2023 Toyota RAV4: engine stalls while driving

Filed Oct 17, 2026 · Electrical, Engine · MA

While in stop and go traffic during heavy rain, vehicle stalled and would not restart. After several attempts, it did restart but ran very rough. A couple days before, a red warning light came on for the steering system, also during a rain event.

Filed Oct 10, 2026 · Fuel system · NC

Fuel gauge needle drops to empty when approximately one-quarter tank or more of fuel remains. First noticedXXX; the exact day is approximate (first noticed sometime in XXX). Dealer (Toyota of Gastonia, [XXX], phone [XXX]; repair order XXX dated XXX) diagnosed a suspected deformed fuel tank and faulty fuel level sender causing improper fuel level readings, and quoted $1,788.85 for tank removal, inspection, and tank assembly replacement. This is the same defect family Toyota acknowledged in Technical Service Bulletin T-SB-0109-20 and Customer Support Program 20TE04 (fuel tank shape variation causing the fuel sender gauge to read incorrectly) for 2019-2021 RAV4 Hybrids. The vehicle is a 2023 RAV4 Hybrid exhibiting the same failure. Inaccurate fuel level readings prevent the driver from knowing the actual fuel remaining, creating a risk of unexpected fuel exhaustion and stalling. Dealer has submitted a coverage request to Toyota; no resolution yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 7, 2026 · Driver assistance, Electrical · 58,829 miles · AR

The contact owns a 2023 Toyota RAV4. The contact stated that while driving at 46 MPH in heavy rain, a warning message indicating that the pre-collision sensor was blocked and needed to be cleared, was displayed temporarily, and the contact continued driving. The contact stated that the vehicle suddenly lost motive power shortly after, and the message "Steering power is low; please contact dealer" was displayed. The vehicle stalled and failed to restart.The following day, the contact's husband successfully restarted the vehicle, but the vehicle immediately stalled again, displaying a "Pre-collision malfunction; please call dealer" message. A local dealer was contacted, and the contact spoke with a receptionist regarding the battery, but the vehicle was neither diagnosed nor repaired. The manufacturer had not been made aware of the failure. The failure mileage was approximately 58,829.

Filed Jun 1, 2026 · Electrical · OH

The video display screen shuts off while driving. You end of trying to get it going again while driving and getting distracted. Ongoing issue over a dozen times in last 2 years.

Filed Apr 30, 2026 · Steering · TX

During the day after driving in rain in a 2023 Rav 4 LE AWD with 19000 miles car turned off. I was parked with it idling and with no warning stalled. I turned on multiple times and it kept stalling out. Finally a message appeared on dash "power steering low". After inspecting under hood and seeing all fluids ok I tried car again (maybe 10 min) and it started. Drove around parking lot it was fine. Drove to my mechanic. No error codes, battery was in good shape. This is very concerning. Suspect water in a hard rain somehow got in car. I was on major roads prior to parking, no huge puddles. Others online have mentioned this issue with no real answer and fears this will occur again while driving. NEEDS A RECAL.

Filed Mar 4, 2026 · Engine, Steering · OH

On a rainy day after driving on the interstate, I pulled into a drive thru. Once there and idling for a few minutes, I tried moving forward and the car rough idled, shows message on dash "Engine Stopped, Power Stering Low" and had reduced engine power and no power steering and then stalls out. I tried turning it back on and it stays on for less than 3 seconds and shuts off. I had it towed to the dealer and they say there are no codes. After reading online, multiple other users experienced the exact same thing when its raining, wipers were on and they were idling after a trip on the interstate. If this would have occurred on the interstate and I lost engine power and reduced steering, it would cause major safety concerns. There were no warning lights prior to the issue and the only thing that flashed for a second when the engine stalled was the power steering, check engine and battery light. Toyota checked the battery and said its at 100%. Dealer cannot identify and issue, but I couldnt drive, had no power steering and had to have the car towed.

Filed May 13, 2025 · Engine · MA

This problem has occurred twice now. First time: 4/19/2023 The car was brought to the car wash, I pulled into my parking spot the car shut off. When I attempted to turn the car back on the car would not start. The car showed a check engine light along with a steering wheel with an exclamation point. The dash said "Engine Stopped Steering Power Low". The car was immediately brought to the dealership after the car would start. The dealership did not find anything wrong along with no codes. The dealership assured me this would not happen while driving. Second Time: 5/9/2025 The car stalled mid driving in the rain and said "Engine Stopped Steering Power Low", car would not turnback on. Car has not been brought to the dealership again due to them not responding. This problem happening while driving puts not only my life at risk but everyone on the road.

Filed May 5, 2025 · Engine, Steering · TX

UNKNOWN: It happened during a heavy storm on my 40 miles to work and all the symbols lights suddenly lit up on the dashboard. The car died and the steering wheel got heavy when I tried to pull to the emergency lane. Luckily I was able to pull over, but it almost caused an accident as I was in the middle lane. I tried to start up the car again, but it would crank up, but died instantly and the dash would show "Ignition on" on the top left and "Engine Stopped: Power Steering Low". I called the dealership and talked to the service department and the service advisor think it was the battery, but he told me to try starting it after 5-10 minutes, if not, to call the tow company and tow the car to dealership for further inspection. I let it sit for 10 minutes and was able to start it back up and drove it straight to the nearest Toyota Dealership. While driving to the dealership, the car kept choking/stalling when pressing on the gas after braking. They examined with their scanners and the battery was in good condition and my car has gas (about 3/4 tank full) and they said the scans reported no issues. This is a concerning issue as I could had lost my life or possibly cause major accident and involve other people life.

Filed Apr 25, 2025 · Electrical, Engine · MD

I was sitting in a drive thru with my car in drive , foot on break and all of a sudden it starts to shake and struggle to stay on . Then it stalls out , engine shuts completely off and my check engine light came on! The error messages on the screen read : Engine stopped , power steering low , precollision system malfunction , and parking brake malfunction. As I tried to restart it , It wouldn’t start back up and stay on at all. After a good 20 min or so , and after being pushed out of the drive thru and my order canceled, my car starts back up as if nothing happened. Had my car checked for codes , and guess what ? NOTHING ! It’s happened to me about 6 times in about a year and two month of owning it ! Nobody can figure out what the problem is . I also have issues randomly with my radio screen . When my phone is hooked up to CarPlay , it will sometimes kick me out and reconnect by itself , the screen completely shutting off and turning back on by itself , there’s times I was listening to pandora and it won’t allow me to click my station and show the song playing , and other issues. Had this happen too many times to count and within the first couple months of owning it , I took it back and they couldn’t figure out the issue. It never happened while they had it .

Filed Feb 23, 2025 · Steering · MS

Car shut off while driving because warning light for the power steering came on p.451stating check power steering fluid level. Vehicle has either a sealed power steering system or its electric. It was raining at the time that this happened. This is a big risk factor that could have led to a wreck but thank god that it did not was able to get out of traffic and stop. It took an hour of waiting before the vehicle would start back up and run properly. Unable to reproduce the problem at this time.

Filed Dec 30, 2024 · Electrical, Engine · CA

This happened on [XXX] in Oakland CA, it was a rainy day. I drove off the freeway and then parked the vehicle in the parking lot. The car was in idle mode. After about 10 minutes the engine started to stall, and then shut off completely. I tried to restart the engine but it failed. The dashboard showed an error message "Engine Stopped, Steering Power Low". I suspected that rainwater entered into the engine from the air intake. After waiting for about 2 hours, I was able to restart the vehicle, and then everything seemed to be normal. Toyota should announce a recall for this problem as this is very dangerous to operate the vehicle on the freeway on rainy days. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 5, 2024 · Transmission · FL

I am an owner of new 2023 RAV4 and believe some of the newer 2023 & 2024 Toyota Rav4 models with ICE (non-hybrid) have a potentially dangerous defect with the transmission system, which causes these cars to jerk and stutter when the gas pedal is lightly depressed (light acceleration) when the car speed is between 15 and 40 mph and tachometer is between 1500 and 2500 RPM. The reason I believe this defect is potentially dangerous is that a few weeks ago I was going through a school zone with an active 20mph limit, and when trying to keep the speed at 20mph, experienced jerkiness, RPM jump and sudden speed bouncing (momentary jerking from lower to faster and back to lower speeds a few times in a row). Typically this issue is a lot more subtle but occasionally it is so bad that I have a momentary feeling of loosing control over the speed of the car and active school zone is the least place I'd like that to happen. Besides, these stutters are pretty bad disturbers when they occur drawing focus away from the road and onto the car itself, since it does feel like the car is about to stall. I have visited the dealership twice regarding this concern, however since these stuttering have a random nature I was not able to replicate the issue during my visits to the dealership. I have also passed this concern to Toyota USA Corporate office and they in fact have acknowledged that they received numerous complaints on the same matter and suspect the issue is in the newer 8 speed transmission system they are now installing. Unfortunately there has been no further action taken by Toyota to remedy this issue, although they are fully aware of it. Hoping you get more complains on this matter and force Toyota to take action. Thank you!