the federal safety agency Recall 24V‑110 (VW 20UF). The vehicle is in Limp Mode and experiencing low oil pressure symptoms. It is also subject to Recall 24V‑110, which identifies a fire risk due to fuel leakage. Despite the safety hazard, the local Volkswagen dealership has refused to perform the recall repair or diagnose the vehicle, stating it is at their 'discretion.' I am reporting a failure by the manufacturer and the dealer to remedy an active safety defect, leaving me with an unsafe, undriveable vehicle."
2016 Volkswagen GTI fuel system problems
18 complaints (27% of all complaints for this car). Typical mileage when it fails: 40,000.
- owner complaints
- 18
- of this car's complaints
- 27%
- typical mileage
- 40,000
- crashes
- 0
- recalls
- 2
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Volkswagen GTI fuel system problems in other years
Specific symptoms reported on the 2016 Volkswagen GTI fuel system
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Fuel system, gasoline
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
- Risk
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1‑800‑893‑5298 or Audi customer service at 1‑800‑253‑2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V‑647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V‑647.
Recall number 24V110000 · Recall details
Fuel system, gasoline
- What is wrong
- Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
- Risk
- As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1‑800‑893‑5298, Audi owners may contact Audi customer service at 1‑800‑253‑2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V‑110.
Recall number 16V647000 · Recall details
Related investigations
Fuel Leak due to Suction Jet Pump Failure within Fuel Tank (Remedy Effectiveness of Recall 16V647)
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V‑647. Recall 16V‑647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V‑647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V‑647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V‑110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V‑110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V‑647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
RQ23007
What 2016 Volkswagen GTI owners say
Most recent owner complaints, unedited.
I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refueling (fuel pump nozzle repeatedly shut off even with a low fuel level). These symptoms were similar to prior EVAP system failures that required replacement of the charcoal canister and EVAP purge (N80) valve earlier in 2025. I brought the vehicle to the dealership on December 29, 2025, specifically requesting completion of Recall 20UF and inspection/replacement of EVAP components if necessary. The dealership initially refused to perform the recall unless I returned the vehicle with less than one-quarter tank of fuel, despite the recall documentation specifying that fuel extraction equipment (VAS5190A or equivalent) is required for this repair. A diagnostic report generated by the dealership listed a “Fuel Pump (in tank)” replacement as a customer-pay repair before later removing it once it was identified as recall-related. After significant delays, the dealership stated the recall had been completed and declined to replace any EVAP components. Since the recall service, the vehicle continues to experience intermittent shuddering and difficulty accelerating. While refueling has temporarily improved, drivability concerns persist, raising questions about whether the recall repair was properly performed and whether the vehicle remains safe to operate. I am concerned about inconsistent handling of a safety recall, improper diagnostic practices, and continued fuel-system-related drivability issues that may pose a safety risk.
Fuel is leaking from near the gas tank when the car is running and creates a puddle- I took my car to the local VW dealership in February to get the Suction Jet Pump Recall completed.
The contact owns a 2016 Volkswagen GTI. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The contact stated while the vehicle was parked, the contact became aware of fuel leaking from the rear of the vehicle. The vehicle was towed to the dealer where the vehicle was diagnosed with a fuel leak coming from the fuel tank suction pump. The contact was informed that the fuel tank suction pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000. VIN tool confirms part not available.
The contact owns a 2016 Volkswagen Golf GTI. The contact stated that while driving at an undisclosed speed, there was an abnormally strong gasoline odor coming from the exhaust. The contact stated that while attempting to fill the tank, the tank failed to accept more than a half tank of fuel. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The dealer was contacted and diagnosed the vehicle with a failure of the fuel pump which was replaced; however, the failure persisted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but was unable to confirm when the part would be available. The failure mileage was approximately 160,000. VIN tool confirms parts not available.
The contact owns a 2016 Volkswagen GTI. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline). The contact stated that while refueling, the gasoline was leaking from the vehicle from an unknown location. The vehicle was taken to an independent mechanic where it was diagnosed that the carbon canister was clogged with fuel and needed to be replaced. The vehicle was repaired started the vehicle was losing motive power. On another occasion, nine months later, the failure reoccurred. The vehicle was taken to a dealer where it was diagnosed and determined that the purge valve, fuel tank, N80, carbon canister, and other unknown parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 24,000. VIN tool confirms parts not available.
The contact owns a 2016 Volkswagen Golf GTI. The contact stated that soon after purchasing the vehicle, she had difficulty placing gas into the fuel tank as fuel would spill out during fill up. Upon investigation, the contact linked the failure to the federal safety agency Campaign Number: 16V647000 (Fuel System, Gasoline, Engine and Engine Cooling). The vehicle was taken to a dealer who informed her that there were no recalls on the vehicle. The contact was then referred to the manufacturer who also confirmed that the vehicle was not under recall. The contact was referred to the federal safety agency for assistance. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was unknown.
The car on is leaking gasoline from back of the gas tank, the car vas in motion and I smell gasoline from my car and may cause a fire because is near the wheel.
The suction pump (part 5q0-201-029) in the evap emission control of my vehicle failed on february 7 2021 causing fuel to be brought into the charcoal canister and then into the purge valve. This LED to heavy fuel smell in my vehicle and required replacement of suction pump, charcoal canister and purge valve. Note that this failure with exact same description was identified as part of the safety recall 20y6 issued by nhsta on october 13 2016 and my vehicle was part of this recall. It was claimed that the issue was fixed on my vehicle on june 28 2017 as part of this recall by vw dealership. However, the suction pump which failed on february 7 2021 had the manufacturing date stamp of 15.08.15 which indicates that perhaps vw didn't replace the suction pump as part of the recall repair or replaced it with another faulty suction pump which still had the issue (since the manufacturing date of the failed suction pump is almost 2 years before the date of recall repair). Vw of america hasn't provided me clear answers to my questions stated below (see attached letter dated february 13 2021, that I sent to vw of america raising these concerns): I) would this suction pump that failed and which was manufactured on 15.08.15 will have the fix for the issue identified in 20y6? Ii) what was the manufacturing date of the suction pump originally installed on my vehicle before the recall repair was performed? Vw of america replied to me on february 15 2021 stating that they won't help me with this repair as the part was out of warranty. However, they didn't provide me answers to the specific questions I raised. If the recall repair was not done properly, isn't vw still responsibile to fix the issue that my vehicle suffered and I would also like them to provide me clear answers to the above two questions.
It sucks in too much air and fails as if it had a sparkplug fault it wastes too much gas and sometimes suffocates and wants to turn off
Questions about the 2016 Volkswagen GTI fuel system
Does the 2016 Volkswagen GTI have fuel system problems?
Owners have filed 18 complaints about the fuel system of the 2016 Volkswagen GTI, 27% of all its complaints.
At what mileage do 2016 Volkswagen GTI fuel system problems start?
The typical (median) mileage in owner complaints is 40,000 miles.
Was there a recall on the 2016 Volkswagen GTI fuel system?
Yes, 2 recalls: 24V110000, 16V647000. Check your VIN to see if your car still needs the free repair.
What year does the Volkswagen GTI have the most fuel system problems?
The Volkswagen GTI model years with the most fuel system complaints are 2019 (23 complaints), 2015 (20 complaints) and 2017 (20 complaints).
Other 2016 Volkswagen GTI problems
Engine 19Transmission 8Visibility 7Body 6Airbags 5Electrical 3Brakes 2Steering 2Driver assistance 1Lights 1Seat belts 1Suspension 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Volkswagen GTI?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history