2000 Toyota Sienna engine problems

Filed May 13, 2019 · Engine · 198,000 miles · TN

The engine leaks oil at valve covers. They have been replaced. Still leaks. And a lot of sludge builds up= on pump screen. Blew engine!! Had engine replaced. Same thing happening. I am on social security. &3 and can not afford thousands on this vehicle.. Please help@+!!

Filed Aug 17, 2014 · Engine · 340,000 miles · NC · fire

I drove my van from work to my house which is around 18 miles. When I got home I could see smoke coming from under the hood. I quickly got out and pulled my baby out of her car seat. Within a few mins the smoke increased by a lot and I called 911. By the time they arrived the van was completely engulfed in flames, it was completely gutted by the time they put out the fire.

Filed Jun 22, 2011 · Engine · 219,000 miles · CA

Tl* the contact owns a 2000 toyota sienna. The contact stated while driving 55 MPH with the brakes applied the vehicle would not stop. The contact drove onto the emergency lane and the vehicle towed to the dealer. The dealer diagnosed the failure and discovered that the engine mounts were broken. The contact took the vehicle to a different dealer for a second diagnostic test who did not state what caused the failure to occur. The contact stated the vehicle was unsafe to drive and could have caused a crash. The failure mileage was 219,000.

Filed Oct 12, 2010 · Electrical, Engine · CA

I own a 2000 toyota sienna which I have had for one year. To date, I have paid to repair the rear seat, as once it was taken out, the mechanism broke and it could not be put back in the car. Also, we have replaced the drivers side seat belt (the whole thing) because the seat belt light would constantly blink. Now the passenger side seat belt light blinks when the seat belt is latched and when nobody is sitting there. The power sliding door has been looked at and repaired three different times. It continues to open, but will never close all the way. Both the drivers side and passengers side power windows will not roll down (or if they do, they will not go back up). There is a banging sound coming from the middle floor board by the gas pedal. The transmission has been replaced. Finally, the rear door latch broke completely and there is no way to open the rear door - from the inside or out. All of this is with normal wear.

Filed Apr 27, 2010 · Engine · 90,000 miles · FL

The contact owns a 2000 toyota sienna. The contact stated that the vehicle was taken to the dealer for diagnostic and testing. The dealer advised that the vehicle converter for the exhaust system needed to be replaced at the owners expense. The dealer advised that the converter for the exhaust system can only be replaced in california. The vehicle was not repaired and the contact does not feel like traveling from florida to california. The contact stated that he has lower fuel mileage as a result of the exhaust system defect. The approximate failure mileage was 90,000. The approximate current mileage was 112,000. Rg

Filed Feb 22, 2010 · Engine · 75,000 miles · AL

Noticed check engine light on and smoke on cold start up. Called local toyota dealer and was told this would be a major "fix" and would cost at least $3,000.00 to repair. After doing a google search I realized my sienna most likely had oil gel and called tmsusa in california to report it. Was told to take van to a local dealer and have diagnosed. Took it in the very next day and oil gel was confirmed (in writing). Was then told that the van was 90 days past coverage and it would cost $6,200.00 for a new engine. I tried to show documents of my oil changes and service manager said it would do no good. I refuse to drive this van for fear that the engine will seize! I am requesting that a second investigation be made into these vehicles. The class action lawsuit did no good for the toyota consumers! Also, for the record, I took the van in when the engine light first came on (engine was not smoking yet) and the dealer told me it was probably just the gas cap and that the engine light comes on in these vehicles all the time. They never documented my visits to the service department. I would have been within the 8 year time frame if they would have checked the engine at that time!

Filed Jul 27, 2009 · Electrical, Engine · CA

2000 toyota sienna has an on/off engine light problem. *nj consumer is adding information. *nj 7/24/09 the consumer was told the ignition coil needed to be replaced, but after it was replaced, the engine light came back on. The spark plugs and wires were changed but to no avail. The consumer stated the vehicle runs poorly and it also stalls. The consumer discovered a website where other years of the toyota sienna were recalled for the same problem. Recall 98e035000.

Filed Jan 9, 2009 · Engine · 115,000 miles · AL

Check engine light has come on for months and was told that it was an o2 sensor and not a severe problem, just won't get as good gas mileage. Vehicle now smokes upon start up and is losing too much oil too quickly. Toyota said to take vehicle to a toyota dealer and have them diagnose the problem. Came back that the engine had "gel" and would cost $2700.00 to clean and repair. Toyota district service manager denied the claim. Said warranty only good for 8 years from date vehicle was purchased. Now waiting to hear from case manager to see if she will o.k. The repairs to be paid for by toyota. We bought the sienna used in 2004 after the tsb was already established but were not made aware of this "gelling" problem. Just had oil changed in november 2008 and now the oil level is barely registering on the stick. Only 6 weeks after the last oil change!!! Car is still at the toyota dealership.

Filed Aug 13, 2008 · Engine · 95,000 miles · NJ

Car has oil sludge problem - toyota settled class action law suit - but I was never notified - and it appears a recall was never initiated?

Filed Feb 5, 2008 · Body, Engine · NC

Engine light went on , checked water and oil, both levels were fine, engine just quit, van was towed to repair shop, I the owner was told that due to sludge in the engine the oil could not pass through so engine seized up, it was a 2000 sienna van, the oil was changed every 3000-4000 miles faithfully, the engine only had 107,000. Original miles on it, a new engine would be 6,200.00 plus labor and a used engine would be 4,200.00 plus labor, so now my van had to be junked.