2023 Toyota RAV4 engine problems

Filed Oct 17, 2026 · Electrical, Engine · MA

While in stop and go traffic during heavy rain, vehicle stalled and would not restart. After several attempts, it did restart but ran very rough. A couple days before, a red warning light came on for the steering system, also during a rain event.

Filed Aug 31, 2026 · Electrical, Engine · FL

The vehicle experienced a sudden, severe loss of vehicle control while driving twice. Without any warning lights, dash indicators, or stored error codes, it began violently surging and decelerating uncontrollably around 20 mph with severe bucking. My [XXX] daughter was driving. Fortunately, this occurred on a quiet local residential road at 5 am; had this sudden failure occurred at highway speeds, it would have resulted in a catastrophic rear-end collision. The vehicle was purchased in May 2023, has 42k miles, and was used normally for school commuting. Incident 1 (XXX): Towed to Toyota. Techs could not diagnose it and opened a Tech Case. Per instructions, dealer replaced shifter assembly due to internal short (Part 33560-0R070). However, within 24 hours of return, the exact same dangerous failure reoccurred suddenly without warning in mild traffic. Experiencing an uncontrollable vehicle was terrifying. Fortunately no crash occurred, but it was towed back immediately. When I raised urgent safety concerns and sought a permanent resolution, Toyota stated it takes 60 days for review. During this period, if the dealer requests loaner return, I must return it immediately. They further stated that as soon as the dealer declares the vehicle "ready for pickup," I must retrieve it immediately or be charged daily storage fees. When I asked how the dealer could diagnose and repair the car entirely on their own—without Toyota Corporate engineering instructions while Toyota is supposedly still investigating the root cause—Toyota had no logical answer. When I asked who assumes legal and safety responsibility if another failure or accident occurs after pickup, Toyota Executive Offices explicitly stated "no one" assumes responsibility. No reasonable consumer would drive an unresolved, life-threatening defect under an explicit disclaimer of safety accountability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 12, 2026 · Engine, Fuel system · GA

On August 6 2026, my RAV4 just cut off at the traffic light. The car was completely dead. I was unable to unlock the trunk but the doors did open. The vehicle was towed to the local dealership. The tow truck man hooked up his portable car charger and the car started. On August 8, 2026 the car cut off after parking in a parking space and would not start so I had to get a jump off. After driving for approximately 50 miles to home, I got a low voltage warning and a statement the battery is charging. The local Toyota dealership did a diagnostic test on August 11, 2026 and stated the battery, starter, and alternator were okay. The same thing happened again on August 12, 2026. The car just cut off after stopping in the parking lot. After getting a jump off, I received a message that the battery is charging. Also, the car shifts speed while driving.

Filed May 4, 2026 · Engine · PR

Was moving forward when all of the sudden the tailpipe flew off (metal thing in the muffler). No real cause, moves the vehicle normally oyt of the driveway and it just flew off.

Filed Mar 4, 2026 · Engine, Steering · OH

On a rainy day after driving on the interstate, I pulled into a drive thru. Once there and idling for a few minutes, I tried moving forward and the car rough idled, shows message on dash "Engine Stopped, Power Stering Low" and had reduced engine power and no power steering and then stalls out. I tried turning it back on and it stays on for less than 3 seconds and shuts off. I had it towed to the dealer and they say there are no codes. After reading online, multiple other users experienced the exact same thing when its raining, wipers were on and they were idling after a trip on the interstate. If this would have occurred on the interstate and I lost engine power and reduced steering, it would cause major safety concerns. There were no warning lights prior to the issue and the only thing that flashed for a second when the engine stalled was the power steering, check engine and battery light. Toyota checked the battery and said its at 100%. Dealer cannot identify and issue, but I couldnt drive, had no power steering and had to have the car towed.

Filed Nov 26, 2025 · Electrical, Engine · NJ

I purchased my 2023 Toyota RAV4 new back on March 13,2023. 10 days later on March 23 it was raining as I pulled into BJ’s parking lot, I parked and began fumbling around getting my bag and keys together when my car started shaking and sputtering eventually shutting down with an error message engine stopped steering power low. After a call to the salesman I was able to get my car restarted after 15minutes and many failed attempts. Car was bought back to service the following week and I was told car was not properly programmed at delivery, it was now programmed correctly and this should not happen again. April 17,2023 my son pulling into Tractor supply , raining out, pulls into spot and car again shakes, sputters and shuts off, same message engine stopped steering power low. After many attempts car restarts approximately 20 minutes later. Car serviced codes ARE FOUND and cleared, road tested and told car was ok. May 31,2025 I was driving down Rt 80, pouring rain when traffic comes to a complete stop due to accident ahead. Car starts shaking, sputtering and shuts down. Same message code as always. I turned the car completely off as not to kill battery and started to goggle the RAV4. I attempted to restart the car numerous times. Called for a tow, prayed that I didn’t get killed once traffic started to move. Finally 1-1/2 hours later it started. Traffic began moving 15 minutes after I got it started. Took in for service, charged $199.61 only to be told there were no codes. Problem could not be duplicated and in the future to always disable the start/stop button while using the vehicle. October30, 2025 raining, I stopped at Panera drive thru. Placed an order waiting in line and car shuts down, same error code, couldn’t restart car for 20 minutes. Took to Toyota November 5th same response no codes and cannot replicate issue, car is ok. Please help rectify this before someone gets killed!

Filed May 29, 2025 · Electrical, Engine · TX

During a rain Storm water was able to leak into my air intake box causing my air filter to become soaked. This caused my car to malfunction, come to an abrupt stop, alerting me of a "engine and steering failure" shutting my car off and becoming stranded on the highway.

Filed May 21, 2025 · Engine, Steering · VA

Was driving in heavy rain after about a 35 mile commute and put the car in park. After about 5 minutes of sitting in park the car turned completely off by itself for a couple of seconds and restarted. Warning message “engine stopped steering power low” popped up on dash and was visible smoke coming from under the hood with a slight burning smell. This is a first incident for the car as it has been driven for about 2 years with a little over 35,100 miles on it.

Filed May 21, 2025 · Engine, Steering · NC

My Toyota RAV 4 the power steering light comes on and says low & it always happens when it’s heavy raining and my wipers are on. The car just stops & wont start again for about 20 mins. This is super dangerous and has happened 4 times now

Filed May 13, 2025 · Engine · MA

This problem has occurred twice now. First time: 4/19/2023 The car was brought to the car wash, I pulled into my parking spot the car shut off. When I attempted to turn the car back on the car would not start. The car showed a check engine light along with a steering wheel with an exclamation point. The dash said "Engine Stopped Steering Power Low". The car was immediately brought to the dealership after the car would start. The dealership did not find anything wrong along with no codes. The dealership assured me this would not happen while driving. Second Time: 5/9/2025 The car stalled mid driving in the rain and said "Engine Stopped Steering Power Low", car would not turnback on. Car has not been brought to the dealership again due to them not responding. This problem happening while driving puts not only my life at risk but everyone on the road.