2005 Yamaha FJR1300 problems

Filed Oct 8, 2025 · Acceleration, Electrical · AL · crash · 1 injury

About a month ago I purchased a 2005 Yamaha fjr1300. After purchasing I was out riding when the bike suddenly stalled. Upon reengaging the clutch, the back tire kicked out very hard and caused me to wreck the bike. I sent the bike to Guntersville Power Sports to have the bike fixed. Upon examination by their techs, it was discovered that the bike had a faulty tps sensor, in which not only could be and was the cause of the accident but also was a recall. Yamahas tech said that the tps sensor was faulty and in corridiance of the recall and would fix and replace the tps sensor. But would not fix the damages. The bike wouldn't have received said damages had the bike not had a faulty tps sensor. Therefore making yamaha responsible

Filed May 18, 2019 · Electrical, Engine · 15,000 miles · FL

Ignition switch is intermittent. Sometimes after turning switch to off position then back to the on position, motorcycle will not start and gage have no power. Sometime I may have to turn key on and off fifty or more times and sometimes that doesn't work. Motorcycle has less than 17,000 miles on it and has been garage kept. I've read many other owners having same the same problems.

Filed Oct 4, 2016 · Electrical · 36,500 miles · CA

Tl* the contact owns a 2005 yamaha fjr1300a. While driving approximately 20 MPH, the vehicle suddenly stalled and failed to restart. Upon inspection, the contact determined that the failure was caused by a failed solder connecting wire for the ignition switch. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 36,500. Updated 01/06/2017

Filed Nov 5, 2014 · Brakes · 42,000 miles · FL

Rear anti lock brakes have stopped working. Yamaha says this is a very expensive fix. The motorcycle obviously is out of warranty. It is no longer as safe as it once was.

Filed Jun 11, 2014 · Tires, Wheels · 58,800 miles · OH

Noticed delamination of tire tread of front tire. Two large blisters near the middle of tread. One about 1" dia., the other about 3" long. Tire mileage was 6,129. Tire type is shinko r011 size 120/70/zr17. Date code is 3012. Tire could have catastrophically deflated. Very dangerous defect.

Filed May 29, 2013 · 22,000 miles · PA

I was exiting interstate 81 near harrisburg, pa, when the oem accessory storage trunk fell off the back of the motorcycle. The mounting bracket cracked, allowing this to happen. Thankfully, my passenger did not fall off, as the trunk doubles as a backrest. Also thankfully, there was not a vehicle directly behind me, as this could have caused an accident. The trunk was damaged beyond repair, and I purchased a new one out of pocket. In 2011, I became aware of a bulletin/recall from yamaha. The dealer replaced the mounting bracket and supplied a reinforcement plate for the trunk bottom. Yamaha did not reimburse me for the new trunk purchase.

Filed May 29, 2013 · Electrical · 53,198 miles · PA

I was pulling up to a stop light and lost all power. Diagnosis showed a failed ignition switch. Online investigation indicates yamaha was forced by the federal safety agency to recall 2006-09 fjr 1300 models for this switch failure, and there are a huge number of 2001-05 owners complaining of the same failure. This could, and probably has, LED to injury or death if failure occurs at a higher speed. I was 500 miles away from home at the time, and incurred cost exceeding $500 to get home with the motorcycle.

Filed May 19, 2013 · Electrical · 63,500 miles · NC

Motorcycle abruptly shut off, after diagnosing for an hour determined that it is was the electric ignition / switch. Evidently 2006 models and up have had the same issue and yahama issued a recall, further research show previous models have and are being affected as well.

Filed Nov 16, 2012 · Brakes · 26,352 miles · VA

Abs failed under emergency braking application and the rear wheel locked up, causing a loss of control. Road testing following the incident confirmed that the ABS system was no longer functional.

Filed Sep 7, 2011 · Fuel system · 27,000 miles · CO

This report is in regard to the second event regarding fuel geysering out of the fuel tank. During a refueling stop in gunnison, colorado, I opened the fuel cap. There was a whooshing sound and fuel literally spewed into the air about 3 feet, covering me and most of the motorcycle in gasoline. Prior to opening the tank cap, I estimated about 1/4 tank remaining. It appeared the fuel tank was still under pressure when I opened the tank cap. Looking at the fuel remaining in the tank, I could see the fuel bubbling, not from heat but because the air was coming out of suspension due to the rapid reduction in pressure. Fortunately, there was no spark nearby because the consequences would have been catastrophic for both myself and the gas station. A year before, the same thing had happened. At that time, I attributed it to either an anomaly or something that I had done wrong. After the second event in colorado, I took the bike to a motorcycle shop to get repaired. At the shop, the mechanic indicated that yamaha representatives had never heard of this problem before, even though a five minute search on the yamaha fjr1300 internet forums indicated that this was not an isolated event. Troubleshooting determined that the vent on the fuel cap assembly was venting much too slowly and required replacement of the entire fuel cap assembly. I would respectfully recommend that this information be provided to all fjr1300 owners because of the potential for serious personal injury. I had written yamaha headquarters in california regarding this issue a few weeks ago but have received no response. A copy of this letter is available upon request.