2024 Toyota Grand Highlander fuel system problems

Filed Oct 2, 2026 · Fuel system · TX

Has a VERY strong gas smell and fumes near gas tank after car has been idling.

Filed Sep 12, 2026 · Fuel system · CA

I own a 2024 Toyota Grand Highlander Hybrid MAX Platinum, purchased brand new in February 2024 and now with approximately 30,400 miles. Since the first few weeks, the vehicle has had an ongoing fuel tank/range issue. The fuel tank is rated at approximately 17 gallons, but the gas pump consistently shuts off after only 10–12 gallons, even when the vehicle indicates 0 miles to empty. It accepts approximately the same amount whether I refuel with 80, 20, or 0 miles remaining. After filling, the vehicle reports the tank as full and but generally shows only 270–290 miles of estimated range. The actual miles driven before requiring fill up is 230-250 miles. Toyota issued T-SB-0060-25 (Low Fuel Warning Light Logic Enhancement), which a Toyota dealer reluctantly performed on my vehicle. It initially improved the displayed range by only about 10 miles, but did not resolve the problem, and the condition is now worsening. The dealer solution was to tell me I can drive another 60-100 miles past empty but I do not believe that is a reasonable or safe workaround. This is because the driver cannot reliably determine the remaining usable fuel or how far the vehicle can safely travel. The condition remains unresolved and is a known issue with other Toyota Grand Highlander Hybrid Max owners.

Filed Sep 1, 2026 · Engine, Fuel system · IL

At 5:16 pm, CST. I was stopped at a stop sign headed west on a 25 mph road crossing a 30 mph road (that does not have a stop sign) in Illinois. After waiting for a an appropriate gap in traffic, I attempted to accelerate though the interesting. I released the brake pedal and attempted to accelerate. The vehicle barely accelerated. The engine seemed to minimally climb in RPM and only accelerated minimally out into the cross road. This lasted approximately 1-2 seconds. AT this point I was fully into the first lane of traffic. I then fully depressed the accelerator to try to get the vehicle to respond and after approximately a 0.5 to 1.0 second delay the engine fully responded and I was able to accelerate out of the oncoming cross traffic. This is by no-means the first time this behavior has happened with this vehicle but it is the first time I'm reporting it to the federal safety agency.

Filed Aug 29, 2026 · Engine, Fuel system · AZ

Horrible gas smell on the interior and exterier of vehicle after fueling up.

Filed Aug 28, 2026 · Fuel system · TX

I currently own a 2024 Toyota Grand Highlander with the 2.4L turbo engine, which I purchased in July 2023. I have been experiencing a strong gasoline/fuel smell coming from the vehicle. I took the vehicle to Fox Toyota in El Paso for inspection. According to the dealership, the smell was caused by the gasoline I was using and they stated that the fuel contained too much ethanol. However, the gasoline smell was strong enough to be concerning, and I am not comfortable simply assuming that the fuel is the cause without further inspection. At this time, I have not been given a specific diagnosis identifying a failed component or confirming that a particular fuel-system component is malfunctioning. The vehicle is available for further inspection if requested. The strong gasoline odor raises a safety concern because the presence of fuel vapors could potentially indicate a fuel leak or another problem with the fuel system, creating a possible fire hazard. The problem was reported to and inspected by Fox Toyota in El Paso, but the dealership attributed the odor to the ethanol content of the fuel rather than identifying a defective component. I have not had the vehicle inspected by the manufacturer or any other independent facility at this time. I have not observed any warning lights or warning messages associated with the problem. The primary symptom has been the strong gasoline smell. The vehicle has the 2.4L turbo engine. I would like to know if other 2024 Grand Highlander 2.4L turbo owners have experienced the same issue and, if so, what the actual cause was and how it was resolved.

Filed Aug 25, 2026 · Fuel system · UT

The car stalled on entering secondary roads from my own neighborhood. When it happens, I have pressed the throttle and the car stops moving forward. It takes 5-10 seconds before the engine picks up and the car moves. The first owner found the same thing and now as the second owner, it has done the same thing.

Filed Aug 23, 2026 · Engine, Fuel system · NY

While driving on a highway at highway speed of approximately 62 miles per hour, a rock from the highway went through the front grille's hole, and punctured the area of the radiator, resulted in a large loss of coolant, and the vehicle's speed suddenly lost highway speed and lost propulsion on the highway, while driving at a highway speed. Thankfully noone was driving behind me. However, If someone was behind me, they would have hit me from the rear due to my loss of propulsion.

Filed Aug 23, 2026 · Fuel system · NY

During driving on a highway at highway speed (not off-roading), A road debris or rock went through the front grille's hole and damaged the cooling system which leaked coolant and i experienced a loss of power and propulsion while driving on highway, as a result of this issue.

Filed Aug 12, 2026 · Fuel system · 45,000 miles · AZ

The contact owns a 2024 Toyota Grand Highlander. The contact stated that while driving at an undisclosed speed, there was an abnormally strong gasoline odor inside the cabin of the vehicle. The contact believed that the odor was caused by a fuel leak. The vehicle was taken to a dealer, where it was diagnosed with an evaporator filter failure, and it was determined that a fuel leak was not the cause of the odor. The dealer stated that the vehicle did not require a repair and could still be driven with the odor inside the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 45,000.

Filed Aug 11, 2026 · Engine, Fuel system · TX

Vehicle intermittently fails to accelerate when accelerator pedal is depressed after stopping. Vehicle may move extremely slowly for several seconds and then suddenly regain power. This has occurred while entering/intersecting traffic and has resulted in near-collision situations. Dealer cannot duplicate the problem.