2009 Toyota Tacoma body problems

Filed Oct 27, 2026 · Body · 140,000 miles · OH

The contact's cousin owns a 2009 Toyota Tacoma. Upon inspection underneath the vehicle, the contact discovered severe frame corrosion on the passenger’s side that could eventually cause the subframe to fracture. The contact stated that an unknown dealer had inspected the subframe in 2018 under recall, and the vehicle passed the inspection. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure by phone. The failure mileage was approximately 140,000.

Filed Jun 29, 2026 · Body · 217,000 miles · IN

The contact owns a 2009 Toyota Tacoma. The contact stated that the frame on the driver’s and passenger’s side was severely rusted. The dealer was contacted about the failure and about the warranty enhancement program ZH6, which was associated with the failure. The manufacturer had extended the warranty coverage for frame corrosion on certain 2005–2010 model year Toyota Tacoma vehicles. The dealer informed the contact that the program had expired. The manufacturer was made aware of the failure. The manufacturer informed the contact that the warranty program had expired. The failure mileage was approximately 217,000.

Filed May 22, 2026 · Body · IL

Real bumper assembly rotted off the frame was dragging behind the truck I'm at 60mph luckily nobody was behind me pulled over and removed it all both frame rails was rusted in half Hanging On by a little piece every place I called will not fix it want me to buy a whole frame truck has 220 miles on it with no rear bumper

Filed Oct 22, 2025 · Body · 85,000 miles · NY

The contact owns a 2009 Toyota Tacoma. The contact stated that after maintenance service on the vehicle, it was discovered that the front subframe of the vehicle was severely corroded. The vehicle was taken to an independent mechanic, where it was inspected, and determined that the entire subframe had failed and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, where the same diagnostic result was provide,d and the contact was informed that the entire subframe needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 85,000.

Filed Oct 22, 2025 · Body · 110,000 miles · SC

The contact owns a 2009 Toyota Tacoma. The contact stated that upon further inspection, the contact became aware that the chassis was rusted. The local dealer was contacted; however, the contact was informed that an unknown Toyota recall for warranty coverage had expired. The manufacturer was made aware of the failure. The failure mileage was approximately 110,000.

Filed Oct 15, 2025 · Body · NJ

The frame has rusted and holes are unsafe. I am worried about driving my vehicle. The safety of me and other drivers on the road I am traveling are at risk. I went to liberty toyota in burlington, nj and they refused to repair. The rust is unusual and there have been other years affected and frames replaced. My wife purchased this truck from liberty toyota

Filed Aug 21, 2025 · Body · SC

Vehicle: 2009 Toyota Tacoma VIN: [XXX] Mileage: 128,400 Owner: Jacob Grove, Anderson, SC Summary of Issue: The frame of this 2009 Toyota Tacoma has developed severe rust perforation that makes the vehicle unsafe to drive. My independent mechanic has refused to work on it due to safety concerns, and Toyota of Greenville (SC) has confirmed that the frame is extensively corroded and requires replacement. Background: Toyota previously issued a Customer Support Program (CSP) for frame corrosion affecting 2005–2009 Tacomas in northern states, including Ohio, where this truck was purchased and operated. In June 2018, the vehicle was inspected at Don Wood Toyota in Athens, OH (91,600 miles). The dealership recorded “no perforation” and did not apply the protective coating or replace the frame. The truck has been minimally driven since (an average of 6,000 miles per year). In May 2024, at 128,400 miles, a mechanic and dealership confirmed the frame has multiple areas of severe perforation, including around brake lines and exhaust mounts. Concern: It is unreasonable that a vehicle frame could go from “no perforation” to “severe perforation” in only 36,000 miles and six years of light use. This indicates either: The 2018 inspection under Toyota’s CSP was inadequate, or The frame was already compromised but not properly addressed at the time. Safety Risk: The vehicle cannot be safely lifted, worked on, or driven in its current condition. The rapid deterioration presents a risk of frame failure while driving, endangering occupants and others on the road. Request: I am submitting this complaint so that the federal safety agency is aware of ongoing frame corrosion failures in 2005–2009 Toyota Tacomas, even in cases where Toyota previously inspected and declined to repair during the CSP period. This case demonstrates that the problem may not have been properly identified or corrected during program inspections, leaving unsafe vehicles on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 7, 2025 · Body · 113,000 miles · WV

The contact owns a 2009 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from underneath the vehicle. Upon inspection, the contact discovered a branch lodged beneath the vehicle and the corroded subframe with a hole in the front passenger’s side subframe. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 113,000.

Filed Oct 24, 2024 · Body · NY

I just learned from my Mechanic that the Frame Corrosion is bad. The frame was inspected by Vanderstyne (now West Herr) Toyota on 06/20/2020. It passed the Inspection at that time, so they did not do anything. But within 4.5 years and only a little more than 6,000 miles driving since then - this corrosion shows up. I think the Toyota Specs for the Corrosion Inspection were not sufficient. Toyota should be held accountable for their negligence. I only have 72,900 miles on this Tacoma. I would have liked to keep it for another 5 years or so, but now I cannot and Toyota washed their hand when I contacted them.

Filed Oct 7, 2024 · Body · NJ

See Attached Letter