2023 Toyota RAV4 brakes problems

Filed Oct 15, 2026 · Brakes · PA

Vehicle produces a plastic-sounding grinding noise from the brake area whenever the vehicle rolls over a rough or uneven road surface while braking. This has occurred since purchase of the vehicle and continues to occur as of current mileage (approximately 45,000 miles). The noise is distinct from normal brake pad wear squeal -- it sounds like a hard plastic component grinding or rattling, correlated specifically with braking over bumps/uneven pavement rather than constant or speed-dependent. The dealer has not yet inspected this specific complaint. Other owners of the same model year have filed similar the federal safety agency complaints describing brake grinding/squealing noise beginning well under 10,000 miles, with one referencing a technical service bulletin for brake noise on 2019-2023 model year vehicles of this make/model, suggesting this may be a widespread condition rather than an isolated defect.

Filed Jul 31, 2026 · Brakes, Driver assistance · CA

While making a left turn in my 2026 Toyota RAV4, the vehicle's Automatic Emergency Braking / Pre-Collision System suddenly activated without cause. The system sounded an audible warning beep and forced the vehicle to brake and come to a hard stop mid-turn. There was nothing in front of me that should have triggered the system. This put my safety and the safety of other drivers at risk. The forced stop occurred suddenly and unexpectedly while turning, which nearly caused an accident, as vehicles behind me had no warning that I would suddenly brake mid-turn. There were no warning lamps or dashboard messages prior to the incident — the false activation occurred suddenly with no prior symptoms. I have dashcam footage of the incident attached below.

Filed Jul 4, 2026 · Brakes, Driver assistance · FL · 1 injury

Vehicle was traveling straight approximately 70–80 mph in very light drizzle. No warning lights or messages before the event. Vehicle suddenly entered an uncontrolled spin multiple times. During the spin, I heard a grinding noise. After stopping, brake/parking brake system warnings appeared on the dash, video after the event recorded.

Filed Mar 19, 2026 · Brakes, Steering · NV

The 2023 Toyota RAV4 8-speed transmission is catastrophically defective and poses an immediate safety hazard. It exhibits severe hesitation, slipping, and lurching when accelerating from a stop or low speed, and when attempting to merge into high-speed traffic (I-15/Las Vegas), creating a high risk of rear-end collisions. During these events, the RPMs spike and fall rapidly but the vehicle fails to accelerate. Furthermore, the vehicle lunges forward while the brakes are applied. The engine actively fights the braking system, requiring extreme physical force to stop the car and prevent front-end collisions. This lunging has repeatedly triggered the Pre-Collision System, causing the seatbelts to lock and tension against the driver’s body. Additionally, the vehicle exhibits steering resistance and feedback during turns, making it difficult to maneuver safely. The local dealership (AutoNation Toyota Las Vegas) inspected the vehicle and claimed these life-threatening behaviors are "normal" for this model.

Filed Dec 10, 2025 · Brakes, Driver assistance · CA · crash

While entering my garage (video available)The 2023 Hybrid Rav 4 accelerated on its own when I was braking to put it into reverse to back up to realign to park in my space. I was hitting the brake and the brake lights were on the dashboard while the car keep accelerating hitting the garage wall.

Filed Oct 27, 2025 · Airbags, Brakes · FL

Vehicle: 2023 Toyota RAV4 Hybrid Issue: Persistent brake noise, safety hazard, manufacturer negligence I leased a 2023 Toyota RAV4 Hybrid from Clermont Toyota (Florida). Well before reaching 5,000 miles, the brakes began squealing and grinding, posing a potential safety hazard. Multiple service visits failed to correct the issue. Toyota Motor Sales, U.S.A., Inc. and its distributor, Southeast Toyota Distributors LLC, have long been aware of this defect, as documented in Technical Service Bulletin TSB-0001-22 and numerous the federal safety agency consumer reports describing similar brake failures and noises in 2019–2023 RAV4 models. Despite repeated notice, Toyota refused to repair or replace the defective vehicle and denied my Lemon Law claim through an arbitration panel connected to manufacturer counsel. This unresolved brake defect creates danger to the driver, passengers, and others on the road. Toyota’s continued sale and lease of vehicles with known braking issues constitute a serious public safety concern. I request that the federal safety agency investigate Toyota’s knowledge of these defects, evaluate the adequacy of its response, and consider a recall to protect consumers nationwide. Contact: [XXX] – [XXX] – [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 16, 2025 · Brakes · ME

1.) The component/system that failed/malfunctioned is the brakes and/or anti-lock braking system. 2.) My safety and that of the people in front of the vehicle is placed at risk because the vehicle's braking system fails, allowing the vehicle to surge forward for a split second, temporarily out of control. 3.) While the problem has occurred many times with various drivers, the Toyota service technician said they were unable to reproduce the issue. However, with the information (date/time) I have provided, they confirmed the computer indicates the ABS system was triggered each time. 4.) The vehicle has been inspected by the Toyota service center representatives. 5.) There were no warnings, messages or other symptoms prior to the brakes failing. The problem is the braking ability is failing for a split second, when the car hits a bump. The size of the bump can be as small as the crack in the asphalt where two roads meet. The problem occurs when I am driving at slow speeds and riding the brake because I am in a situation like being in slow-moving bumper-to-bumper traffic, approaching an intersection requiring a stop, or coasting down hill. On numerous occasions, the brakes release, allowing the car to surge forward for a split second, before re-engaging. Toyota has told me it is the ABS working as intended. To be clear, the braking failure is happening at slow speeds and on dry pavement. This is not how ABS normally works. I have driven numerous makes and models of cars for 40 years and I have never experienced this type of situation triggering an ABS system. I report this to Toyota each time I bring my car in for regular maintenance. During the last visit, my regular service technician told me that they have now seen at least 5 or 6 other cars doing what I have described above. I don't have a specific date of the incidence because it happens frequently and has done so since I bought the car (10/01/23), so below, I am just listing the last time I reported it to Toyota.

Filed Jul 6, 2025 · Acceleration, Brakes · NY · crash · 1 injury

The vehicle was a 2023 Toyota RAV4 hybrid. When the driver attempted to park the vehicle in a parking lot, it suddenly began moving forward without use of the accelerator. The driver applied the brakes but the pedal went to the floor without braking. The vehicle seemed to be moving faster than expected without use of the gas pedal and went through the parking lot. The driver stopped the vehicle by running up over a curb, through a traffic island with soft dirt and mulch and finally crashing into a metal storage unit. Two air bags deployed. Toyota was notified of the crash and a Toyota representative made the 911 call. A New York state trooper and two fire trucks arrived. The vehicle was towed and eventually collected by our insurance company. The tow truck driver said the brake pedal went to the floor when he tried it. The car was declared a total loss. 1. The notable failure was in the braking system. The car also seemed to be traveling faster than it should and didn't slow down. The insurance company has the vehicle now. 2. The safety issue was loss of speed and braking control of the vehicle. Steering was normal. Fortunately the parking lot had few cars or people in it. 3. No investigation of the problem aside from assessment of damage that I know of. 4. Liberty Mutual assessed the damage. The NY state trooper made a collision information form and gave us a copy. 5. No warning lights or related symptoms were noted prior to the car traveling on its own. After the crash, a local Toyota dealer called and said that they were notified that the check engine light was on and there was a problem with the hybrid system, along with other warnings.

Filed Jul 1, 2025 · Airbags, Brakes · FL

My 2023 Toyota RAV4 Hybrid has had squeaky brakes for many months (from 4,000 miles onward and consistently continues to be an annoyance, nuisance, and safety hazard while intensifying in frequency), but despite taking the vehicle to the Toyota dealer more than 4 times, they have been unable to repair the issue. At least twice the air bag sensors have come on for the backseat when there was nobody seated in the backseat, distracting me from safely driving. Toyota has done nothing to right the wrong mechanically, refund me for the vehicle (a lease) or offer a replacement. I have a 14 page document filed with the Florida Attorney General Lemon Law Division thoroughly indicating why these ongoing mechanical failures, safety hazards, nuisances and distractions to me the driver substantially impair the use, value, and safety of the vehicle—fulfilling key criteria under Florida Statutes § 681.102 and § 681.104, which I am happy to provide all consumers and attorneys willing to launch a CLASS ACTION against Toyota. Florida law defines "impairment of value" not by market collapse, but by any reasonable reduction in consumer confidence. Consumer disclosure laws require honesty about defects. Florida Statute § 681.102(15) defines a “nonconformity” as a defect that “substantially impairs the use, value, or safety of the motor vehicle.” My vehicle has been subject to repair more than 4 times for the same defect within 24 months and thus qualifies for relief. The manufacturer’s failure to permanently correct the squeaky brakes—even after attempted repairs—demonstrates a pattern of unresolved nonconformity. The squeaky brake issue is not a cosmetic inconvenience—it affects the vehicle's functionality, resale integrity, and safety assurance. Toyota acknowledges the problem exists (via TSB) but has failed to provide a lasting solution. If unresolved, this defect would materially concern any reasonable consumer and diminish confidence in the vehicle’s reliability and safety.

Filed Apr 15, 2025 · Airbags, Brakes · VA · crash

Sudden surge and acceleration upon parking. I had brakes depressed pulling into a parking space when the vehicle felt like it jumped and quickly accelerated. It veered left missing the parked van in front of me but crashing into the parked Honda Accord two spots over and one in front. It crashed into the back tire and fender area of the passenger side of the Honda pushing it completely out of its spot and sideways. My vehicle kept going even though pushing the brakes to stop. I had to force it into park to stop. The car’s air bags deployed but my Toyota’s airbags nor crash warning system worked.