Toyota RAV4 engine failure problems

Filed May 7, 2026 · Engine · 34,678 miles · CO

The contact owns a 2020 Toyota RAV4. The contact stated that while the vehicle was parked, coolant was observed leaking from the engine compartment with no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed that the engine casing had failed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but denied the engine replacement request because the vehicle had previously been serviced by an independent mechanic for engine maintenance. The contact stated that the failure was related to the federal safety agency Campaign Number: 20V064000 (Engine and Engine Cooling). The approximate failure mileage was 34,678.

Filed Feb 23, 2026 · Steering · 200,000 miles · GA

The contact owns a 2014 Toyota Rav4. The contact stated that while driving approximately 20 MPH and turning right at an intersection, the steering wheel seized with several unknown warning lights illuminated. The contact completed the turn, and the steering wheel started functioning normally, and the warning lights were no longer illuminated. The failure reoccurred while making a right turn. The vehicle was taken to an independent mechanic, and the contact was referred to the dealer for assistance. The dealer was contacted and confirmed that the VIN was not under recall related to the failure. The vehicle was not repaired. The contact had stopped driving the vehicle. After researching online, the contact associated the failure with the federal safety agency Campaign Number: 20V373000 (Steering): however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.

Filed Feb 23, 2026 · Steering · 97,000 miles · NY · crash

The contact owns a 2021 Toyota Rav4. The contact stated that while his daughter was driving approximately 23 MPH and attempting to make a turn, the steering wheel seized, and the vehicle sideswiped another parked vehicle. There was no warning light illuminated. The steering wheel remained seized. The air bags had not deployed. No injuries were sustained, and no medical attention was required. A Police Report was filed. The vehicle was towed to the dealer, where it was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 97,000.

Filed Feb 4, 2026 · Engine · WA

I was driving down a road and my engine just stopped working lights came on saying there were several issues including the engine. I researched online and found there were recalls due to this same problem for the same make, model and year as my Vehicle, but there is no recall on my vehicle. The dealer confirmed the engine was seized up or whatever wording they used. No one has inspected it other than Rodland Toyota. There were no warning lights or messages or symptoms before the issue.

Filed Nov 21, 2025 · Engine, Fuel system · NY

My 2019 Toyota RAV4 Hybrid (VIN: [XXX] ) suffered sudden engine failure due to coolant intrusion. On Nov 20, 2025, Johnstons Toyota in Harriman, NY (RO#XXX) diagnosed the issue and recorded DTCs P26CA31 and P26CB, which indicate failure of the coolant flow control/bypass valve. The dealer confirmed heavy white smoke from the exhaust with a strong coolant smell and advised the engine had failed, recommending a replacement. This vehicle is part of the early 2019 Japan-built batch widely known for premature electric water pump and coolant-flow system failures. Internal impeller swelling, seal leakage, and bearing seizure can cause coolant pressure spikes and ultimately head-gasket failure with coolant entering the cylinders. This defect has been reported by thousands of RAV4 Hybrid owners (2019–2021). Toyota has addressed it quietly through internal TSBs such as XXX and XXX but no public recall has been issued. The safety risk is severe: the engine began emitting thick white smoke and ran roughly, risking sudden power loss, overheating, or engine seizure while driving. A stall at highway speed could easily cause a collision. Toyota USA opened Case #XXX but declined assistance despite the defect being well documented. This failure was sudden, with no warning lights prior to the incident. Given the widespread nature of this defect and its clear safety implications, I request that the federal safety agency open a formal investigation into the electric water pump/coolant system failures in 2019–2021 Toyota RAV4 Hybrids and consider requiring a safety recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 12, 2025 · Engine, Transmission · 67,314 miles · TX

The contact owns a 2021 Toyota Rav4. The contact stated that while her daughter was dropping her off, the daughter shifted to park(P), and the vehicle made an abnormal static sound. The contact stated that the failure recurred upon shifting to drive(D). There was no warning light illuminated. Additionally, the contact stated that there was an abnormal sound coming from the engine. An independent auto electrician was contacted and informed the contact that the abnormal sounds could be related to an engine failure; however, the vehicle was not diagnosed or repaired. The vehicle was taken to the dealer, where the contact was informed that no failure was found. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 67,314.

Filed Oct 24, 2025 · Engine · WA

Engine timeing system rattle on startup. Even basic web research shows this is a common problem for select model years and acorss mulitple models. This issue has a high probility of causing catastrophic engine damage, where the timeing chain & VVT system fails to keep timing causing the valves to colide with the pistons. There is a TOTAL ENGINE FAILURE risk with each and every engine start. The fix on the 3.5L requires the engine to be removed, VVT and timing chain tensioner to be replaced. This is a $4000 to $5000 dollar repair. This is a clear manufacuting wide spread defect and should be repaired by toyota via recall!

Filed Oct 14, 2025 · Engine · TX

Over the course of the past two days, 2013 Toyota RAV4 has engine cut-off while moving on surface streets, tollroads, and Interstate Highways. Thus far, this has occurred 9 times without any warning whatsoever. Car is in otherwise fine mechanical condition, with all four new tires, new brake rotors & ceramic brake pads, new battery & cables inspection, professional throttle body cleaning, 5,000 mile full-synthetic oil change & oil filter, new engine air filter, and all features and functions in what was known as 100% condition with no Engine Fault indicator on or subsequent OBD II codes. Yet it stalls at all speeds, including street traffic speeds and cruise at 70mpg. No indication whatsoever.

Filed Oct 1, 2025 · Brakes, Steering · 45,500 miles · MN

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at 40 MPH, the steering wheel seized, and the contact had to use force to maneuver the steering wheel. A yellow light was illuminated, followed by a red light. The message "Power Steering Malfunction" was displayed. The vehicle was taken to the dealer, where it was diagnosed, and determined that the power steering unit sensor had failed. The vehicle was not repaired due to the cost. The contact retrieved DTCs: C05D604 (Electronic Power Steering (EPS) System Internal Failure); C151287 (Malfunction in the Electric Power Steering (EPS) System Torque Sensor); and C15D11C (Electric Parking Brake Failure). The vehicle was not repaired due to the cost. The contact stated that the failure persisted. The contact related the failure to the federal safety agency Campaign Number: 20V373000 (STEERING); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 45,500.

Filed Sep 28, 2025 · Electrical, Engine · FL

Had to have my 2024 Toyota RAV 4 towed for a second time in 2 month after driving in heavy rain. During the first instance, I drove less than 10 miles on the highway in very heavy rain. Arrived at my destination, put the car in park and the engine and RPM meter started pulsating, revving feeling as if the car were going to stall. Turned the engine off, had the vehicle towed to the dealership who found "no issues" with the car. Again on September 23, 2025, I drove through a heavy rain storm, arrived a my destination and again the engine/RPM were pulsating/revving. An hour later when I went to leave (in no rain), started the vehicle and the engine began to sputter, all warning lights on the dash board went on including in part "Parking Support Brake Malfunction Visit Your Dealer", "Pre-Collision System Malfunction Visit Your Dealer" and "Engine Stopped Steering Power Low", and the engine sputtered and shut off. Had the vehicle towed to another dealership where it has been for 5 days with the technician telling me he cannot replicate the issue. This is a serious problem for a new vehicle with 17k miles. Not only is this is a safety risk due to vehicle failure/shut down, it is a serious defect in a product that I paid $40,000 for. Please do all that can be done to force Toyota to fix this issue, as it appears based on review of similar complaints on this website that this is happening quite a lot. Separately, it is more than concerning that total engine failure does not generate codes sufficient for Toyota technicians to diagnose such a fatal problem.