Rear axle has cracked at weld joint causing the tire to sit off center.
The worst 2012 Toyota Prius C problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes26
- Electrical15
- Airbags8
- Driver assistance6
- Engine5
- Seat belts4
- Transmission4
- Acceleration3
- Lights3
- Seats3
- Fuel system2
- Visibility2
- Body1
- Steering1
- Suspension1
Specific symptoms reported on the 2012 Toyota Prius C
Trouble codes owners of the 2012 Toyota Prius C mention
C1391 3P0A94 2
Recalls
No recalls on record for this model year.
Defect investigations
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
Drivability, Service brake failure
On January 3, 2013, the federal safety agency received a letter (ODI No. 10487746) from Ms. Jessie A. Powell petitioning the agency to investigate drivability and braking concerns in the subject vehicle.The petition expressed two concerns: 1. The first software problem was when the vehicle shifted from battery to motor and caused such impact, I initially believed the vehicle had been struck in the rear.2. The next more alarming problem was NO BRAKES. The brake pedal traveled to the floor and a dashboard warning light flashed.This symptom occurred twice, leading to the vehicle being towed to the dealership, the second time in the dealership parking lot after diagnostics of the first incident.After a test drive and vehicle inspection, no actionable problem was found within the petitioner?s vehicle.The braking concern reported turned out to be normal vehicle operation.The petitioner identified other complaints of poor braking performance and low brake pedal received by the federal safety agency concerning Prius models. Broader review of the consumer complaints reported for all variants of the subject vehicle showed no indication that either the reported jolting sensation or the brake performance concerns reported are occurring in this vehicle population at a level that would require investigative action by the federal safety agency.The following recalls by Toyota were to address many of these complaints in Prius variants. Neither of these recalls is applicable to Ms. Powell?s 2012 Prius C: 1. Recall 10V‑039 March 5, 2010 - 2010 Prius, Lexus HS - Reprogramming ABS ECU - Improve Antilock brake function over bumpy surfaces. 2. Recall 13V‑235 August 7, 2013 - 2010 Prius, Lexus HS - Replace Brake Booster / Pump assembly - Low brake pedal due to nitrogen bubble in hydraulic portion of brake system. In the Agency?s view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists in the subject vehicles.Therefore, given the need to allocate and prioritize the federal safety agency limited resources to best accomplish the Agency?s safety mission, the petition is denied.This action does not constitute a finding by the federal safety agency that a safety-related defect does not exist.The Agency will take further action if warranted by future circumstances.More details concerning our review can be found in the Federal Register Notice for this action.
DP13002
Technical service bulletins for the 2012 Toyota Prius C 366
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Obsolete notice
- This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries
- Condition in which a musty odor is present
- Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical...
- To prevent brake rotor rust from forming during transportation and storage, wheel film will be used...
- The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix...
- Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal...
- Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad...
- Condition in which a musty odor is present
- Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal...
2012 Toyota Prius C fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 1.5L 4‑cyl Hybrid | FWD | 53 | 46 | 50 |
What 2012 Toyota Prius C owners say
Most recent owner complaints, unedited.
The contact owned a 2012 Toyota Prius C. The contact stated that while attempting to park, the vehicle rapidly accelerated upon tapping the brake pedal and crashed into a brick storefront without warning. The air bags failed to deploy upon impact. A bystander inside the store assisted the contact in exiting the vehicle. Law enforcement responded to the scene and administered a breathalyzer test, which returned negative for alcohol. A police report was filed, noting minor scratch damage to the storefront's concrete. The contact did not seek immediate medical attention; however, she sustained soreness in her upper arms and upper legs, as well as driving-related anxiety in a rental vehicle. The vehicle was towed to an independent mechanic, where it was inspected and deemed a total loss by an insurance adjuster. The contact stated that two days prior to the crash, the vehicle had surged forward without warning when the brake pedal. The dealer was notified of the failure but provided no assistance. The failure mileage was approximately 165,000.
The contact owns a 2012 Toyota Prius C. The contact stated that while driving 20 MPH, the message "Check Hybrid Status - Stop vehicle in Safe Place Immediately" was displayed. There were several warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed with an internal power module transmitter and MG control computer inside the inverter assembly failures. The vehicle was not repaired. The contact called an independent mechanic, and DTC: P0A94 (DC/DC converter or inverter performance problem invertor assembly) was associated with the failure. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 98,015.
While driving 65 mph on the expressway on January 12th, 2026 under cruise control, I tapped my brakes to slow down. My brake warning light came on, along with the ABS warning light, and the anti-swerve warning light. Cruise control no longer worked, and my brakes were noticeably hard to apply. I immediately had the vehicle computer checked and the issue is a leaking brake booster component, a faulty part known by Toyota to fail prematurely with this and other Prius models. No recall was issued however. The car is now unsafe to drive until a ~$4000 repair is done, according to my service representative.
Brakes went soft with little braking power. Traced the fault code to a faulty braking actuator; toyota says this is past the coverage date for the recall.
I own a 2012 Toyota Prius C with approximately 156,578 miles. The vehicle has been diagnosed with C1391 – Abnormal Leak in Accumulator, which causes the brake actuator to lose hydraulic pressure. This results in frequent buzzing from the actuator pump, illuminated warning lights (BRAKE, ABS, Traction Control), and loss of ABS and stability control. The condition increases stopping distance and creates a serious safety hazard. Toyota previously acknowledged this exact defect under Customer Support Program CSP 21TE01, which covered brake booster and pump assemblies for certain Prius and Prius C models when codes such as C1391 were present. However, the program expired on November 30, 2022, and my vehicle is just over the 150,000-mile coverage limit. Despite this, my Prius exhibits the same defect that Toyota has already recognized as a safety-related issue. Toyota Carlsbad confirmed the diagnosis and quoted $3,399.55 plus tax for repair, with a reduced courtesy estimate of $2,817.86 plus tax, but declined goodwill assistance since CSP 21TE01 expired. Given the widespread reports of brake actuator failures in Prius models, I believe this represents a systemic safety issue that warrants the federal safety agency investigation and potential recall/extended coverage.
Brake Actuator and ABS Accumalator failed. It is a common failure reported by multiple owners on these cars. I was on the high way going 70 when it failed and lost any brake boost I had putting me in a very dangerous situation where I narrowly avoided an accident. Upon scanning the car's codes I got code C1391 which I looked up and saw a bunch of other people who were also struggling with this issue.
I am writing to express a complaint regarding the issues I have experienced with the brake system of my Toyota Prius C, 2012 model. For the past several months, I have noticed that the brakes exhibit strange noises, soft pedal sensation, reduced braking efficiency, were driving and the ABS, traction, brake, and that other light turned on and the brakes became slow these issues have been observed on multiple occasions and pose a safety risk to myself, other drivers, and pedestrians. I have taken the vehicle for inspection, but the problems persist or have not been definitively resolved. I believe these faults may be related to defects in the braking system, and therefore I request a thorough inspection and necessary repairs at no cost, considering that the manufacturer could be responsible for manufacturing defects.
The brakes on this Prius started to make weird noises. Because it is a hybrid, I wasn't sure if it was normal. After searching online, it is a known issue. The car has just under 76,000 miles on it. It might be worth $7000 on a good day. Toyota wants to replace two brake parts, numbered 47050-52020 and 04006-74152 to a tune of $2700. According to a Toyota bulletin, this job should take 2.3 hours. For that amount of work, my local Toyota shop wants almost $2000 in labor. My car was seen by the local shop (being on an island, it is literally the only Toyota shop that this car can be seen) when the "customer support program" 21TE01 was in place and they did nothing. Now, the time window has disappeared, even though we only have half of the maximum number of miles to get the repair. Toyota should be ashamed of themselves.
My ABS actuator failed. Turns off the boosted braking and cruise control. This is a known issue in Toyotas and it always happens outside the warranty window. This is putting my safety at risk as the brakes don’t work as they’re supposed to
Compare the 2012 Toyota Prius C
Other model years
Questions about the 2012 Toyota Prius C
Is the 2012 Toyota Prius C reliable?
Owners have filed 65 complaints about the 2012 Toyota Prius C, 3.6 times a typical Prius C model year. It is one of the years we flag to avoid.
What is the 2012 Toyota Prius C year score?
The 2012 Toyota Prius C scores 28 out of 100 (poor). The score compares it with the other model years of the Toyota Prius C: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2012 Toyota Prius C?
Brakes, with 26 complaints, typically around 25,000 miles. Next is electrical (15).
How many recalls does the 2012 Toyota Prius C have?
No recalls on record.
What year does the Toyota Prius C have bad brakes?
The Toyota Prius C model years with the most brakes complaints are 2012 (26 complaints) and 2013 (18 complaints).
What gas mileage does the 2012 Toyota Prius C get?
Official estimates for the 2012 Toyota Prius C range from 50 mpg combined. The most efficient version (1.5L 4-cyl hybrid, FWD) gets 53 city and 46 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2012 Toyota Prius C?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history