2012 Toyota Prius engine problems

Filed Jul 6, 2026 · Acceleration, Engine · IL

Unknown. There were a multitude of codes that appeared on the diagnostics causing problems with engine. The temperature, brake, tire sensor lights are all on. The cruise control is not working. White smoke emitting from tail pipe and engine. Main engine coolant leaking. Car overheating rapidly.

Filed Mar 11, 2024 · Engine · 106,000 miles · CA

The contact owns a 2012 Toyota Prius. The contact stated that when the vehicle was started, there was a rattling sound coming from the vehicle. The contact stated that while depressing the accelerator pedal, the vehicle started shaking abnormally with a rattling sound. The vehicle was taken to the dealer where it was diagnosed with a blown head gasket and that the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 106,000.

Filed Mar 1, 2024 · Brakes, Engine · OK

I bought my first used car, 2012 Toyota Prius, from Fowler Toyota back at the end of October 2023, but I was not able to pick it up until September 21, 2023 due to extra time for re-conditioning. I did not haggle about the price nor complained about the 3 week delay. In the last 3 weeks of owning my car, the TPMS sensor light and check engine light infrequently turned on. February 28, 2024 all the fault sensor lights on my instrument panel are on, along with the loss of proper braking function. I was not worried about the other sensor faults, but brake malfunction is a matter of life and death to myself and others on the road. I have had the car for a little over 4 months and less than 10k miles. I brought the car in to diagnose all the error codes. The dealer said it will cost over $2600 to fix the brake malfunction. I chose this particular car because carfax had well documented service records and Fowler Toyota advertised that every used vehicle for sale has surpassed rigorous inspection. I voiced my complaint to the used car director and he offered numerous default excuses for unforeseen problems inherent in buying a used car. I said I did my due diligence by selectively purchasing a used Toyota Prius, from a reputable Toyota dealership that uses a Toyota certified service center to inspect and recondition vehicles for sale. All the cliche nightmare stories of buying a used car from the side of the road car lots came true in my experience at Fowler Toyota. The worst used car story happened to me, despite performing my due diligence: to buy a used Toyota from a Toyota dealership that uses a Toyota certified service center for re-conditioning vehicles. I even paid more to finance my Prius through Toyota Financial services, which did not offer extended warranty. For God sake, I was buying a Toyota with 121k miles. I only bought a prius because I work too hard to throw away all my hard earned money on gasoline. The only recourse the dealership offered

Filed Feb 13, 2024 · Engine · PA

I was driving on the internet doing 60mph and there was a very loud bang and then a shaking of the parts under the hood. I was right next to an exit and coasted off the exit to a hotel parking lot. I had car towed to my mechanic. He said that the piston went thru the engine and the engine is done and needs replaced. I am having a hard time trusting Toyota again to purchase another Prius. I have had Prius for over 10 years and never had anything like this occur. I had no warning signs and no dashboard lights lit up until after all of this occurred and scared the life out of me then the engine light came on.

Filed Sep 6, 2023 · Driver assistance, Engine · VA

There is no incident occurring to me .but I change some parts like head light.& whisper .engine .

Filed Jun 18, 2023 · Engine · MI

Head gasket failure

Filed Jan 23, 2023 · Electrical, Engine · IL · fire

The engine caught fire while sitting in my garage. I had driven it for a few hours doing deliveries for a store and parked it in my garage around 2:30pm. About 1.5 hours later, my wife was coming home and opened the garage door and saw smoke above the hood of my car and then a few seconds later it burst into flames. I believe that it was smouldering for a while and the gust of wind when the big garage door opened gave it the extra push to ignite. The car was bought used and had a front end accident prior to my purchasing it so the electrical system could have melted and started the fire but the inspector that Toyota sent did not give me any copy of his report. It is a 2012 model. I bought the car in 2014, and had it for about 5 years until this happened and completed burned up the car and all the contents of my garage. I had a T-Mobile Sync-up module in the OBD port and it recorded a drop in voltage from around 12 to 5 volts at the time of the fire which I believe was transferred to my phone when I was near it.

Filed Jun 18, 2021 · Electrical, Engine · CA

There has been a safety recall on my vehicle for the years 2004-2009 models of the Toyota Prius, but my model year is 2012 and I have the exact same issue. 1) My check engine light comes on and off and it appears to be the hybrid electric water pump issue related to the coolant. The cap pops off and spills out. 2) When the light comes on, I am assuming the car is starting to overheat and is putting myself and my 3 year old daughter at risk as this is the primary car we use to transport her. We have just stop taking her out at all due to this issue. When the car overheats, I pull over and it can be risky as sometimes, I am on the highway or local streets. I do not want this issue to cause problems for other other drivers as well while I am trying to pull over where ever I am. 3) The problem as I stated above has been acknowledge by you and Toyota but just for 2004-2009 models. 4) The problem has not been inspected by Toyota, the police, or third party. I have been the only person checking the car and I am using a diagnostic check engine light tool to read the code and looking under the hood to find the coolant pump leaking and popped out just as indicated in the recall for other models. 5) Yes, the check engine light and high temperature light goes on and off. The issue first appeared around November of 2020.

Filed Feb 24, 2021 · Engine · 99,500 miles · MA

This vehicle has been burning oil for the past 10,000 miles. Vehicle has had all services and synthetic oil changes done from day 1 at the dealership. Oil changes every 5,000 miles since day 1. At 90,000 miles the car started burning oil excessively. Complaints and diagnostics were attempted at toyota franchise dealerships but they failed to find the issue. Finally at 100,000 miles the engine failed due to head gasket failure. This vehicle is classified as a partial zero emission vehicle and it is registered in a state that follows california air resource board regulations and is being serviced in a state that follows as well. Under the pzev regulations, toyota warranties emission related components for 15 years or 150,000 miles. Under toyotas warranty guide it states seals and gaskets are covered. The manual does not clarify any further leaving the coverage level vague and questionable. Upon trying to get toyota to replace the engine, they gave us a week of no responses and finally declining the claim even when the manual states it should be covered. The oil burning issue with this motor is a big problem that toyota has been trying to cover up. Toyota is quoting $13,000 for engine replacement. They have a service bulleting regarding the oil burning because it's a known issue, but they only honor claims under the 5 year 60,000 miles power train warranty.

Filed Dec 14, 2020 · Engine · 136,000 miles · TX

When idling there is a loud rattle and multiple random misfires in the engine. Appears to be a head gasket leak problem from reading forums. I have been to multiple repair shops they cannot determine the problem.