2004 Volvo S60: hesitation when accelerating

Filed Jun 28, 2017 · Engine · 158,000 miles · NH

Tl* the contact owns a 2004 volvo s60. The contact stated that while driving at approximately 40 MPH, the check engine warning indicator illuminated. The engine started to hesitate and stalled. The contact coasted to the side of the road and waited for approximately three minutes and restarted the vehicle. The contact drove the vehicle to m.p.l. Automotive laconia new hampshire (independent mechanic). The vehicle was diagnosed with a fuel rail pressure sensor needing replacement and also advised the contact of the federal safety agency campaign number: 07v226000 (engine and engine coolant). The contact called lovering volvo meredith new hampshire was advised that the VIN was part of the recall. The vehicle was not repaired as of yet. The approximate failure mileage was 158,000.

Filed Jan 21, 2015 · Brakes, Engine · 100,000 miles · CA

The 2.4l 2004 volvo s60 experiences erratic behavior and engine failure when operating multiple concurrent electrical systems. When these systems (operated within specified guidelines) are used concurrently they cause the following conditions: engine failure, loss of power steering, loss of brakes. The following is a list of electrical channels that have been used to trigger the engine failure: brakes, indicator lights (right or left) heated seats (x2) front windshield defrost multiple s60 model owners have reported having experienced this same engine failure which cannot be detected by the manufactures diagnostics test. When tested the battery, alternator and computer all present positive read-outs. Http://repairpal.com/replaced-map-senor-and-maf-airflow-engine-light-back-on-hesitate-still-cut-off-321 http://community.cartalk.com/discussion/2290017/volvo-s60-engine-cuts-off-while-turning https://answers.yahoo.com/question/index?qid=20110502120739aa0tjsr this is a serious condition that could result in a collision or even death. A recall on this model is being immediately requested. Thank you, [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Jun 29, 2012 · Electrical · 118,000 miles · MA

Tl* the contact owns a 2004 volvo s60. The contact stated that the vehicle was experiencing several electrical failures. The rear door indicator was illuminated, the vehicle was exhibiting hesitation, the steering was hard to turn and the interior light remained illuminated. The vehicle was taken to a local mechanic where the brake, spark plugs and air filter was replaced however, the failure was not corrected. The vehicle continued to experience the electrical failures. The manufacturer was not made aware of the failure. The failure mileage was 118,000 and the current mileage was 120,000.

Filed Apr 28, 2010 · Engine · 87,000 miles · NJ

Tl*the contact owns a 2004 volvo s60. While driving at approximately 10 MPH, the vehicle hesitated, decreased in engine performance, the check engine light illuminated and the vehicle stalled. The contact turned off the ignition restarted it to move to the side of the road. The failure occurred on four other occasions. The vehicle was taken to an independent mechanic who was unable to diagnose the failure. The current mileage was approximately 90,000. The failure mileage was approximately 87,000.

Filed Nov 9, 2009 · Engine, Fuel system · CA

2004 volvo s60 regularly serviced by volvo. Bought new, well maintained, exc cond, & oil changed ever 3000 miles. Only 68k miles presently but many problems since bought new. #1) replacing burned out rear/front headlight bulbs constantly. #2) check engine light came on before 40k miles. Wasn't too concerned at first because only issue I seemed to have was hesitation somewhat when accelerating after being parked. Until one day veh wouldn't accelerate beyond a roll after being stopped for red light. A few days later driving approx 50 MPH uphill car stopped accelerating and stalled. Both times I was able to roll to side of road, restart & make it home. Scared me enough though to take to volvo next day. Fuel sensor gauge needed to be replaced. When I checked if covered under recall - found my car wasn't based on VIN, another fairly costly repair. #3 - AC fan wouldn't go off one day - fan running full blast & control switch wouldn't regulate or work. Fan continued to run even when I turned off ignition. Dead battery next morning needed jump start. Ac fan modular bad - modular repair done & then fan somehow burned out due to new modular when mechanic testing repair - now fan needed to be replaced. Very costly repair once again. #3 - check engine light came on. After months to several mechanics, checking oil, etc. Told light probably just faulty. Then check oil light blinks - car had less than 1/2 qt oil & I had major engine damage. Had complete engine rebuilt & very expensive. Engine running great. Now 2 mos later & I hear a metal to metal noise/sound when making turns - preferably right hand - & coming from rght front side of car. Mechanic can't see safety issues when up on rack. Has no clue. Noise annoying and concerning. It sounds like wheel is going to fall off car. I am sure it will cost another fortune . However once repaired - trading in. I loved my car...however no longer feel veh is safe or depen.

Filed May 21, 2009 · Engine · 40,000 miles · FL

Displays "check engine" most of the time and downloads to a fuel pressure sensor. Auto hesitates periodically and has on 4 separate occasions stalled completely. 07v226000 has a recall for this exact problem but volvo says my VIN not affected. Seems from seeing other complaints with same problem that volvo underestimated their problem.

Filed Oct 2, 2008 · Electrical · 62,000 miles · GA

Driving along the highway at bout 70 MPH, the car suddenly hesitates and loses power (the RPM reader, and speedometer fall to 0). The car then regains power and then it jerks and hesitates, once again losing power. This time the power stays out. Haven't had the problem fixed yet the initial acceleration of the car is extremely slow and it requires a hard press on the gas to get the car in motion. The power doesn't work for the following functions: power lock (including the remote) all steering wheel functions (radio and cruise control) headlights turn signals windshield wipers sun roof side and rear view mirrors air conditioning controls all gauges in the dashboard.

Filed Nov 10, 2007 · Fuel system · 38,500 miles · AZ

Strong fuel odor emitting from passenger side of vehicle. Observed gas stains covering outside of gas tank. Returned to dealer and dealer replaced fuel pump. Since then, no odors. However, auto continues to hesitate when driving. In one instance, car stalled in heavy traffic and was nearly rear ended.