2025 Toyota RAV4 visibility problems

Filed Sep 1, 2026 · Visibility · CA

My windshield spontaneously cracked from the outside frame down 10 inches and then across the glass through site line of driver. There was no outside influence (Rock chip and etc) I am not the first RAV4 owner to experience this.

Filed Aug 29, 2026 · Visibility · SC

On August 29, 2026, at approximately 9:04 PM, my vehicle was turned off and parked in my driveway. I entered the driver’s side of the vehicle and closed the driver’s door normally. Immediately after the door was closed, the rear windshield/back glass completely shattered without warning. There was no known impact to the rear windshield at the time of the incident. The outside temperature was approximately 76°F with 85% humidity, and the incident occurred after dark. I did not notice any warning lights, messages, visible damage, or other symptoms before the glass shattered. The sudden failure created a safety risk because shattered glass could strike or injure vehicle occupants and left the vehicle without an intact rear windshield. The cause of the failure is UNKNOWN at this time.

Filed Aug 5, 2026 · Visibility · OR

Driving at 70mph on the freeway when the rear windshield blew out. Seemingly for no reason. Didn't sound like anything hit the windshield, just the pop of the glass. Seems like a defective windshield.

Filed Jul 22, 2026 · Visibility · 556 miles · TX

The contact owns a 2025 Toyota Rav4. The contact stated that while driving the vehicle at an undisclosed speed and activating the A/C, there was hot air coming from the vents. The dealer was contacted, and the contact was informed that the A/C condenser was damaged by an object, causing a refrigerant leak. The contact stated that the vehicle was sold with the pre-existing failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 556.

Filed Jun 11, 2026 · Visibility · 12,838 miles · MI

The contact owns a 2025 Toyota RAV4. The contact stated that while driving under normal conditions, the contact heard an abnormally loud, violent, and shattering sound. The contact then noticed that the moonroof glass panel had exploded without impact, causing shattered glass to fall inside the cabin. A police report was filed. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 12,838.

Filed Mar 27, 2026 · Visibility · FL

There is a stress fracture to the windshield starting at the bottom of the glass where it attaches to the body of the car, below the wipers. It’s not a chip nor was it caused by an object. It’s a semi circle crack. Two employees at the dealer glass department concurred that it’s not damage from a foreign object hitting and that it’s a stress crack. Yet dealer refuses to cover hands warranty. Car has less than 12,000 when this cracked.

Filed Mar 26, 2026 · Visibility · 30,000 miles · IL

The contact owns a 2025 Toyota Rav4. The contact stated that while driving approximately 60 MPH, the rear driver’s side window suddenly shattered after an abnormally loud bang was heard. The local dealer was contacted; however, the vehicle was not diagnosed or repaired because there were no recalls associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

Filed Jan 6, 2026 · Fuel system, Lights · MD

1)I purchased my car during daylight hours. A few days later I drove my car in the evening and could not see street signs or the road 1/3 of the way up through my windshield. There is a definitive line where the windshield turns black. It is extremely dangerous. The Toyota engagement center told me to take my car to the dealership where it was purchased. I also took photos of what I could not see while driving. The dealership said there is nothing they can do and this is normal. The engagement center called back after they received the photos and told me their head technician could not see the street signs looking at my photos either. I was told to take the car back again to the dealership and once again told " there is nothing that can be done." They told me to put on my automatic brights. This feature does not help. The dealership also told me I could just put on my brights manually. This blinds other drivers on the road and then they put on their brights driving towards me, which decreases my ability to see while driving. the Toyota engagement center dropped the ball after 3 months of trying to report how dangerous this situation is. I am now reaching out to your department because of serious safety issues. I did not buy a car to be placed in a dangerous situation where I can't see to drive at night up. It is very dangerous driving up and down hills. 2)I also want to report - most of the time my gas milage ranges between 18 - 22 mph. This is way below the stats that were given to me when the car was purchased. 3)The phone table does not charge my phone and is a complete fail. 4)The visors are too short and hardly serve a purpose.

Filed Dec 18, 2025 · Visibility · VA

Unknow

Filed Nov 19, 2025 · Visibility · MI

Stress fracture in the windshield