Toyota Highlander won't start problems

Filed Jun 16, 2026 · Transmission · MN

System Failed -Transmission makes a high pitch whine, which Toyota has identified as a product manufacturing issue with the 2017-2022 V6 Highlander, but has not done anything to rectify the issue for those of us out of warranty. As this transmission issue usually doesn't start happening until 60,000 miles, unless you bought an extended warranty, you're out another $8K to $10K due to their negligence. Found this on Redit - Toyota knows the UA80F whines—it’s in TSB T-SB-0160-18 , T-SB-0008-21 and CSP ZJC. But unless your VIN’s on their cherry-picked list, they’ll play dumb. Safety Risk - Transmission stops working and car is inoperable. Reproduced - Yes, Toyota is aware that several cars are affected and doesn't care. Symptoms - Identified Symptoms are high pitched whine, rough shifting, transmission slippage, etc.

Filed Apr 24, 2026 · Transmission · CA

In January during an oil change i was advised that my Toyota had a timing cover leak which is a costly repair. At this time my car was at 148k. i researched it recently and found that it could be dangerous to drive with this leak that Toyota did not advise me about after i had several phone calls with their corporate office and dealership. And even though it is a common problem with their 2017 Highlander they would not take responsibility for fixing it. It was disappointing after getting all of the service recommendations done that i would have to pay $4500.00 for engine work for a seven year old vehicle. This cost was a hardship for me because I'm still making a car payment. I also had to replace the battery every 1.5 years. The battery warning light never came on, leaving me stuck at an intersection until the tow truck arrived. It cut off because of the start/ stop feature and that would not start again. No warning. And after about 15 minutes my hazard lights went dead. This is an ongoing issue.

Filed Dec 18, 2025 · Body · NH

Paint is peeling off my car, This is confirmed by Toyota it was covered by the Consumer Support program which expired in July however the paint did not start peeling off until last week.Toyota said that there wasn't anything they could do. this is clearly a manufacture defect and should be repair by Toyota at no charge to me.

Filed Sep 27, 2025 · Engine, Transmission · CA

On September 2, 2025, the vehicle’s Hybrid System shut down on cold start and the vehicle would not start. A dealer inspection reported coolant had entered cylinder #4, allegedly causing the engine block to warp, the cylinder head to crack, and the head gasket to fail. This was a sudden catastrophic engine failure on a five-year-old vehicle with no prior overheating warnings, no dashboard alerts, and no performance issues in the days leading up to the failure. It is highly unlikely for an engine block to warp without sustained overheating, yet the failure occurred on a cold start. The dealership itself described this as a “premature failure” in their service report. At approximately 26,000 miles, the vehicle’s coolant thermostat failed and was replaced under warranty. If the thermostat stuck closed even briefly, the engine could have experienced one or more silent overheat events that never registered on the dashboard. In aluminum blocks, even short bursts of high localized heat can create latent distortion that doesn’t cause immediate problems but can eventually lead to catastrophic failure years later. Safety Risk: – Vehicle became disabled suddenly without warning. – Engine failure occurred without overheating symptoms, creating risk of sudden shutdown during use. Problem Confirmation: – Engine failure confirmed by a Toyota-authorized dealer. – Dealer service report explicitly called this a “premature failure.” Warning Lamps / Symptoms: – A check engine light appeared briefly three days before failure, then cleared on its own. – No overheating warnings or drivability issues were observed prior to failure.

Filed Aug 10, 2025 · Transmission · KS

While slowing down, the vehicle will suddenly lunge forward, as if It hit a patch of ice and then slow again. This started happening around 30,000 miles. The dealer said this is because of a transition between hydraulic braking and regenerative braking and is "NORMAL". This did not start until 30k miles. I have owned 4 hybrid vehicles and only this one does this. Upon reading and studying online, there was a bulletin for an earlier generation of this type of problem. Clearly, it is an issue as I am not the only one with this problem.

Filed Jul 14, 2025 · Electrical, Engine · MO

After getting gas, the vehicle will not start. It will crank and crank but not turn over, like it is starving for gas. Then after 10-15 minutes it will start barely and to keep it running I have to floor the accelerator. Any other time it starts just fine. There are also no codes causing a check engine light.

Filed Feb 27, 2025 · Electrical, Transmission · WI

On February 16, 2025 the vehicle was parked. The temperatures that day were in single digits. After approximately 1 1/2 hours the 12V system was drained. The driver panel was blank and the vehicle did not respond to any attempt to start. This vehicle had a similar incident the prior year, also in extreme cold conditions. During that incident the vehicle was towed to the dealership. They recharge the 12V system and did not find any problems once the faults were cleared. For the February incident, an attempt was made to jump start the vehicle. After the jump start the driver panel was active, but the vehicle reported a hybrid system malfunction and would not start the engine. The vehicle was then towed to the dealership. Attached is the report from service team. Problem #1. Under cold weather conditions this vehicle will drain the 12V system leaving the driver stranded in dangerous weather. Problem #2. The jump start procedure leaves the ECU exposed to severe damage. This leaves the vehicle inoperable.

Filed Jan 19, 2025 · Brakes · CA

Car will not start due to message that says "Braking Power Low. Stop in a Safe Place" There have been recalls on 2018 Highlanders for the brake vacuum pump but it is not listed for my particular vehicle

Filed Dec 15, 2024 · Brakes, Fuel system · CA

I own a Toyota Highlander 2018 LE. I have been servicing it regularly at authorized Toyota delaership service centers. I have around 28000 miles on it. While trying to start the car this morning, the car wouldn't start, the brake feels hard and won't depress, and the dashboard displays the message" Braking Power Low STOP in a Safe Place See Owner's Manual"

Filed Nov 24, 2024 · Brakes, Engine · MS

My husband took my car from the carport and parked it in the driveway near the water hose to wash the car. When he finished, it would not start. The message “Braking Power Low” , “STOP in a Safe Place”, “ See Owner’s Manual”showed up. Of course, we could not find anything in the large owner’s manual concerning that! I checked with my VIN to see if mine was included in the recall regarding this same matter, but it was NOT, just as all other Toyota Highlander 2018 owners who complained were told!!! We will find out tomorrow and pray it won’t be a lot of money. We have a Thanksgiving trip planned to see our grandchildren. Today is Sunday and we planned to leave on Tuesday. I shudder to think what could have happened if it suddenly stopped on [XXX] with all the holiday traffic. My husband was looking to buy a car after the first of the year and was going to buy a Toyota. After this, he has reconsidered. Toyota needs to see all these complaints and how many were not included in the recall!!! Something’s not right! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)