Engine maintenance message appeared on my dash. I took it to Big O's Tires and Service a car repair service provider. Upon connecting to the car and inspecting they told me it was a faulty possibly leaking engine coolant valve. The cost to repair is $916. This may cause the engine to overheat and possibly fail due to overheating. This can be very dangerous because it will happen if it does happen while driving which could cause an accident. I have not fixed the issue yet due to a lack of funds but will have to fix it as soon as a get paid because I drive my family in this car and cannot risk catastrophic engine failure. Please have Toyota recall this part as it is a very common failure amongst 2019-2023 Rav4s. A class action lawsuit is underway due to how often this issue arises. Thank you for your time.
2020 Toyota RAV4 engine complaints
Page 2 of 8: complaints 11 to 40 of 193, newest first, as owners wrote them.
I was driving the car with no issues on [XXX]- made two 30-minute trips with no issues the same day. During a 15-minute drive, the car was fine until I was at an intersection 12 minutes into the drive [XXX] and [XXX] ). I was stopped at the intersection for maybe a minute, and when the traffic light turned green, I released my brake and went to accelerate when I got the following display message: "Engine Stopped Steering Power Low." The engine turned off, and I couldn't get the car to budge in drive or reverse. When I tried pressing on the gas pedal, it wouldn't budge and felt very stiff. I'm thankful this happened at a smaller intersection on a Sunday evening because my car wouldn't start back up and was stuck in the dead center of this intersection. Cars going East and South all had to drive around me. This put my safety at risk because I had to hop out of my car and redirect people around it until a kind passerby pulled over to help push my car to the right-side turning lane. I was standing in the middle of an intersection on a road with a 35-40 mph speed limit. After pushing the car to the curb and calling a few towing places (maybe 20 minutes later), I tried starting the car again, and it started with no issues whatsoever. I drove it the rest of the way back (for 3 minutes) with no problems, and I made another three 20-25 minute drives on it today. Nothing sounds wrong with the car; it's running with no issues. I would take my car to the dealership for a diagnostic, but I can't afford to right now. I will put my battery on a tender and use a multimeter to check the voltage within the next few days. Regular maintenance has been kept, and the car has never had this happen prior. I've never received the "Engine Stopped Steering Power Low" message prior to this incident. The car is available for inspection upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Coolant Bypass Valve failure at 40k miles - 2020 rav4. Replacement at dealership is costing over 800$.
The coolant bypass valuve has failed. There looks to be a class action lawsuit currently underway.
My vehicle Toyota RAV4 Hybrid 2020 began lost power and jerk on highway driving and then following messages appeared: Hybrid System Malfunction, A malfunction in electronic control of engine, throttle or automatic transmission has been detected and check engine light. This happened in September 2024. Toyota dealership replaced the low fuel pressure sensor A after my complaint and vehicle diagnostic, but it did not help. I recently had the same problem while driving on the highway for a long distance.
I have a 20202 Rav4 Hybrid and the engine short block has malfunctioned due to no error on my part, in my research there was a recall for this EXACTLY this issues in other cars of this year/make/model - although my vehicle initially did not qualify for this I believe that this in fact related and that Toyota should be responsible for the repair or replacement of the engine. The car is currently with a Toyota Dealership Service Center, Lake City Toyota in Seattle, WA but they have not been helpful. They have given me vague answers and have sent the engine offsite to a machine shop and keep requesting that I pour additional money into fixing an engine that clearly had a manufacturer defect. My car has always been serviced at Toyota dealerships, as suggested by Toyota. My car has never had previous issues until the engine light came on one day, i checked the coolant and it was empty - first replaced the fluid, let it sit overnight, then drove it around the block to circulate the coolant - when the reservoir emptied again I immediately made an appointment to take it in. The Dealership has not given me any paper invoices or written confirmation/notice of what is happening aside form continuing to ask me to pay more money to fix an engine that is clearly related to the national recall issued.
Coolant Bypass Valve, vehicle is available for inspection. Confirmed by Certified Toyota Dealership. There is a know defect with the Coolant Bypass Valve in 2019-2023 Toyota Rav4. Maintenance Required Light Only Comes on when the Heat is switched to Air Conditioner.
See attached document for complaint.
"Engine maintenance required. Visit your dealer" prompt after turning on Air conditioning. Message of Engine coolant bypass valve circuit short to battery or open upon diagnostic test
My Rav4 xle 2020. Starting the engine up it shakes and blows white smokes for 5 seconds and smooths out. This symptoms happens every time when engine is turn on I have to fill coolant once a week.
Coolant relief valve failure
Shortly after having vehicle serviced at Toyota the engine maintenance light came on. Imagine my surprise at learning that many other Rav4 owners have the same exact issue right around the 65,000 mile mark. But regardless I toke it to the Toyota dealer to have them diagnose the issue and under the advisement of the technician opt in for the repair so that my car “wouldn’t have more serious problems as a result [of not fixing the coolant bypass valve].” So now I have to pay $1000 for repair when I have had the car just the tiniest bit over 4 years (which is how long the warranty lasted).
The coolant valve is malfunctioning and causing an engine safety light to be on constantly
Coolant bypass valve failure
The wiring harness to the lithium battery is corroded, and it is unregulated. My repair shop said the car is unsafe to drive because of the amount of unregulated electricity in the battery. Also, the cruise control doesn't work. My repair shop says this is happening to other vehicles. Parts and labor total almost $7,000.
Warning light: Engine Maintenance Required Coolant Bypass Valve
Continuous Warning light display : Engine Maintenance Required Visit Your Dealer. The OBD diagnostic scanner lists the faulty system as follows: Code P268115. Engine coolant bypass valve circuit short to battery or open circuit. This appears to be a common fault on certain Toyota RAV4 years.
The contact owns a 2020 Toyota Rav4. The contact stated that upon starting the vehicle, there was an abnormal amount of white smoke and an abnormal odor coming from the vehicle. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that the engine needed to be replaced due to coolant intrusion. The vehicle was not repaired. The contact referenced the federal safety agency Campaign Number: 20V064000 (ENGINE AND ENGINE COOLING) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.
at only 55k miles my 2020 toyota rav4 has shown an “engine maintenance required” sign. not to be mistaken with general maintenance. apparently this is a widely common issue where brand new toyotas are having cooling bypass valve issue. however concerningly so, because there are no recalls for this problem yet seemingly every rav4 has this problem? how is there no recall, everyone is paying out of pocket for essentially poor manufacturing, its outrageous, also considering the part itself is under $100 but some dealers are charging anywhere to $600-$1300. it’s predatory and outright wrong.
The coolant bypass valve has been failed prematurely therefor engine heat up and there is a warning on my dashboard that say "engine maintenance required"
Check engine light came on and noted a malfunction in the electronic control of the engine, throttle or transmission. When taken to the dealer they found code P012807 related to engine cooling and suggested a replacement of the thermostat. This part should have a life of 100k or 8-10 years and car currently has less than 60k miles and 4 years old. Asked the dealership about known recall 20TA04 - for engine cooling recall but they insisted my car was not impacted. This is a safety issue as it could result in overheating of the engine leading to fire hazards.
What component or system failed or malfunctioned, and is it available for inspection upon request? The Engine Coolant Bypass Valve B failed. The check engine light comes on and disables All-Wheel-Drive, Radar Cruise Control, Lane Keep Assist and interrupts functionality of the infortainment system. I am also worried that it could have a negative effect on the operation of the engine. How was your safety or the safety of others put at risk? My safety or the safety of others was not put at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The problem has been confirmed by an independent service center. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No
Bypass Coolant Valve malfunctioned resulting in Engine Maintenance Required triggered. Because I do distance driving at high speeds, any potential engine issue poses a risk to safety. The problem has been confirmed by a dealer/service center. The component in question has not been inspected by the manufacturer. The warning sign that states "Engine Maintenance Required" appeared on the dashboard and remains.
•August 19, 2022: All emergency/error code lights came on the dash while driving on highway. The vehicle was taken to Don McGill Toyota for service. In that time, all error codes came back and went away a few times on their own. Vehicle was taken on 08/20/2022 (please refer to service records) in which it was originally deemed there were no issues with the vehicle. Toyota recommended that if the problem persists, bring the vehicle back in. •August 26, 2022: Vehicle emergency lights came back on while driving on the highway again. The vehicle was taken back to Don McGill Toyota for a service emergency. Was told the Vehicle needed a sensor replaced. Got the vehicle back on September 15, 2022. •September 6, 2023: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota. Another part was replaced (please refer to service records) and the vehicle was returned on September 9, 2023. •August 2024: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota for a break service as well as getting this emergency lights issue resolved. The vehicle was picked up 5 hours later, however upon driving a little in the dealership parking lot, emergency lights came back on. Immediately went back and brought it up to the service advisor, who then took the car back for another 1 hour and deemed the vehicle needed to be “recalibrated”. This recalibration was completed, then left the dealership. •September 3, 2024: Vehicle emergency lights come back on. This time the vehicle struggled to brake when the lights came on. The vehicle was taken into Don McGill Toyota for immediate service. Breaks were looked at and recalibration was completed. Vehicle returned on September 6, 2024. •September 14, 2024: Vehicle emergency lights come back on. The vehicle was taken to Don McGill Toyota for emergency service. Brakes were checked and the vehicle was driven around to bring the lights up. The vehicle was given back on October 1, 2024, after the ser
My Toyota 2020 RAV4 has a dangerous design flaw. It rolls when turned off and in drive mode. For example, my driveway is on an incline, and a couple times I have pulled into my driveway, gotten distracted, and I forgot to put the car in Park. When I hit the on/off button, the car rolls backwards, accelerating due to gravity. If you're not quick, you can end up rolling out into traffic, or running someone over that is behind your car. All the other cars I've ever owned didn't roll when the car was turned off unless you were in neutral. I believe this is a design flaw because I've spoken to a few other RAV4 owners that have experienced the same thing, and on one occasion, I tested it on another RAV4 and it was the same. I can see this being very dangerous. If you are standing outside of the car and hit the on/off button while it's in drive, you would get knocked down by the door, and your car would be rolling without you in the car.
The contact owns a 2020 Toyota Rav4. The contact received notification of the federal safety agency Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer, where the driver's side seat belt sensor was replaced. Additionally, the contact stated that the vehicle had failed to exceed 1,000 RPM while driving. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.
Known coolant bypass valve issue dealership declining to cover it although it’s impacting a ton of people.
Service engine message coolant bypass valve circuit short to battery or open code P268115
Engine Maintenance Light on. After inspection at dealership, the cause was determined as Coolant By-pass valve stuck closed
I have had an "Engine Maintenance Required" warning light on since I purchased the vehicle (used) and have had it checked out by my local mechanic and the Toyota dealer. It is due to the coolant bypass valve malfunctioning. Apparently this is an extremely common issue according to the class action lawsuit and should NOT be put on the customer to pay for this when my odometer has not even hit 60k. A recall needs to be issued for this once and for all.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Toyota RAV4?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history