Volkswagen Passat power steering loss problems

Filed Oct 28, 2026 · Electrical, Engine · VA

Since purchase in XXX, the vehicle has intermittently illuminated the EPC warning light at startup, at which point the engine will not accelerate (reduced power/limp mode). Cycling the ignition usually clears it. Beginning in XXX, a second symptom appeared: while stopped at idle (traffic lights, stop signs), the battery warning light illuminates and the engine stalls, requiring a restart in traffic. This has occurred approximately 8 times in XXX, most recently on Saturday, XXX when it happened twice. Wet or rainy conditions appear to make it worse. Stalling in traffic results in loss of power steering and brake assist and is a safety hazard. The vehicle has been to Volkswagen dealers six times for this complaint with no lasting repair: a wiring harness repair at Freehold VW (XXX); a boost pressure sensor diagnosis (XXX); an overlay harness, ECM-related repairs, and ECM software update under emissions recall 23EO (XXX); boost pressure sensor replacement (XXX); airflow meter replacement and harness repair (XXX); and re-pinning of loose connections at the ECM connector for the G31 boost pressure sensor (XXX), all at World VW in [XXX]. Fault code P0236 (turbocharger boost sensor circuit) has been recorded on every visit; P2261 was also recorded. The check engine light, EPC light, and stalling have all returned since the XXX repair. Current mileage is approximately 27,800. Repair orders are available on request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 28, 2026 · Airbags, Electrical · IN · crash · 1 injury

A prior recall that was supposedly fixed, broke again. Submitted several complaints with the federal safety agency and Volkswagen. Volkswagen said i had to pay a fee to verify what was wrong with my vehicle because the recall had already been fixed before. Months of waiting and waiting for an appointment and then vw would still not refix the recall. So years and years went by before the recall was recalled and vw sent out notice. Only to schedule you vehicle for service months out and then call and cancel because there is a shortage of parts and no known time in getting them. Anyways the recalled recall is an air bag spring that caused all of my vehicles "functions" to stop working. No horn, no steering wheel button functions, no computer functions. And during this time of not having my vehicles safety features... I was involved in a collision where my horn would have probably been a lifesaver and a vehicle saver had I had it

Filed Jun 3, 2026 · Electrical, Engine · NJ

A major engineering and material design failure occurred involving internal fluid containment seals, resulting in a severe electrical safety hazard. Pressurized engine coolant breached an internal component seal and began migrating internally directly through the vehicle's engine wiring harness via capillary/siphoning action. The fluid used the sealed wiring loom as a literal pipeline, traveling inside the wire insulation to bypass all outer weather seals and completely flood the Engine Control Module (ECM) pin connectors. The vehicle's dealership service department documented extensive galvanic corrosion and shorting inside the primary vehicle computer pins due to this blue-green fluid pooling. Because the dealership has not yet completed the full repair, the exact originating component source of the leak (e.g., the engine coolant temperature sensor or the coolant expansion tank housing barrier) remains unconfirmed. However, the physical mechanism of the coolant migration through the sealed harness into the primary electrical architecture is fully verified. This defect presents a critical safety risk. The sudden flooding and short-circuiting of the Engine Control Module can cause an immediate and unexpected loss of engine propulsion, power steering assist, and electrical control while driving at highway speeds, creating an imminent risk of a high-speed collision.

Filed Jun 8, 2024 · Airbags · FL

The airbag light came on and shortly thereafter the steering wheel buttons stop working, the steering was stiff and harder to turn and ultimately the horn stop working. I feel driving a vehicle with a broken clock spring is extremely dangerous and is a safety issue.

Filed Mar 15, 2024 · Airbags, Electrical · NY

My family and I have been VW owners for over 60 years. Unfortunately, the 2006 VW Passat has been layered with defects, negligent manufacturing issues, faulty wiring, electrical problems, computer glitches, to mention a few. There have been many recalls including an official recall by the federal safety agency, for steering linkage problems and tie rod assembly which caused a loss of steering, crashes and deaths. Over 292 complaints are filed with Consumer Affairs, over 561 defects reported, and thousands of horror stories like mine about this car. It's considered a lemon by many car professionals. Many dealerships in the USA offered to inspect, and replace the electronic steering column lock free of charge and address any other concerns, which should be standard, reasonable behavior for all VW dealerships, mandated by this Federal agency. Shortly after this car almost killed me in 2013, VW put me through countless stressful hours of calls, emails and the like and still refused to be fully accountable. Shortly after my almost end of life, the notorious VW Emissions Scandal spoke volumes. VW was well aware of their defects including the electrical system in the steering column/immobilizer, (the system won’t recognize the key; a module in the car that connects the key and starts the engine is defective). In many cases, the entire steering column is defective and has to be completely replaced because the car’s pistons, internal combustion and engine are all subpar. Even the Sunroof and drains are defective and every time it rains, there is a flood in my car which has caused life threatening mold and mildew. I am respectfully asking for your help in having VW provide me, a near [XXX] woman, a safe, reliable, car without another defective sunroof and without defective water drains. It can be used as long as it's reliable and without deadly mold and mildew. I have photos. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 17, 2023 · Steering · VA

The Clock Spring issue that was recalled on 2012-2014 Passat's occurred on my vehicle which was manufactured July 2014 as a 2015. The car only has 60k miles on it. Clicking while turning the wheel, no steering wheel controls work and air bag light is on meaning it will not deploy and my vehicle will not pass inspection. I have spent days calling the dealer and left messages but they are not returning my calls. From the my research it appears that my vehicle is not covered by the current recall so in addition the safety concern I will pay a large sum to fix this issue and have no idea how long it will last. I've read where some of the clock springs fail at 30k.

Filed Aug 30, 2022 · Engine · 170,000 miles · TX

The contact owns a 2008 Volkswagen Passat. The contact referenced the federal safety agency Campaign Number: 17V509000 (Fuel System, Gasoline). The contact stated that on multiple occasions while driving, the steering became difficult to maneuver. The contact stated that the RPM increased rapidly and the engine revved without the accelerator pedal being depressed. The check engine warning light was illuminated. Additionally, the contact stated that she was able to maneuver the vehicle and turned the vehicle off. The contact stated that she was able to restart the vehicle without a failure. The contact then stated that a week later while driving the failure recurred. The vehicle was taken to the dealer where it was diagnosed that the ECM needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The contact was advised to take the vehicle to the dealer. The failure mileage was approximately 170,000.

Filed Feb 24, 2022 · Acceleration, Electrical · MO

I was driving this particular day through a busyfour way stoplight intersection around time school was dismissing so 3:30ish PM. And I lost all power to my vehicle with just the battery light flashing once. I barely made it out of the i intersection and to the shoulder of the road as there was no power steering and i had to pump my breaks to stop. I called the local police and let them know it would be towed tomorrow morning. The tow bill was 100 dollars and i had replaced the battery thinking it was the problem. The brand new battery drained in two minutes tops after install alternator was tested and fuses were in working order all except for one that went to my12 volt charging port which was replaced as well as serpentine belt was replaced with alternator test. The battery still drains instantly and when speaking with volkswagon suntrup in sunset hills st. Louis which is the nearest Volkswagen dealership about 30 minute drive my car still is under a dealership warranty for the national emissions recall that was just fixed after i purchased the vehicle. The dealership refuses to come get/ fix/ diagnose or rectify vehicle although admitting to knowing this year has parasitic draws instally killing a brand new battery even while driving was/is a very dangerous situation for me and my family. This car has been sitting in my drive way now for 6 months while nothing is being by vw and i am without safe or working transportation for my family. Ive also been told by vw. That they cant find some parasitic draws and are confused as me!

Filed Sep 27, 2021 · Engine · MO

The oil light/message comes on, the engine burns oil excessively about 1 quart every 1,000 miles or so. Our biggest fear is that this will continue to get worse and the engine may seize up at some point due to this issue and cause a loss of power and/or a severe accident for us or anyone operating one of these VW vehicles with the same issue. VW indicated that this is "normal" but it does not seem "normal". We have never owned a vehicle (even older vehicles back in the 80s/90s) that had an issue like this, and this is a newer (2015) vehicle that we bought brand new. We had the shop look at the vehicle and they said it is burning oil and there might be a class-action against VW for it burning oil. It did not have this issue until some time after 30,000 miles which tells us that something changed in the engine at some point. With all of the burning oil, this cannot be good for air quality and the environment - not sure how many of these engines are on the road currently, but multiplied out it has to be contrary to any clean air acts that may exist in various states or at the federal level. Additionally, the oil is special "european" and is relatively expensive - the manufacturer indicates up to 10,000 miles between oil changes, so that could be up to 10 quarts of oil burning into the atmosphere (and costing money) for a single VW vehicle every few months, not to mention the safety concern if someones engine seizes up as a result causing a loss of power, loss of power steering, loss of power brakes, etc. The date shown for 'incident' is the most recent date that we had to add oil due to this issue.

Filed Aug 17, 2021 · Airbags, Steering · MA

1. Air bag clock spring (twice) 2. No horn, no airbag driver side safety issues. 3. Yes, twice confirmed by VW Dealer 4. No other inspections, just VW Dealer 5. No warnings of the issue until none of the controls were working - now an air bag light January 29, 2020 - 82227 miles, no air bag, no horn, no steering wheel controls. brought to dealer - says there is a known issue with the clock spring and replaced it no charge. August 11, 2021, 123221 miles, no air bag, no horn, no steering wheel controls. brought to dealer - says not covered. the first clock spring lasted 80,000, the second one even more faulty - lasted barely 40000.