2011 Volkswagen Jetta technical service bulletins
1,338 technical service bulletins and manufacturer communications cover the 2011 Volkswagen Jetta.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Prevent Sporatic Misfire Faults.
- Engine missfire diagnostic aid
- Identifying and Mixing Volkswagen Engine Coolants
- Adhesive to bond sensor to Radiator.
- Safety Related Inquiry and Reporting
- Suggested fuel additive
- This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
- Permission to change Daily Order upgraded to RED Order
- Differences between a leak and seepage
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Oil Consumption Measurement and Electronic Oil Consumption Measurement
- Lubricating engine components before reassembly.
- Instruction, how to lubicate engine before initial start.
- Inquiries
- Volkswagen Engine Oil Standards
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Damage Inspection of Park assist sensors
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- Paint color and/or finish of the engine compartment may not match the exterior paint color
- The federal safety agency has issued an urgent warning regarding counterfeit replacement airbag inflators...
- This is a notice for software changes with the ODIS diagnostic program to correct the communication during...
- What is and what is not a leaking suspension strut.
- Replace Door Lock and Cap.
- Engine misfire diagnostic aid.
- G12Evo can now be mixed with previous coolants.
- Cautions about using aftermarket transmission flush machines and aftermarket transmission fluids.
- How to measure engine oil consumption.
- Fuel Additive to prevent sporatic misfire
- A list of suggested fuel stations
- GFF Requirements regardless of concern plus System flush requirement
- Fuel Additive
- How to identify and when to replace a leaking strut
- Volkswagen Engine Oil Quality Standards (U.S. Only)
- How to check for HVAC system leaks using nitrogen.
- Volkswagen Engine Oil Quality Standards
- Identifying and Mixing Engine Coolant
- Diesel Models only
- Engine Oil Standards
- Lack of paint under roof
- Additional reporting
- Vehicle Concerns Before Recall Repair Available
- How to perform the engine oil consumption measurement
- Engine Misfire Diagnostic Aid
- How to manage software versions using VW diagnostic Tool
- Checking Engine Oil and correctly reading dip stick
- A list of engine oil that meet Volkswagen Engine Oil Standards
- Fluid requirements
- Wind & Water Leak Checking
- Fuel additive to help with misfire faults
- Recommended Gasoline Quality
- Battery testing
- Multiple Update closures: 20AH Atlas Quality Package 1, 24AE 1.8T ECM/TCM SW, 24BG Jetta Hybrid ECM SW,...
- Engine Replacement Tip
- Engine Assembly Tip
- Engine oil quality standards
- VW Engine oil quality standards
- Frozen Charge Air Cooler, Engine no start updated to include Parts ordering notification.
- Airbag / Pyrotechnic Safety Belt Deployment Inquiries, update to contact information due to retirement.
- Reporting procedure for A/C compressor replacement regardless of the reason for failure
- Battery Testing and Charging Using Midtronics VAS6161 and or GRX3000VAS Charger
- Update to Volkswagen engine oil standards
- Helpline & Parts Dept
- Diagnostic assistance for excessive static current draw
- Volkswagen Engine oil quality standards, update to attachments.
- This communication is a notice for software changes with the ODIS program for specific cars.
- Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
- Software Version Management (SVM) instruction.
- Automatic Transmission Fluid Requirements
- Engine Oil Consumption Measurement Instruction and Work sheet.
- Volkswagen Engine Oil Standards, updated to include model year 2024.
- Diagnostic Aid for engine misfire.
- Gasoline fuel additive
- Gasoline quality information in regards to gasoline engine performance.
- This communication is a notice for software changes with the ODIS program for specific cars
- Introduce new engine coolant compatible with all models and all model years.
- This Document was revised
- Engine oil quality standards, update to attachments.
- This document outlines updates to the ODIS diagnostic software
- Strut or Shock leak assessment.
- Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
- This Document informs dealers on VWP-23-01
- VW contact when reporting a Airbag or Pyrotechnic safety belt deployment
- Radio knob replacement instead of radio replacement w/ knob part number.
- Update model year applicability to include 2023.
- Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger
- ACC Calibration Process
- A/C requirements, update to model year applicability.
- Engine Oil Quality Standards updated to include the latest Engine Oil ) excluding Routan & ID.4attachments
- Evaluate TDI vehicle for repurchase prior to repairs
- Update to required vehicle wash shampoo.
- Engine Oil Quality Standards updated to include the latest Engine Oil attachments
- Minimum battery charger requirements during software updates
- Engine oil consumption measurement.
- Engine Oil Quality Standards updated to include model year 2023 and the latest Engine Oil attachments
- Gasoline quality check
- Software Version Management (SVM) instruction
- Gasoline quality.
- VW engine oil specifications
- Recommended fuel additive to avoid engine misfires.
- Auto Trans fluid requirements.
- High soot loads prior to regeneration can
- Refrigerant leak diagnosis using Nitrogen
- Battery Testing and Charging using VAS6161 and or GRX3000VAS
- Refrigerant leak diagnosis using Nitrogen
- VW engine oil specifications
- Engine oil pressure priming.
- Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and...
- High soot loads prior to regeneration can
- Battery Testing and Charging using recommended VW test equipment.
- Battery Tester VAS 6161 introduction.
- High soot loads prior to regeneration can
- Update engine oil quality standard lists (attachments)
- Customer states rattle noise from the underbody heat shields
- Exterior Lights, Moisture Accumulation
- Customer states rattle noise from the underbody heat shields
- Customer states rattle noise from the underbody heat shields
- Engine oil consumption measurement
- Customer states rattle noise from the underbody heat shields Oil level sensor leaking
- Discharged Battery, Diagnosis for excessive current draw.
- Update model and model year applicability, introduce new coolant G12Evo.
- Customer states rattle noise from the underbody heat shields Oil level sensor leaking
- Engine Performance, DTC's stored
- Customer states rattle noise from the underbody heat shields Oil level sensor leaking
- Customer states rattle noise from the underbody heat shields
- Customer states MIL-on with P0087 P053F in the ECM
- Customer states MIL-on with P0087 P053F in the ECM
- This bulletin contains general instructions for software updates.
- Battery testing using VW special tools, updated to include additional model year applicability and include...
- Explanation of error message received from scan tool when erasing diagnostic trouble codes (DTCs) in...
- Update to model year applicability.
- Diagnosis for EGR flow insufficient
- Additional safety related Inquiry and Reporting instruction.
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- KESSY equipped Key Adaptation, updated to add model year applicability.
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- Republication of archived technical tip for water leak testing fixture.
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- Customer states MIL-on with P0087 P0149 P053F in the ECM
- Customer states MIL-on with P013E in the ECM
- Customer states MIL-on with P013E in the ECM
- A/C Compressor replacement requirements, updated to include additional model year applicability.
- Customer states MIL-on with P013E in the ECM
- Customer states MIL-on with P013E in the ECM
- DTC P0401 diagnostic assistance, additional smoke test and cold air control valve test
- Fuel Additive to Help Prevent Sporadic Misfire Faults
- Engine Misfire Diagnostic Aid. Updated to include additional model and model year applicability.
- VW approved gasoline fuel additive, update to include additional models and model year applicability.
- Software Version Management (SVM)
- Navigation for addressing incorrect Part direction.
- Removing musty odor from A/C system
- Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both...
- This special notice is to inform dealers to return the parts listed and only order the successor parts...
- 2009-2015
- Warranty Extension for Fuel Injectors Certain 2011 Model Year Volkswagen
- Warranty Extension for Intake Manifold & Fuel Injectors Certain 2008-2011
- Parts ordering information
- Key battery diagnosis, updated to include additional model year applicability.
- Transmission Fluid requirements updated to include additional model year applicability.
- Exterior lighting moisture in lens updated to exclude LED lighting.
- Update to top tier brochure purchasing url.
- Update to brochure purchase url
- Update regeneration test plan instruction.
- Software Version Management (SVM) instruction updated to include model year 2021
- Updated to include update recommended engine oil attachments.
- Data link diagnostics and tips
- A/C requirements, update to title.
- Updated to include an additional model year applicability.
- Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do...
- Battery testing
- This special notice is to inform dealers to return the part numbers listed (State of California only).
- Updated key ordering protocol
- This special notice is to inform dealers to return the part numbers listed and order the superseded part...
- Update to include additional components in parts table.
- Using Nitrogen to assist in finding A/C refrigerant leaks.
- Oil consumption test updated to include additional models and model year applicability.
- Update to model and model year applicability and remove WISE claiming information.
- Mandatory fastener.
- Update to part quantity in Part Table.
- Updated to include additional models and model year applicability.
- Antilock brake function test direction.
- Statement referring to TB 2043893 removed
- Recall Reminder Part Labels
- Oil pressure priming after engine replacement or internal repair.
- Electronic Stabilization Program (ESP) function test may not end on its own causing DTC.
- Customer states MIL-on with P0496
- Customer states MIL-on with P0496
- Update labor operation numbers per Saga updates.
- Directions to assist in performing basic settings for the ac control module
- Customer states MIL-on with P0496
- Update brochure part number and recording URL. Update model and model year applicability.
- Update Top Tier brochure part number.
- Metadata update (add MY 2014 Eos (missing).
- Update to include 2020-2021 model and model year applicability.
- Tool number added to table
- New a/c machine version added to table
- New machine version added to table.
- Cam screen damage.
- Voltage Drop Testing
- Voltage Drop Testing.
- Tire Chain Information (for California dealers only) All Model Years
- Update to Volkswagen engine oil specification attachments.
- Additional Guided Functions programming assistance
- Update to existing tip for fuel quality checking.
- Volkswagen After Sales Weekly Communication
- ERP fault information.
- Micro switch customer call list.
- Update to Volkswagen Identifying and mixing of coolant
- Update to regeneration instruction.
- Update model applicability to MY 2020.
- This Document informs dealers on the the new Water Pump Limited Warranty Extension
- This Document informs dealers on the the Frequently Asked Questions for the new Water Pump Limited...
- Update to Volkswagen engine oil standards.
- Due to a parts catalog error, incorrect emissions related component(s) may have been installed on some...
- Added: Torque Spec table
- Catalytic Converter Regeneration Scan Tool instruction.
- Include new special tool adapter and 2018 model year Jetta only
- Update to mode; and model year applicability.
- Nox regeneration information
- The part number listed in the document is to be returned if it meets the criteria provided.
- The part number listed in the document is to be returned.
- Update to labor operation claiming number per Saga updates.
- Include additional photo's of water ingress
- TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB
- Quick Reference Update Guide.
- This document informs dealers of a revision to the Extended Emissions Warranty Limited Warranty Extension...
- Update to Volkswagen engine oil standards
- This document outlines updates to the software used to perform vehicle diagnostics
- REMOVED all 12 hour wait period before starting references
- Update vehicle metadata to include pull ahead models
- Vehicle Fuse location assistance.
- Engine oil quality standards
- This Document informs dealers on the Revised VWP-15-06 to exclude the fuel sample requirements.
- This document outlines updates to the diagnostic software (ODIS).
- Updated to include an additional warranty claiming statement.
- Remote Key Battery Replacement.
- Remote Key Battery Replacement
- Additional Safety Inquiry and Reporting instruction.
- Update to TB to include model year 2018 & 2019 applicability.
- Update vehicle metadata.
- This Document was revised on page 2. The verbiage was changed from the cusomter's perspective to the...
- Engine oils which meet Volkswagen oil quality standards.
- High Pressure Fuel Pump Diagnosis.
- Email Important TDI Announcement Duplicate Photos in IN-FORM
- Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
- This document outlines fixes within the ODIS vehicle diagnostic software for various test plans.
- Updated to include additional labor operations due to labor time updates in Elsa.
- Campaign Reminder Communication
- Adhesive circular
- Update to labor operation numbers per Saga updates
- UDS Basic settings directions
- Valve spring diagnosis.
- Adaptive front lighting descriptive
- Alternative method for radio code retrieval.
- The fault code in
- Engine Oils Which Meet Volkswagen Oil Quality Standards
- Gasoline Engine Misfire Diagnosis document
- Battery Testing and Charging instruction
- Condensation and or water droplets visible on inside of exterior light lenses
- Condensation and/or water droplets visible on inside of exterior light lenses
- Instrument cluster production mode solution, updated to include additional model and model year applicability.
- This Document informs dealers that 2.0L TDI Gen 1, Gen 2 and Gen 3 Customer Vehicles are no longer...
- Remote lock function
- 2.0L tdi
- This Document informs dealers that 2.0L TDI Gen 1 and Gen 3 Customer Vehicles are no longer eligible for...
- Horn and ancillary steering wheel controls diagnosis.
- Balance shaft direction for debris issues.
- This Document informs dealers on VWP-18-11 for the Steering Wheel Clock Spring Limited Warranty Extension
- Alternate diagnostic process for overheating.
- Diagnostic protocol for engine noise with cam timing faults
- Vacuum line inspection for specific DTCS.
- DTC Status Bit Definitions.
- Engine replacement tip
- Incorrect removal of Turbocharger oil feed line may
- Update parts table.
- Comfort/BCM Replacement direction, updated to include additional model year applicability.
- Loss of 15 power defeat process.
- Email_Important TDI Announcement
- To include an additional model year applicability.
- Update content and include additional models and model year applicability.
- Remote Ket battery diagnostics
- Key Battery Diagnostic Process
- Updated existing tip to include latest model years for explanation of P130A
- Waste spark description and diagnosis.
- This information bulletin contains instructions for checking the pins/terminals for contacts and nano...
- ECM Software.
- Modify service instruction and to update GFF Time expenditure in the warranty table.
- Updated work procedure, 2010 Model Year pre-repair aftertreatment system inspection.
- Tip for Scan tool concerns that may occur duing a test plan
- Tip demonstrating label information for clarity
- Volkswagen of America is requesting your cooperation in supplying us with technical information related to...
- Update brochure part number, literature ordering websie address and include an additional model year...
- Update information regarding Top Tier brochure part number andVW literature ordering address
- Updated to address additional model years
- Update procedure to reset oxygen sensor adaptations, as a result of erratic test plan function.
- Update model year applicability and existing tip for transmission basic settings direction.
- Update to model year applicability and existing tip for Dual clutch basic settings procedure.
- Updated to include model year 2014 thru 2018 applicability.
- Iinclude additional model year applicability and tool information.
- 2.0L tdi
- Update to existing information to address phone concerns via bluetooth resulting from saved emoji information
- This special notice is to inform dealers to return all part numbers listed in the document
- 2.0L tdi
- Vss 17-08 - tdi
- Precautionary steps to Error Code ERP0203E when performing campaign 23U3.
- E-mail TDI ODIS AEM Update.
- Update to expand fuel testing for lean DTCS.
- Tip to reinforce dealer scan tool update importance in regards to 24CV campaign.
- Download ODIS Service Diagnostic Version for 24CV recall.
- Updated to include an additional diagnostic trouble code (P04F0)
- Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement
- Directions to assist in performing basic settings for the ac control module and include model year 2017...
- Notification of the 2.0l Gen 1, TDI remediation fix monitoring via the VTA system, in alignment with...
- Tips to address specific DTCs that can result from an exhaust leak.
- The 2.0L Gen1 FAQ document is to assist our VWGoA dealers with frequently asked questions and answers to...
- The 2.0L Gen1 FAQ document is to assisty our VWGoA dealers with frequently asked questions and answers to...
- Alternative repair direction to address DTC P1386 on the 2.5l engine
- Update Tiguan oil pan labor operation number in warranty table.
- Engine 2.0L MPI CBPA: Changed Oil Capacity to 3.6L (3.8 qt)
- 17 17 01
- This special notice is to inform dealers to return all part numbers listed in the document and order the...
- Update incorrect model year applicability in model table.
- Update incorrect model year applicability in model table
- Vas 6154
- Update vehicle metadata for 2009 pull ahead.
- Coding information for replacement ECM to address specific fault setting after the install.
- Adhesive application for installation on all areo parts solds as an accessory
- Update to existing article that addressed additional diagnostics for lean running concerns.
- Tip to perform GFF feedback for test plan issues.
- Seach tips to assist in finding DTC information
- Steps to address false misfire indication
- Directions to inspect the engine mount for debris, including stones, that may
- Update fuel sampling requirement.
- Update TB to include model year 2016 & 2017 applicability
- Idler roller for ribbed bely now available as a parts kit.
- Quick Reference of vehicle concerns
- Update to existing Tech Tip 91-11-01 for later model years, to direct technicians to the bluetooth...
- To add associated labor operation numbers to warranty table and include model year 2017 applicability.
- Update Technical bulletin to include model year 2016 and 2017 models.
- This communication is to update our ProFi dealers of the current status of the latest inbound and outbound...
- Tdi in-form
- Update tech tip to include model year 2017 applicability.
- Updated to require additional print outs during warranty claiming.
- Updated direction to address no communication concerns with the -J519- Vehicle Electrical System Control...
- Update model year applicability to include 2017.
- Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that...
- Update model year applicability.
- Updated to include model year 2017 applicability
- Equipment: other: owners/service/other manual
- Update to include additional model year applicability.
- Updated to include additional model year applicability.
- The strainer screen in the camshaft bearing bracket can tear and
- Update to the direction to perform basis setting adaptation of the AC compressor after control module...
- Update model and model year applicability.
- Data Link connector pin assignment chart that is applicable to all models
- Contacting the parts helpline
- Updated to include additional model year and required documentation instruction.
- Updated vendor code and parts table.
- To include model year 2017 applicability.
- To update causal part numbers in warranty table and update model year applicability.
- Direction to perform system reset after component replacment or disconnect of the HVAC system control head
- Update technical bulletin to include all 2017 models
- Directions to deactivate transport safeguard mode in replacement radios
- Engine, misfire diagnostic aid the MIL is flashing or illuminated."
- Update to model year applicability.
- Repair of extensive stone chips in front bumber cover.
- This communication informs of the tdi emissions settlement agreement with regards to 2.0L tdi vehicles.
- To update basic setting instruction for model year 2016 vehicles.
- To update golf (exchange parts) time units due to saga/elsa updates 6/13/16
- This dealer letter gives an update on the current emissions issues with regards to 2.0L tdi vehicles.
- Summary to be provided on a future date.
- Explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
- Direction to perform basis setting adaptation of the AC compressor after control module replacement
- To update claim processing statement.
- Reminder to follow the correct repair procedure of pilot bearing replacement, when removing and...
- Quick Reference Update Guide of the vehicles expected upgraded software level
- To update warranty labor operations due to elsa updates, and to include an additional parts table for...
- Update technical bulletin to include all models for 2015, 2016, 2017 model year applicability.
- Updated technical bulletin to add injector seal plate to parts table.
- Tech tip denoting potential for damage of the data link connector when using after market plug in devices...
- The update to this tech tip was to include the 2016 model year applicability.
- This communication informs dealers of the warranty claim coding for 30-DAY inventory maintenances on 2.0L...
- This special notice is to inform dealers to return all parts built between december 2015 and march 2016
- Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to...
- Technical Bulletin concerning the Fresh Air Blower being Inoperative
- Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle...
- Informing of a update of codes for the Inventory Vehicle Open Campaign/Action Report
- Electric coolant fans continue to run after ignition is switched off.
- Quick reference update guide.
- Elsa Newsletter
- Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF
- Technical tips on what to do if improper gasoline has been added to the vehicle.
- Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to...
- Fuel additive to help prevent sporadic misfire faults.
- Document refers to Surface corrosion or corrosion perforation that can occur on various locations around...
- Corrosion, Front fenders, at upper wheel opening.
- Document discusses the customer concern of
- Technical Bulletin about a customer concern stating that customer observed one or more of the...
- This document was created In response to multiple dealership inquires about aftermarket universal (one...
- Automatic transmission fluid requirements.
- Strut or Shock Absorber Leak Assesment.
- Front door locks hard to release.
- How to Reset Inspection Service and Interval Service software
- Summary of Technical Bulletin to include additional model and model year applicability
- Technical Bulletins.
- Airbag Issues.
- Job Aid ? VW Engine Oil Capacities (Gasoline, Diesel, Hybrid Engines)
- VW Engine Oil Capacities.
- Information on areas Surface corrosion or corrosion perforation can occur on various locations around the...
- Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch.
- Reminder that ODIS Service V3.0.0 is now available for installation, and that it is mandatory on all...
- Mandatory Installation from Web-Server.
- Glow Plug Pressure Sensor Faults Stored in ECM Fault Memory: When diagnosing MIL ON with glow plug...
- Warranty.
- This document includes what incentives are included in the Volkswagen TDI Customer Goodwill Package.
- This document gives answers to frequently ask questions concerning the current owners and lessees of TDI...
- Goodwill Package.
- 01 16 01
- High soot loads prior to regeneration can
- Technical Bulletin (Fuel Rail/System Pressure issues): When diagnosing the condition above on a common...
- Technical Bulletin (Washer Level Sensor issues): The sensitivity of the washer solvent level sensor (G33)...
- Technical Bulletin (Engine, Misfire Diagnostic Aid):
- Correction to fault code
- Control Module Faulty
- Customer Letter
- This document informs of Volkswagen AG and Audi AG received notice from the US Environmental Protection...
- Technical Bulletin (High-voltage repairs on Hybrid and Electric vehicles):
- Technical Bulletin (Fuel Rail/System Pressure, and Pressure Sensor issues): When diagnosing the Fuel...
- Tech Tips (A/C Control Module Basic Settings):
- Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory): High soot...
- Technical Bulletin (Intake manifold runner position sensor issues):
- Technical Bulletin: High Pressure Fuel Pump Diagnosis
- Volkswagen: some volkswagen vehicles with 2.0 tfsi engines will have the intake manifold and fuel...
- Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a...
- Technical Bulletin (Exhaust Pressure Control Valve / Exhaust Gas Recirculation Flow issues):
- Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not...
- Tech Tips (Instrument Cluster Production Mode):
- Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system
- Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an...
- Volkswagen: TSB contains an owner notification letter
- Emissions Service Action (Certain 2010-2014 Volkswagen Vehicles with 2.0L TDI® Clean Diesel Engine ECM...
- Volkswagen informed customers of a decision to extend the warranty for the high-pressure fuel pump (HPFP)...
- Volkswagen: certain vehicles, with clean diesel engines, have installed misfueling guard, where diesel and...
- Service Action Campaign (Certain 2009-2012 Model Year Vehicles with TDI® Clean Diesel Engine Install...
- This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates,...
- Warranty Information (Policies and Procedures Bulletin): Volkswagen has extended the warranty for the...
- Volkswagen: vehicle is rough running, fails to start and malfunction indicator lamp (MIL) be on and after...
- Technical Bulletin (No Start, or Rough Running issues): When diagnosing the condition(No Start, or Rough...
- This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates,...
- Tech Tips (Radiator Identification Sensor): On TSI (2.0l CCTA, CBFA) equipped vehicles with fault code...
- Tech Tips (Coolant Leak or Repeat Coolant Leak from the Water Pump Area): The document informs to inspect...
- Tech Tips: The document discusses the conditions of when turbo can to be fixed or replaced
- As diesel engine passenger vehicles become more popular, auto manufacturers have seen an increase in the...
- Volkswagen dealership communication
- Technical Bulletin (Sunroof or Power Sunshade, Does Not Open/Close or Automatic Operation Does Not Function)
- Tech Tips (Bluetooth Compatibility): Where A Bluetooth compatibility list vehicles
- Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative,...
- Technical Bulletin (Squeaking Noises From Front Of Vehicle): Squeaking/creaking noise from front of...
- Technical Bulletin (Hybrid Oil Drain Plug issues): Engine oil leak after an engine oil change has been...
- Technical Bulletin:Engine Lacks Performance, and Engine Warning Light ON issues
- Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass...
- Technical Bulletin:
- Update
- Volkswagen dealership communication
- Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function...
- Tech Tips: Side Heated Seat May Take Longer to Heat Up and Potentially be Lower in Temperature
- Emissions Service Action: The vehicle?s engine management software has been improved to assure the...
- Volkswagen dealership communication
- Volkswagen dealership communication
- Volkswagen dealership communication
- Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light...
- Tech Tips (Test Plan to Calibrate Adaptive Cruise Control Sensors Will Not Begin notice): Notification...
- Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
- Technical Bulletin: Diagnosing with Damage on External Chrome or Aluminum Surfaces
- Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened /...
- Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function...
- Tech Tips: Instrument Cluster Illumination
- Technical Bulletin:
- Tech Tips for No Charging System Voltage issue
- Tech Tips: Generator Charging Concern Diagnosis Tip
- Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or...
- Tech Tips: Water Leak into Front Passenger Compartment
- Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program
- Technical Bulletin (P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory ): Document discusses...
- Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses...
- Discusses the issues associated with using contaiminated gasoline
- Technical Bulletin: Update Programming of ECM for Concerns of a Bump Sensation after Coming to a Stop
- Technical Bulletin: Discussion on engine issues lacking performance
- Tech Tips: Covers concerns with Both the Anti-lock Brake (ABS) and Airbag systems working together
- Tech Tips: Equipping vehicles With KESSY ? Key Adaptation Tip
- Quick Reference Update Guide
- VW Elsa Newsletter
- Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
- Tech Tips (Active Wheel Speed Sensor Diagnosis):
- Use the following procedure to diagnose active wheel speed sensor complaints
- Tech Tips (SVM Update Instructions):
- When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically...
- Update Programming, MIL ON, DTC P0106 Manifold Absolute Pressure Range / Performance Stored in ECM Fault...
- Technical Bulletin (Manifold Absolute Pressure Range / Performance issues):
- Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the...
- Tech Tips (Electro ? Steering
- Reminder: Improvements to Technical Information Titles in ElsaPro
- Tech Tips (Oxygen Sensor Reset Procedures):
- Disconnect both O2 sensors (front and rear), start engine and let idle
- Technical Bulletin (Front Door Locks Hard to Release):
- Front Door Locks Hard to Release
- Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This...
- Electric Coolant Fans Continue to Run after Ignition is Switched OFF
- Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water...
- Technical Bulletin (Removing Paint Contaminants from Exterior Paint):
- Removing Paint Contaminants from Exterior Paint
- Tech Tips (Active Wheel Speed Sensor Diagnosis):
- Tech Tips (Common Rail TDI ? Fuel Filter Replacement and Prime/Bleed Procedure):
- Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear):
- Technical Bulletin (Camshaft Adjustment Valve 1 -N205- Diagnosis): Completing the GFF function test and...
- Use the following procedure to diagnose active wheel speed sensor complaints
- Camshaft Adjustment Valve 1 -N205- Diagnosis
- Technical Bulletin (Cylinder Contribution/Balance Faults):
- Tech Tips (RNS 510? Replacement Radio/Navigation Unit has no Sound): Replacement RNS 510 radio/navigation...
- Tech Tips (Window Switch Replacement): Be advised that when replacing a window switch on the listed...
- Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle
- Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical...
- Some Golf, GTI, Jetta, and Passat vehicles equipped with electromechanical power steering have the G85...
- Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air...
- Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure...
- Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
- Engine will not start after standing in cold weather below 0°C (32°F), MIL may be illuminated with various...
- Keyless Entry Inoperative after Access / Start (KESSY) Module Replacement
- Volkswagen: an extension warranty, with specific conditions, 10 yrs or 120,000 miles,whichever is first,...
- Technical Bulletin (Intake Manifold Faults Stored in ECM Fault Memory issues):
- MIL ON, DTCs P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory
- Volkswagen: the exterior handle on front door is very hard to open due to various climate or temperature...
- Tech Tips (AC Compressor Replacement, Refrigerant Circuit Flushing Requirement):
- Tech Tips (Window Switch Replacement):
- Tech Tips (Comfort Module (J393) or BCM (J519) Replacement):
- Technical Bulletin (Front Door Locks Hard to Release): The front door lock operation is affected by...
- When replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all...
- AC Compressor Replacement, Refrigerant Circuit Flushing Requirement
- Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient, and Soot Accumulation issues):
- MIL on, DTC P0401
- Technical Bulletin (Cylinder Contribution/Balance Faults):
- Technical Bulletin (Front Door Locks Hard to Release):
- Technical Bulletin (Secondary Air Injection System Air Flow/Pressure):
- Customer may comment that the front door is hard to open with exterior handle.
- MIL on
- MIL on
- Technical Bulletin (Intake Manifold Fault issues):
- The DLC is intended for use with diagnostic scan tools and by emissions testing stations
- Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
- Technical Bulletin (Intake Manifold issues):
- Technical Bulletin (Front Door Latches Hard to Release):
- Front Door Latches Hard to Release
- Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard):
- Engine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
- Quick Reference Update Guide:
- Tech Tips (TDI Engine
- When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below
- Use the diagram below to test the N75 Solenoid Valve in the event of a turbocharger fault code such as...
- Technical Bulletin (Oil Consumption Measurement):
- Tech Tips (Comfort Module (J393) or BCM (J519) Replacement):
- Tech Tips (Electro
- Oil Consumption Measurement
- 90-11-07
- High-voltage repairs on Hybrid and Electric vehicles
- ODIS Service Update
- Tech Tips (Instrument Cluster Illumination): The instrument cluster illumination is controlled by a...
- Instrument Cluster Illumination
- Technical Bulletin (Update Programming issue due to Harsh Gear Engagement from Park to Drive or Reverse):...
- 2009-2015
- Update Programming, Harsh Gear Engagement from Park to Drive or Reverse
- Technical Bulletin (Slave Cylinder
- Slave Cylinder
- Tech Tips (Instrument Cluster Trim/Left and Center Instrument Panel Vent Assembly Removal Procedure
- The removal procedure for Jetta (162) has been updated in the Elsa repair manual.
- Technical Bulletin (Cylinder Contribution / Balance Fault issues): The Diagnostic strategy for zero fuel...
- Tech Tips (Fuel line connections): Be aware that fuel lines are color coded on vehicles with return fuel...
- Tech Tips (2009-2014 All TDI (2.0L, 3.0L) Common Rail models Passat, Golf, Jetta, Jetta SportWagen,...
- Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure...
- MIL on
- Upcoming Communication to Owners of 2009-2015 MY Volkswagen TDI Clean Diesel Engine Vehicles Registered in...
- Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends),...
- Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI® Clean...
- Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or...
- Incorrect torque converter or flywheel/flexplate installation can result in transmission damage
- Technical Bulletin (PDI
- Pdi
- Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting...
- When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize the...
- When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize the following
- Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires...
- Tech Tips: This document informs on how to Reset the Inspection Service, and Interval Service.
- Under the ?Control Module? tab right click on address word ?17 Dash Board?. Open ?Control module OBD?. Click ?
- The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle
- Resetting Inspection Service and Interval Service
- Technical Bulletin (Exterior Lights, Moisture Accumulation):
- Exterior Lights, Moisture Accumulation
- Technical Bulletin (Washer Level Sensor): The issue is caused by the outside influence of non-approved...
- Washer Level Sensor
- PROFI Dealer Vehicle Information Request Form:
- For an upcoming campaign that will include all MY09-14 TDI (CBEA/CJAA) vehicles, we need to test the...
- Tech Tips (Engine Control Module Fault P130A ?Hide Cylinder?):
- The alarm siren may activate immediately after opening the door, after unlocking using the physical key
- Washer Level Sensor issues: The indicator lamp in the I.P. for washer fluid remains illuminated and the...
- Tech Tips (Washer Level Sensor issues):
- The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full
- Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Engine will not start after...
- Volkswagen: some vehicles fail to have any power or the check engine warning light is on.
- Technical Bulletin (Engine Lacks Performance, Engine Warning Light ON): Engine does not have any power and...
- Technical Bulletin (TDI Common Rail High Pitch Whine Noise after Switching Ignition OFF): With the...
- TDI Common Rail High Pitch Whine Noise after Switching Ignition OFF
- Technical Bulletin (Exhaust Gas Recirculation Flow, Could be accompanied with Soot Accumulation): High...
- Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can
- Tech Tips (All Navigation Radios-All Models): When the Navigation RNS 850/510/315 is in 3D mode, the top...
- HVAC, Unpleasant Odor
- All Navigation Radios-All Models
- Tech Tips (Vehicles equipped with Premium (RCD 510) Radios ? Coding Information for Replacing ?AC? Suffix...
- When replacing the radio on a 2010 ? 2011 vehicle equipped with a Premium 8 (RCD 510) radio with part...
- Coding Information for Replacing ?AC? Suffix Radios with ?AF? Suffix Replacement Unit
- Technical Bulletin (Incorrect Glow Plug Faults): During the initial glow phase, after switching the...
- Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of...
- Squeaks, Rattles, Noise, Repair Materials
- Volkswagen Warranty Policies and Procedures ? April 2014
- Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system
- Volkswagen: airbag warning light was illuminated indicating a front side airbag pressure sensor...
- Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster): Airbag lamp in instrument...
- Technical Bulletin (Sunroof / Sunshade, Will Not Open): The panoramic sunroof, regular sunroof or sunshade...
- Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or...
- Sunroof / Sunshade, Will Not Open
- Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag Control Module
- Gasoline Quality
- Electric Coolant Fans Continue to Run after Ignition is OFF
- Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some...
- Proper Removal of Engine Cover to Avoid Breakage
- Technical Bulletin (No Start, or Rough Running due to Fuel Rail issues): When diagnosing the condition...
- MIL on
- Jetta Bluetooth manual coding procedure.
- Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version...
- Software Version Management
- Technical Bulletin (Manifold Absolute Pressure Range / Performance Stored in ECM Fault Memory): Monitoring...
- Technical Bulletin (No Start, or Rough Running issues): When diagnosing a MIL ON, no-start or rough...
- Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights,...
- Volkswagen: some vehicles may experience an illuminated brake warning light
- Update Programming to Eliminate DTC P050A Stored in ECM Fault Memory
- When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be...
- Vehicles equipped with Immobilizer 4 (Download) ? Adapting Keys after Vehicle Lock Set Replacement
- On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box...
- Please contact VW Helpline before attempting repair
- Wiper Motor Noisy or Inoperative
- Tech Tips (Lean Fuel Trim Readings):
- Tech Tips (Lean Fuel Trim Readings):
- Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative,...
- To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after...
- Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Document discusses diagnosis Codes...
- VW Elsa Newsletter.
- Volkswagen Elsa Newsletter
- DTC P2711
- Tech Tips (Fuel injector seals for 2.0L (CBPA) engine code): Fuel injector seals are available separately...
- Tech Tips (A/C Control Module Basic Settings):
- Fuel injector seals for 2.0L.
- To set basic setting on the Climatic control module after replacement for fault code 00898 follow steps below
- Fuel injector seals are available separately for service repairs
- A/C Control Module Basic Settings
- Fuel injector seals for 2.0L (CBPA) engine code
- VW Elsa News Letter
- Tech Tips (No Charging System Voltage):
- Tech Tips (Auto Unlock Function): On the vehicles listed above, the auto unlock feature will only unlock...
- Tech Tips (Auto Unlock Function): On the vehicles listed above, the auto unlock feature will only unlock...
- Auto Unlock Function.
- On the vehicles listed above, the auto unlock feature will only unlock the door(s) that were unlocked when...
- Auto Unlock Function
- Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may...
- Rattling noises from engine compartmen area or exhaust system.
- Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM.
- Rattling Noises from Engine Compartment Area or Exhaust System
- On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box...
- On-Car Analysis List.
- On-car analysis list from December 2nd, 2013 please contact VW Helpline before attempting repair
- Please contact VW Helpline before attempting repair.
- Volkswagen: a seam sealer skip or hole in area around hood hinge or behind front fender is causing water...
- Tech Tips (Water Leak into Front Passenger Compartment): A concern of water leak into the front passenger...
- A concern of water leak into the front passenger compartment may be caused by a seam sealer skip or hole...
- Tech Tips (All Models 2000-2014
- Part ordering
- If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down?...
- Tech Tips (Bluetooth Compatibility):
- To check Bluetooth compatibility for all 2011 and newer vehicles, as well as 2010 Routan, use the link below.
- Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system
- Perfect Delivery Inspection (PDI)
- Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area):
- Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463):
- Use of aftermarket air filters such as cotton bed steel mesh or cone style, can
- Inspect the water pump for signs of contact with engine oil
- Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient issues):
- MIL on, DTC P0401
- Tech Tips (No Communication with the J519 Vehicle Electrical System Control Module/Body Control Module):...
- If no communication can be established to the Vehicle electrical system control module J519 (address word...
- Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF):
- Please contact VW Helpline before attempting repair
- Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations...
- Tech Tips (Tail Lamp Bulb Holder):
- The picture below shows an A6 Jetta Outer Tail Lamp Bulb Holder (Part Numbers 5C6945257 & 5C6947258)
- Outer Tail Lamp Bulb Holder
- Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the...
- Tech Tips (Tire Pressure Monitoring System): The TPMS system on the MY vehicles (2011-2013 Jetta, Tiguan,...
- Technical Bulletin (Keyless Entry Inoperative after Access/Start (KESSY) Module Replacement): After...
- Technical Bulletin (Keyless Entry Inoperative after Access / Start (KESSY) Module Replacement): After...
- Technical Bulletin (Exhaust Pressure Control Valve issues):
- MIL on
- High Voltage Repairs on Hybrid Vehicles
- Service Action Campaign (TDI Clean Diesel Engine Install Misfueling Guard): As diesel engine passenger...
- VOLKSWAGEN DEALERSHIP COMMUNICATION (Revision to Service Action 20T8 ? Owner Supplements Install...
- Tech Tips (Vehicles with 2.5L Engine
- When diagnosing fault code P2279-Leaking Air in Intake System, be sure to check the cam timing first.
- Volkswagen: during cold weather, engine fails to start, after standing, and if moisture, from intake air,...
- Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Engines will not start after...
- Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be...
- On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box...
- Rns 315
- Tech Tips.
- On-car analysis list of Customer Complaints: Transmission Concerns(including clutch assembly, bevel box...
- Volkswagen: diagnosis for high pressure fuel pump where no start, engine crank, without driving, after...
- Technical Bulletin (Update Programming to Eliminate DTC P050A "Cold Start Idle Air Control System...
- Technical Bulletin (Brake Electronics issues): This software update is designed to re-program both the ECM...
- Update Programming ECM to Eliminate DTC 03366 Stored in Brake Electronics Fault Memory
- Tech Tips (Daytime Running Light (DRL) Indicator in Instrument Cluster):
- Tech Tips (Equipped with 2.0L TDI Engine
- Be aware that the daytime running light (DRL) indicator in the instrument cluster is only functional on...
- Daytime Running Light (DRL) Indicator in Instrument Cluster
- Jetta-jsw
- This bulletin provides a procedure to determine ?repair? versus ?replacement? of an automatic transmission
- Volkswagen: activated charcoal filter system, solenoid valve and performing gff function test a vacuum...
- Technical Bulletin Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve)...
- Update
- VOLKSWAGEN DEALERSHIP COMMUNICATION (Revision to UPDATE 24X7
- Revision to UPDATE 24X7 ? 2.0L MPI Software 2011-2012 My Jetta 2.0L
- 2.0L MPI
- 2.0L MPI
- JETTA Perfect Delivery Inspection (PDI)
- Technical Bulletin (Damage on External Chrome or Aluminum Surfaces) The surfaces of chrome parts can get...
- Damage on External Chrome or Aluminum Surfaces
- Volkswagen: some vehicles may exhibit poor power steering assistance
- Technical Bulletin (Poor Power Steering Assistance):
- On-car analysis list of Customer Complaint: Transmission Concerns (including clutch assembly, bevel box...
- Poor Power Steering Assistance, DTCs 16344 014, 16353 014, 16355 014, 02614 014 Stored in Power Steering...
- Tech Tips (Equipped with RCD-510 Premium 8 Radio
- If the radio is switching to the Bluetooth audio selection whenever a paired phone makes any sound, such...
- Equipped with RCD-510 Premium 8 Radio ? Radio Switches to Bluetooth Audio without Input
- In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time...
- Tech Tips (Brake Electronics (ABS) Fault Code 02757 Diagnosis Tip):
- If the battery has a low state of charge or is disconnected, fault code 02757 ?adapting tire pressures?...
- Service Action Campaign (Certain 2009-2012 Model Year Vehicles with TDI Clean Diesel Engine Install...
- VOLKSWAGEN DEALERSHIP COMMUNICATION (Revision to Service Action 20T8 Install Misfueling Guard):
- Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found...
- Install Misfueling Guard
- Secondary Air Pressure Sensor Limited Warranty Extension
- Tech Tips (Measure Value Block Request): If a request has been made for several MVBs from a DSG...
- VOLKSWAGEN DEALERSHIP COMMUNICATION (Service Action 20T8 Install Misfueling Guard): Volkswagen has...
- If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft),...
- Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis
- Volkswagen: on some vehicles, low fuel stored in ECM pressure, engine would crank but not start long...
- Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function...
- Jetta Perfect Delivery Inspection (PDI)
- Technical Bulletin (Customers may complain of a MIL ON condition, which is caused by DTC P2458 (Diesel...
- Update Programming to Eliminate DTC P2458 Stored in ECM Fault Memory
- Technical Bulletin (Automatic Transmission Fluid Requirements): At this time, Volkswagen Group of America,...
- Technical Bulletin (Manifold Absolute Pressure Range / Performance Stored in ECM Fault Memory): Monitoring...
- Update Programming, MIL ON, DTC P0106 Manifold Absolute Pressure Range /ECM Fault Memory Performance Stored
- Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines...
- Technical Bulletin (Update Programming of ECM for Concerns of a Bump Sensation after Coming to a Stop):...
- Wiper Blade Inspection for Proper Warranty Coding
- Technical Bulletin (Sunroof / Sunshade, Will Not Open): The sunroof's "Basic Setting" has been...
- Technical Bulletin (Cylinder Glow Plug issues): During the initial glow phase, after switching the...
- MIL on
- VOLKSWAGEN DEALERSHIP COMMUNICATION (Revision to Service Action 20T8 FAQ Install Misfueling Guard):
- We would like to inform you that the FAQ for Service Action 20T8 has been revised to include additional...
- Update Programming of ECM for Concerns of a Bump Sensation after Coming to a Stop
- After A/C control module J301 is replaced, fault 00898-005 ?Activation A/C Compressor No or Incorrect...
- Rns 315
- When diagnosing a vehicle concern, and fault P130A ?Hide Cylinder? is found in the Engine Control Module...
- Brake Disc, Pulsation, All Vehicles except Routan (U.S. Only)
- As diesel engine passenger vehicles become more popular, auto manufacturers have seen an increase in the...
- Replacement Radio/Navigation Unit has no Sound
- Volkswagen: some vehicles may run rough, experience engine crank, or no start
- High Pressure Fuel Pump Diagnosis
- When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch...
- Be aware that fuel lines are color coded on vehicles with return fuel pressure lines
- Volkswagen: some vehicles may experience a misfire and/or reduced engine performance
- Engine, Misfire Diagnostic Aid
- Volkswagen: steering rack
- On-car analysis list of Customer Complaints: Transmission
- After a cold start, the engine coolant temperature gauge will slowly rise to approximately 190° F. When...
- For concerns of Fault Code P117A ?Bank 1, correction Lambda middle reached adjustment limit? stored in the...
- Pss
- Volkswagen: high pressure fuel pump diagnosis
- When diagnosing a customer concern of fuel gauge not reading full after fueling, start by checking for the...
- Bluetooth Compatibility.
- When replacing a radio navigation unit, inspect the security labels on both the new and replacement units...
- Radio Navigation Unit Security Label
- After switching ON the RNS 315 radio-navigation system, the message "Please insert software CD" appears...
- To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at...
- Be aware that the 24 RNS-510 radio presets are not band dependent, and can be programmed to any mix of AM,...
- MIL ON, DTC(s) P0671, P0672, P0673 and/or P0674 Stored in ECM Fault Memory
- RNS 510 ? Radio Preset Display
- When diagnosing a customer concern of fuel gauge not reading full after fueling, start by checking for the...
- When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary
- Vehicles Equipped with Bluetooth Hands-Free Phone ? Pairing of Android Phones
- GPS Antenna Concerns
- Satellite Radio Overview
- This Technical Bulletin provides an overview for performing vehicle four Wheel Alignment and information...
- Replacement RNS 510 radio/navigation units may be shipped in transportation safeguard mode and therefore...
- The Apple iPhone 5, iPad fourth generation, and iPod nano seventh generation use a proprietary ?Lightning?...
- MDI Control of Apple Devices with Lightning Connector (iPhone 5, iPad fourth generation, iPod Nano seventh...
- Recommended procedure for removing damaged CV boot.
- If Passenger Occupant Detection System (PODS) basic settings will not complete after module replacement,...
- Engine Exhaust Flap Limited Warranty Extension
- Volkswagen: it is a normal occurrence for the electric coolant fans to continue to run after the ignition...
- All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
- If key blade is found to stick or bind when opening or closing, check position of roll pin that secures...
- Technical Bulletin (Factory Installed Media-In (MDI), Updated Programming for Various iPod Concerns): The...
- Technical Bulletin (Exhaust Pressure Control issues):
- Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician...
- Technical Bulletin (Bluetooth System Identification):
- VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming Communication to Owners of 2009-2013 MY Volkswagen TDI Clean...
- Volkswagen: airbag warning lamp illuminated in instrument cluster, DTC B101614 stored in airbag control module
- Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag...
- Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement...
- No charging system voltage.
- ElsaWeb Newsletter
- Cbfa 2.0T tsi
- When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds...
- If airbag faults B10B300 OR 03551 are stored, DO NOT replace airbag components for these faults, refer to...
- Volkswagen: would experience no start after long periods of not driving and engine run rough
- Technical Bulletin (Incorrect Glow Plug Faults): During the initial glow phase, after switching the...
- Volkswagen: camshaft adjustment valve 1-N205-DIAGNOSIS
- Volkswagen; possible oil leak after oil filter change. due to the mounting design of the engine oil...
- Volkswagen: possible oil leak from oil filter housing
- On-car analysis list of Customer Complaints: Transmission Concerns
- Volkswagen:evaporative (EVAP) emission system, diagnostic trouble code diagnosis
- If seat belt light remains on only when passenger seat is occupied with seat belt latched, check to see if...
- Volkswagen: when not driven for long periods of time, would have engine crank, but no start
- Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function...
- Engine Crank, No Start after Long Periods without Driving
- Volkswagen: passenger seat belt remains on when occupied and belt is latched
- Tech Tips (Seat Belt Light Remains On With Passenger Seat Occupied, and Seat Belt Latched):
- Volkswagen dealership communication (20R9
- Volkswagen dealership communication (20R9
- Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen...
- Tech Tips (Alternative (Second) Speed Display):
- Alternative (or second) speed display is available to show the vehicle speed in units other than the units...
- Alternative (Second) Speed Display
- On-car analysis list of Customer Complaints: Fuel gauge doesn't read full when the fuel tank is
- Tech Tips (Equipped With KESSY ? Key Adaptation Tip):
- Technical Bulletin (PDI
- Technical Bulletin (Four Wheel Alignment Overview): This Technical Bulletin provides an overview for...
- Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines...
- Equipped With KESSY ? Key Adaptation Tip
- Volkswagen Carefree Maintenance Program ? Gasoline Engines (Except Routan)
- Technical Bulletin (Slave Cylinder
- Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail...
- Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine...
- Technical Bulletin (Sunroof / Sunshade, Will Not Open): The issued of The panoramic sunroof, regular...
- Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not...
- Technical Bulletin (Cylinder Glow Plug Circuit issues): Internal hardware issue of the glow plug relay may
- Tech Tips (Equipped With KESSY ? Key Adaptation Tip): When adapting keys on a vehicle equipped with KESSY,...
- All keys must be present during key adaptation
- Engine Control Module Updates:
- Engine Control Module Updates:
- Technical Bulletin (Bluetooth System Identification):
- Installation instructions (Original parking distance control system):
- Volkswagen: due to a loose or unfastened connector for passenger air bag, the airbag warning lamp may...
- Technical Bulletin (Airbag Warning Lamp Illuminated in Instrument Cluster, DTC B101614 Stored in Airbag...
- Warranty Information (Volkswagen Amenity Subsidy Program
- Body/Infotainment Module Software Updates:
- Transmission Control Module Updates:
- Updates (RVU):
- Warranty Information (Volkswagen Amenity Subsidy Program
- Volkswagen: all models experience the timing chain slipping, rattling noises of the engine after starting,...
- Water Leak into Front Passenger.
- Volkswagen: while driving vehicle or having seat raised or lowered, tolerances between seat bolt frame...
- Volkswagen: see document search button for customer letter
- Customer States Windshield Wipers Streak or Smear
- Window Switch Replacement
- It may be necessary to reboot the RNS315 navigation unit, due to either, update programming stalled, or...
- Cars equipped with RNS 315 Navigation Unit ? System Reboot Sequence
- Volkswagen: the transmission control module has an implausible transmission shift sequence due to the...
- Tech Tips (Kessy System ? Loss of 15 Power):
- Volkswagen: instrument cluster shows brake warning light on, caused by an incorrect sampling rate between...
- Volkswagen: while driving approximately 55 to 65MPH, a whinning or whistle noise is heard
- Whistle or whine noise coming from the transmission when driving
- Volkswagen: certain model year vehicles are experiencing engine not starting, making a rattling noise when...
- Volkswagen: under high electric power consumption, vehicle would run rough and have cold starts.
- Volkswagen: in some vehicles, the warning light for engine may be on and the engine power has failed.
- Volkswagen: if electronic steering column lock was replaced or updated, would cause the remote keyless...
- For concerns of navigation inaccuracy, with or without antenna fault codes, begin by checking the number...
- The instrument cluster illumination is controlled by a photocell inside the cluster
- Volkswagen: the gear box has a momentarily delay while accelerating
- The RNS 315 navigation unit does not contain the Sirius Traffic functionality
- Sirius Traffic Information
- 2012-2013
- When the Navigation RNS 850/510/315 is in 3D mode, the top portion of the screen may not display streets
- Tech Tips (A/C Control Module Basic Settings):
- A/C Control module basic settings
- Volkswagen: malfunction light is on and there is noise with the engine running rough
- Volkswagen: malfunction light is on with two possible fault codes present
- When diagnosing a low battery or no charging system concern, start by inspecting the SA1 200 amp fuse in...
- Volkswagen: there is a warranty extension on hard start conditions for customers who had an earlier...
- Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). update to...
- Volkswagen: MIL on; DTC P0087 and/or P0192 stored in ECM fault memory. one or more of the following codes...
- The TPMS system on the MY vehicles listed above, is now an indirect type system
- When replacing fuel system components on the Common Rail TDI engine (including the fuel filter), the fuel...
- If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow...
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 Volkswagen Jetta?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history