2008 winnebago on a 2008 w22 workhorse chassis has 26838 miles, required replacement of the front rotors and all of the brake pads. Rotors were actually cracked but not burned requiring replacement *tgw the consumer stated the calipers seized. Also, several brake repair technicians stated the problem was not due to normal failure, but more likely due to the defective calipers. The consumer stated the front seals, rotors, front and rear pads and seal oil cap were replaced. *jb updated 03/10/11.
The worst 2008 Workhorse W22 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes3
- Fuel system1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes3
- Fuel system1
Recalls 1
Service brakes, hydraulic
- What is wrong
- Navistar is recalling certain model year my 2001-2008 workhorse w20, w21 and w22 chassis and certain model year 2009 through 2011 monaco rv admiral, arista, monarch, and riptide recreational vehicles equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.
- Risk
- The temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
- Remedy
- Workhorse dealers will replace all four bosch brake caliper assemblies free of charge. The safety recall began on september 16, 2010. Owners may contact workhorse at 1‑877‑246‑7731.
Recall number 09V110000 · Recall details
What 2008 Workhorse W22 owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 2008 workhorse w22 chassis. The contact stated while exiting a parking lot at low speeds, the brakes were depressed and the pedal fell into the floorboard. The vehicle was towed to an authorized dealer where they advised that the hydraulic fluid had overheated and leaked out of the vehicle. The dealer also advised that it would take approximately five days before the parts needed to repair the vehicle would arrive. Instead, the repairs were performed with the same defective parts that were initially on the vehicle. The dealer advised that the new calipers were not yet available to install on the vehicle. The contact stated he would no longer operate the vehicle until repairs were completed due to the nature of the failure. The contact did not feel safe driving the vehicle. The failure mileage was approximately 10,000. The current mileage was approximately 11,000.
2008 holiday rambler 34'. Consumer states problem with 2008 w22 workhorse gas tank *tgw the consumer stated the chassis has a 75 gallon gas tank and it was designed to be used as a left or right fill. Since his is a left fill, the manufacturer capped the right side. The consumer stated the cap began to leak. Workhorse paid to have the hose replaced. The consumer believed the hose material was never meant to be used for gasoline.
Tl*- the contact owns a 2008 workhorse w22 chassis motor home. While driving at 30 MPH, the contact engaged the brakes and but they would not release. He had to coast to the side of the road. The vehicle was towed to an authorized dealership. The vehicle was not repaired at the time the complaint was filed. The failure and current mileages were approximately 15,800.
Compare the 2008 Workhorse W22
Other model years
Questions about the 2008 Workhorse W22
Is the 2008 Workhorse W22 reliable?
Owners have filed 4 complaints about the 2008 Workhorse W22, fewer than a typical W22 model year.
What is the 2008 Workhorse W22 year score?
The 2008 Workhorse W22 scores 88 out of 100 (good). The score compares it with the other model years of the Workhorse W22: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2008 Workhorse W22?
Brakes, with 3 complaints. Next is fuel system (1).
How many recalls does the 2008 Workhorse W22 have?
1 recall, covering service brakes, hydraulic.
Was there a recall on the 2008 Workhorse W22 brakes?
Yes, 1 recall: 09V110000. Check your VIN to see if your car still needs the free repair.
What year does the Workhorse W22 have bad brakes?
The Workhorse W22 model years with the most brakes complaints are 2003 (111 complaints), 2004 (83 complaints) and 2002 (64 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Workhorse W22?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history