2008 Toyota Tundra suspension problems

Filed Oct 1, 2023 · Fuel system, Suspension · CT

I was washing my truck October,1,2023 and while spraying the underside with water I noticed the fuel tank hanging extremely low from the back while further inspection I observed the rear fuel tank strap had rusted off and the tank was hanging by the front strap which is very corroded along with all inner structure and frame rails which is rusted corroded and completely rotted out. This truck has been very well maintained and has only 104354 miles on it.

Filed Aug 15, 2023 · Body, Suspension · 171,000 miles · MA

The contact's husband owns a 2008 Toyota Tundra. The contact stated that while driving at an undisclosed speed, a fellow motorist alerted her husband that an unknown part had been hanging from underneath the vehicle. Upon inspection, the contact's husband discovered that the fuel tank had detached from the vehicle due to severe corrosion. The contact stated that several years prior, the vehicle had been subjected to an unknown recall related to corrosion. The contact stated that a special coating was sprayed on the vehicle to prevent corrosion; however, the recall remedy failed to prevent the corrosion. The dealer was notified of the failure but offered no assistance. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 171,000.

Filed Jul 29, 2022 · Engine, Fuel system · CO

The air injection pumps went out. Vehicle could not get out of limp mode, was very dangerous as I couldnt get up to speed while merging onto traffic. Had to put hazards on and drive vehicle home under 25mph. Vehicles were going around me. Vehicle is scheduled to be looked at by a dealer, but still recommend this be a safety issue!!

Filed Sep 16, 2021 · Body, Suspension · FL

Excessive rust build up all along the underside of the vehicle, frame, and all over the suspension components

Filed May 26, 2019 · Body, Fuel system · 73,400 miles · VA

Frame mount for gas tank has rusted and fuel tank is dropping down. Last year an undercoating was applied by a toyota dealer and is peeling off in certain areas. I believe pursuant to the class action lawsuit referred to as brian warner et al toyota motor corporation my vehicle may be covered under warranty because the gas tank strap mounting is part of the frame. As of now, my mechanic advised me not to drive it as it is a safety hazard. I noticed the tank strap was hanging down from the frame and the gas tank was also hanging down while the vehicle was parked in my driveway.

Filed Jan 29, 2017 · Suspension, Transmission · 58,000 miles · MI

I'm writing regarding my 2008 toyota tundra and a recent rear axle wheel bearings failure. The truck itself is in meticulous condition and only has 58,000 miles on it. The reason for the note is that I've seen articles indicating there has been issues as well as located a related toyota service bulletins. I was also told by the service technician that the bearings that were installed were upgraded bearings. Typically I wouldn't think twice, but knowing this is a safety issue as well as the other information we have found, I'm curious if the federal safety agency has done any investigation or has any additional information it can share? Toyota and my dealer ended up covering half the repair, but there was still quite a bit we had to cover. Beyond the bearing, we recently learned there may be issues with the frame. Anything you can share on that would also be appreciated. Thank you in advance. We have a 5 year old that travels in the vehicles and therefore safety is our utmost importance.

Filed Jun 13, 2015 · Suspension · 89,000 miles · MA

Leaf springs giving out, never put half of the max weight capacity, called toyota they told me nothing they can do and they stand behind their product even though I personally know someone that had theirs repaired at no charge toyota would not fix it for free if they did not know the product was bad and faulty. Noise coming from front end of vehicle while driving between 10 to 30 MPH. I was told needed entire new front end, and other components for the repair. I did not know toyota did not care about the public so much to let unsafe vehicles to be out on the road. Cannot drive vehicle until these repairs are done for worry of safety for me and my family.

Filed Aug 27, 2012 · Suspension · 42,396 miles · NY

Tl* the contact owns a 2008 toyota tundra. The contact stated that while traveling 25 to 30 MPH a growling sound emitted from the rear of the vehicle. The vehicle was taken to the dealer who stated that the failure might be caused by a defective rear axle or differential. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 42,396 and the current mileage was 74,000.

Filed Apr 4, 2012 · Steering, Suspension · 48,035 miles · WI

Right front tie rod stripped out and became separated from right front wheel.

Filed Dec 10, 2011 · Suspension · 46,500 miles · FL

On december 3, 2011 I was driving with my family on a paved local road and the front driver's side of the truck just dropped several inches after a loud snap sound. Initially I thought the front wheel had come of the truck somehow because it was a fairly violent drop. I pulled over and inspected the wheel, everything looked to be in tact. Next I got on the ground and noticed right away that the front strut had snapped in half. I considered this to be a major safety problem, so I contacted my local toyota dealership and let them know what happened. The response I got was... "how many miles are on your tundra"? I replied 46,500. The next response was very disappointing - with no other inquiry into the situation, the technician said, "well, you are outside of the 3yr / 36,000 mile warranty on the struts so you can have the truck towed to our shop and we can replace it for you". I'm thinking wow!!! That's the response after I just tell a toyota service technician that a factory part just randomly failed and could have been a serious safety issue. Next I contacted the national hotline for toyota customer care. They said the problem would be documented and thanked me for calling in with my concern. This is my 3rd tundra and I've never had an issue like this before. All in all, I am very disappointed that a major component like a strut failed under normal driving conditions. Even more disappointing is the reaction I received from both my local dealer and the national customer hotline. I can't imagine what a nightmare this could have been if I was on the interstate when the strut failed? I recommend every gen 2 tundra owner take a look and make sure you don't see any kind of stress cracks, or anything that looks odd with your front struts. For the record - I don't offroad or drive my truck hard....and all maintenance is up to date and documented!