COMPONENT: The right-rear shock absorber sheared off at its base and was loose inside the rear suspension. The vehicle has approximately 78,000 miles and the factory Polestar Engineered (Öhlins) suspension. There was no collision, impact, or road hazard before the failure. The failed shock is still on the vehicle and is available for inspection upon request. SAFETY RISK: The failure occurred while driving at highway speed. With the shock detached, that corner of the vehicle had no damping, which can reduce stability and braking control, especially over bumps or in an emergency maneuver. The loose shock could also strike and damage nearby brake lines, wiring, the tire, or axle components. CONFIRMATION: On [XXX], an independent repair shop found the right-rear shock sheared at its base, with no sign of impact or other damage. The mechanic said he had never seen this failure before. On [XXX], at the first available appointment, Volvo Cars Danbury (Danbury, CT) confirmed the right-rear shock was broken and recommended replacing both rear shocks. INSPECTIONS: The authorized Volvo dealer inspected the vehicle and submitted a goodwill request to Volvo, which Volvo declined. To my knowledge, Volvo has not inspected the failed part directly. No police or insurance inspection. WARNING SIGNS: On [XXX], I first noticed metal-on-metal noises from the rear while driving on the highway. No warning lamps or messages appeared. There were no other symptoms before the noise began. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The worst 2022 Volvo V60 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Suspension1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Suspension1
Recalls 3
Electrical system: propulsion system: traction battery
- What is wrong
- Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
- Risk
- A short circuit in a high-voltage battery increases the risk of a fire.
- Remedy
- Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1‑800‑458‑1552. Volvo Car's number for this recall is R10312.
Recall number 25V179000 · Recall details
Engine and engine cooling: engine: engine control module (ecu/ECM)
- What is wrong
- Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
- Risk
- The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
- Remedy
- Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1‑800‑458‑1552. Volvo Car's number for this recall is R10198.
Recall number 22V793000 · Recall details
Seat belts: rear/other: retractor
- What is wrong
- Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
- Risk
- An unsecured child restraint system can increase the risk of injury during a crash.
- Remedy
- Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1‑888‑458‑1552. Volvo Car's number for this recall is R10111.
Recall number 21V682000 · Recall details
See all 3 recalls for the 2022 Volvo V60
Defect investigations
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
Technical service bulletins for the 2022 Volvo V60 185
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This is a Technical Journal: Text only no attachments
- This is a Technical Journal text only no attachments : Improved 12V battery test in VIDA. The 12V battery...
- This is a Tech Journal
- This is a TJ
- This is a TJ
- This is a Technical Journal: Text plus 1 .jpg attachment
- This is a TJ
- This is a TJ Text only no attachments -- If the FLC2 is not responding when attempting to load software,...
- This is a Technical Journal: Headlamp condensation inside lens
- This is a Technical Journal: Intermittent knocking noise during acceleration
What 2022 Volvo V60 owners say
Most recent owner complaints, unedited.
Compare the 2022 Volvo V60
Other model years
Questions about the 2022 Volvo V60
Is the 2022 Volvo V60 reliable?
Owners have filed 1 complaint about the 2022 Volvo V60, fewer than a typical V60 model year.
What is the most common problem with the 2022 Volvo V60?
Suspension, with 1 complaint.
How many recalls does the 2022 Volvo V60 have?
3 recalls, covering electrical system, engine and engine cooling and seat belts.
Is there a class action lawsuit over the Volvo V60?
Yes. New class action says Volvo's Google-based infotainment screens freeze and take climate and rearview camera with them (November 9, 2026).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Volvo V60?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history