle bracket in close proximity to the exhaust, are primary factors. How can you recall one model for a rusted frame due to safety but not another? Personal photos available. Huge numbers of photos and reports available online - search " rusted frame 4runner" or similar.
2002 toyota 4 runner. Consumer writes in regards to vehicle gas pedal malfunction. *smd the consumer stated after stopping at a stop sign, he attempted to move forward, but the vehicle would not move. After several trips to the dealer, the problem was fixed. However, the consumer did state what the problem was.
The differential housing is rusting out and is seeping fluid. In addition, the frame is dangerously rusted, especially from the rear axle back. I have been told by a very reputable body shop in the area, that the frame needs to be replaced, but due to the severity of the rust, this is not practical. Toyota is replacing frames on their tundra pickups due to rust, but refuses to cover 4runners, though they share the same frame. If I did not have the vehicle serviced by the dealer regularly, I would be unaware of the dangerous condition of the frame.
Recently purchased this vehicle and started cleaning it, after I drove it home and pressure washed undercarriage, pieces of the rear differential started flying off and gear oil started running out of holes. I have a 1971 dodge challenger with original rear end that has never been in garage and have never seen a rearend rust like this. I'm really worried about how strong the axle housing structure is and if it could possible break in half while driving vehicle.
My 4runner has 72000 miles on it, and I just realized the rear differential housing has rusted through. The metal is so thin that the fluid is leaking out through the pours of the metal. I took it to the dealer and they said it would cost 3000$+ to replace the entire rear end. There is no other rust under the vehicle except for the pumpkin housing. After looking around on the internet I found this is a common problem, of the housing not only being too thin of metal for the application, but low quality steel that's prone to corrosion.
After noticing a strong gear oil odor and seeing the actual gear oil on the back the of the vehicle I was alarmed to find out that the rear axle housing had rust perforating the rear of the housing. Once the housing was checked by a certified mechanic and turned away due to fear of destroying the housing, I removed the vehicle from the road.
Rear differential rust through.
2002 4runner sr5 4wd, 141k miles, completely rusted through rear differential, both rear axle seals busted out, differential housing has several pin hole leaks and is thinned out, the only fix is a completely new rear end, which is very costly, I am the 2nd owner, I've owned a 99 4runner that had these same rear differential rust issues, the rust is ridiculous and has deteriorated the whole undercarriage and my 4runner is garage kept and I wash it all the time. I can't believe toyota has not been held accountable for the rusting out of rear differentials and rear axle issues.
The rear differential housing has rusted through causing its oil to leak out.
2002 toyota 4 runner rusted out rear axle housing. Rear axle housing leaks oil due to rust erosion on the rear axle cover.
Tl* the contact owns a 2002 toyota 4runner. The contact stated while driving 35 MPH, the vehicle began to lose power abnormally accompanied by the illumination of the check engine warning light. The contact later discovered that the aluminum radiator and the bolt that connected the coolant and transmission fluid transfer was faulty causing the two fluids to combine abnormally. The contact stated spoke with several mechanics that advised him of that the two fluids were combining. The vehicle was not repaired. The current and failure mileage was unavailable.
I am the original owner of a 2002 toyota 4runner-sr5, sport edition with 74,600k miles. In november 2009, I experienced the same problem that's being reported by other toyota owners whose vehicles are being recalled. The accelerator pedal stuck in a partially depressed position on its own and quite suddenly. This occurrence only happened once. The engine was racing at a very high RPM and my rear tires were squealing loud enough to draw attention from passersby. Luckily for me I was slowly pulling into a parking slot. My reaction to this situation was to put the gear in neutral and applied the brakes. My main concern is if the ongoing investigation by the federal safety agency and toyota will include a look-back at earlier models for these known problems? And, if so, what is the manufacturer's recommendation to owners' with earlier models?
I have a 2002 toyota 4 runner with rust out of the rear differential housing. I took the vehicle in for repairs only to discover that metal was quite rusted at the rear housing and instead of a simple part replacement, the whole assembly has to be replaced, a costly repair. I found other owners with similar stories online. Is this a defective part? I had temporary repair with grinding, welding and epoxy which for the time being has corrected the leak but eventually it will reappear.
Check engine light came in, it was diagnosed as a 770 shift solenoid-e and I was told by two different experts that my transmission would need to be replaced. The toyota 4-runner was purchased in january 2008 from folsom lake toyota with 89,000 miles and currently has 95,500 miles on it. The estimate for repair was $2,300.00.
2002 toyota 4runner front end makes loud noises, when going over high bumps and some stiffness in steering. *ts the battery needed to be replace due to little or no fluids, noises were coming from the front end, the shock were leaking, and transmission fluid was leaking. The consumer requested a replacement of the front suspension/lower ball joints and the leaking shocks at no cost.
The rear driver axle seals were leaking, which caused the brake pedal to stick. Please provide more information.
Complaint: defective vehicle severely rolls backwards when in 'forward drive' on a hill. Toyota states that the vehicle was road tested and found vehicle operating to specifications. *jb my observation is that the toyota 2002 4runner is an unsafe and defective vehicle that should be recalled immediately. Toyota is unwilling to admit that there is a problem, but I intend to prove beyond a reasonable doubt that the toyota 2002 4runner is defective and unsafe to drive. The problem presents a serious safety concern. When I purchased the vehicle I lived in a flat area (morris plains). Recently we moved to a location with a steep driveway (700 feet). Since moving to our new home my wife and I have experienced several occasions where the vehicle severely rolls opposite the desired direction when transitioning from the brake to the gas pedal while at a stop on a steep hill. The problem is exaggerated when the roads are slick, as the car also spins sideways due to loss of momentum for which the vehicle is forced to compensate creating total lost of traction and driver control. My wife and I purchased the vehicle because toyota advertised it as the vehicle that can take you to the ends of the world. toyota actually shows a vehicle climbing a very steep mountain. That is false advertising! We purchased the vehicle because it is supposed to handle steep hills safely under a four-wheel drive capability. The vehicle is very difficult and nearly impossible to park on a hill without hitting another vehicle. In good faith, I have proceeded to address the matter with the manufacturer and do not believe that an injury or death has to occur prior to the manufacturer recalling the product for correction. Toyota has corrected the problem on the 2003 4runner but will not correct it on previous vehicles because they don't perceive it as a problem.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Toyota 4RUNNER?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history