Unknown
2019 Toyota RAV4 fuel system complaints
Page 2 of 10: complaints 11 to 40 of 269, newest first, as owners wrote them.
I am writing to formally lodge a complaint regarding a recurring issue with my 2019 Toyota RAV4, which I believe poses a significant safety concern. The check engine light on my vehicle frequently illuminates, resulting in the disablement of the all-wheel drive (AWD) system. I initially brought my vehicle to a Toyota dealership, where they replaced the charcoal canister (EVAP) three times based on the diagnostic code. Despite these repeated repairs, the problem persists. Suspecting that the issue might be related to the dealership's service, I sought a second opinion from another Toyota dealership. Unfortunately, they provided the same diagnosis and solution, which again failed to resolve the issue. Given that the AWD system is a critical safety feature, especially in adverse driving conditions, I believe this issue should be considered a safety concern and potentially covered by a recall. Further given that the EVAP system is directly tied to the fuel it also should be considered a safety concerns. The repeated failure to address the root cause of the problem not only undermines the reliability of the vehicle but also compromises the safety of its occupants. I kindly request that the federal safety agency investigate this matter and consider issuing a recall to address this widespread issue. Your attention to this matter would be greatly appreciated, as it would ensure the safety and satisfaction of Toyota RAV4 owners. Thank you for your time and consideration. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I was told on 6/28/2024 that my car needs a new coolant bypass valve at a cost of 900.00 on researching this I see there is a class action suit against Toyota because there are so many people with this problem and it should be a recall. Not sure where to go from here .
My RAV4 does not hold a full tank of gas. It only allows half a tank get full of gasoline. Toyota says they don't know how to fix, as well as two other shops I have brought it to. There are no engine messages or any other signs of issues. Gas will gush out of the tank when filling up if I do not stop at half way.
"Engine Maintenance Required See Dealer" message keeps appearing on my bashboard took it to my local Toyota dealer and they confirmed the problem is the coolant bypass valve/hose $150 to find the find the problem and $700 to fix apparently this is common in 2019-2022 RAV4s. Now my car won't drive for long without over heating I have only had my car for a year and a half and drive less than 5,000 a year.
Bypass coolant valve is a known issue and while the valve isn’t broken or leaking the car is prompting for a fix that isn’t necessary of a fix.
The engine maintenance required turned on at55k miles for the coolant bypass. After trying to get it repaired they had 500 on back order. Thousands of Rav 4’s are experiencing this with over $800 quote to repair , this cannot just be a basic issue this is bigger.
The vehicle does not get anywhere near the advertised fuel tank capacity. The fuel tank size IS 14.5, but when fueling it gets >10. Causing the vehicle to get nowhere near the maximum mileage until empty.
Car is shaking when turned on. Will stall if car is not shifted to gear sometimes. When AC is on, car will jump rpm. car acceleration is weak and will jump to 5-6k rpm. car also smells burnt sometimes when driving. car also smells like gasoline sometimes. car does not hold proper amount of gasoline.
I have 2019 Toyota RAV4. 69,000 miles. I had issue this week when I was driving and park. The gas given by it self after I park the vehicle. and today all of the sudden stop on the road. The dash board shows me EPS light, Battery sign.
As I opened up the fuel door - a spring popped out - after I finished fueling- I tried to reopen the fuel door but could not - this can strand a driver when gas gets low as unable to refill the gas tank due to inability to open the door
The fuel system will not fill up the full tank. When the tank is half full it signals for the pump to stop and that is all that will go in the tank.
Unintended acceleration.
I am not able to fill up the fuel tank to capacity. 8 gallons is all I. An vet in the tank. The tank is not full. The gauges show it’s about at the half way mark.
The contact owns a 2019 Toyota Rav4. The contact stated that while attempting to refuel the vehicle, it was discovered that the interior latch to open the fuel door had malfunctioned, and the fuel door failed to open. The contact was unable to refuel the vehicle due to the failure. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 27,900.
Unknown
The engine on my Rav4 suddenly stopped without any notification while I was driving it on the freeway. I could have been severely injured from the risk of being rear ended by vehicles behind me. I have experienced this twice now, and both times, I have been on a busy highway in the middle of rush hour traffic. While driving, the engine would start sputtering and the vehicle will jolt and shake, eventually causing a warning message to appear that says power steering low, engine shutting off, place vehicle in Park. Then, when I turn the engine off, and try to restart it, it would flash a message that read Not ready to drive. After towing the vehicle to a service department, the vehicle would start up like normal, and the techs could not get vehicle to duplicate the issue. No codes would come up when they place it on a scanner, either. I researched the issue online, and it appears I am not the only one who has experienced this issue with the Rav4. Please reference https://www.rav4world.com/threads/engine-stopped-steering-power-low.323916/ This incident happened twice, once on 3/6 and again on 3/8. I thought the issue was fixed after having my vehicle towed on 3/6 to Freeman Toyota Service where they determined the issue was due to a recall on the fuel pump. However, the incident occurred again on 3/8, and I had to have the vehicle towed as the engine shut off while I was driving on the freeway blocking one lane of traffic on the interchange that connects one freeway to another. I was very fearful of other vehicles crashing into me as some of them were squeezing by between my vehicle and the retaining wall to get around me. It took the wrecker over an hour to get to me due to high traffic time. I have uploaded 2 tow bills I had to pay, and the service invoice for the recall work done. My vehicle is currently at another Toyota Service department where they are telling me they are unable to duplicate the issue.
Hybrid system malfunction. Repairs include replacement of motor cable #2 and frame wire. Advanced Corrosion was the explanation. Not covered under warranty (either 3yr/36K or platinum addt’l plan). Problem occurred at 36,366 miles (300+ miles just over standard warranty?) In the midst of delayed communicating with Toyota with no response after 3 days. Was told to reference TSB T-TT-0630-20. After researching, this problem is frequently referenced as being an issue. Should just be a recall at this point.
Engine maintenance light came on after a routine oil change. I took it to a toyota dealer, they said that it has something to do with the coolant system. The problem is ongoing with several toyota models, including rav4, Tacoma, Tundra, Camry, Sienna models 2018-2022. The problem is that the car can suddenly overheat and shut down on a busy highway, which is very Dangerous. Someone, can get killed, if this is not addressed. I don't know why there is not a recall already. The government should definitely get involved.
Fuel pump was replaced in May 2020 under recall. Recalled part had 12 month warranty. Rav4 was purchased used in May 2022 and in June, engine started stuttering. Contacted Toyota Field Reps at local dealership and they reset codes and suggested running different and better gas. A case was opened. In July, when filling up car, the car would not start at the pump. The car had to be towed on Sunday. Toyota Field Reps made aware that car would crank after banging on the fuel tank. A service call was placed again and before we could get it to the dealership on Thursday, when the car was filled up again at a different gas station, it would not start at the pump again. It was towed a second time to the dealership and Toyota did multiple tests to determine the fuel pump and hose over the saddle tank needed to be replaced. Toyota would not honor that replacement part saying this was the customers responsibility now. We paid for the replacement today 8/11/22 and drove it one hour and filled it up again and it hesitated and would not crank at the pump, finally fired up and then dies at the red light in traffic. It was taken back to the dealership.
Fuel pump malfunction. Stalling out with no warning or no previous issues
My fuel range went from 400 miles to 330 in a months time. I already had the recall fixed. I am concerned that the replacement fuel system is bad.
Took my 2019 RAV4 to Toyota of Orange. Like couple months ago for fuel pump recal but my vehicle stalls when driving on freeway or streets. Looses speed for 4 seconds and its scary reported issues to Toyota of Orange and they don’t fixed anything they only want to sell. They offer me services I don’t need for my vehicle. Got 2021 RAV4 rental from Enterprise and that one work just find no problems had it for about a week. If could get another another dealer that will be great.
gas meter is incorrect car is suppose to have 14.5 gallons fuel tank and im only able to out in 9 gallons. gas range meter is incorrect reads wrong range of mileage... need to be recall many people are complaining about this issue toyota should correct it...
Engine stalled on a highway going 65 mph in cruise control. I had 1/4 full fuel tank. just before the engine stopped working I read information on my dashboard I have to stop the car in .5 miles, than .3 miles and engine stalled within seconds. I was able to pull over with dead engine. I shut down the car using key (I have a mechanical key for ignition) and car started with a message 'hybrid system malfunction. output power reduced . visit your dealer." I visited local mechanic who read the codes and instructed its a faulty fuel pump. I filled the car with more gas and drove couple of miles with reduced power. I left the car for 36 hours and it started to run ok by itself. dealer replaced fuel pump and now it works fine. The day of incident I was able to smell gas around engine bay before incident. I was able to smell strong gas smell after incident after I filled more gas in the vehicle most likely from engine bay fresh air intake. My assumption is this is due to bad fuel/air ratio and the result was unburned fuel. The week before the incident engine felt it kicked in roughly on its start up (my car is a hybrid). I had a fuel pump recall performed 4 months before but the fuel pump failed based on codes p319300 p008700 p107a2a . dealer replaced fuel pump (2nd time) and car works well and much smoother than before.
The contact owns a 2019 Toyota RAV4. The contact stated that there was an unknown blinking red light on the instrument cluster. The contact received notification of the federal safety agency campaign number: 20V682000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact called the local dealer and it was confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. Parts distribution disconnect. The approximate failure mileage was 25,000.
When filling the fuel tank when full fuel spills out until the pump handle finally shuts off. Estimated spillage is about 1/2 to 1 cup of fuel. This has happened more than 6 times
Unknown component or system While driving on the Interstate during rush hour, traveling 60 miles an hour, another vehicle along side us entered our lane and we had to avoid a collision by aggressive braking and steering. Following this maneuver, our vehicle immediately shut down. An 18 wheel barely missed crashing into our rear. It took us approximately 1 minute to realize we needed to put the car in park, step on the brake, and push the ignition button to restart the vehicle.
Case number started at Toyota Customer service: 210701002045 Requested an unacceptable time to answer of 8 weeks. There was a recall for this vehicle. I wasnt notified and the recall also doesnt show in any website (Not Toyota not in the goverment one). I went on a trip thousands mile aways from home, I was up in the montains, the car got broken in a very bad place where I had to spend almost $2,000 dollars due to Towing, meal and hotel expenses (as the dealer was closed on a weekend). I am trying to solve this with Toyota but they say I have to wait 8 weeks to start looking at my case. It is unacceptable . I need a reimbursement ASAP.
My vehicle is stalling when at low speed and sometimes high speed. It fails to accelerate. Every time I contact my service provider they push back my service another month.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Toyota RAV4?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history