2014 BMW 328D: check engine light

Filed May 11, 2026 · Fuel system · CA

1.) The Bosch CP4 High-Pressure Fuel Pump (HPFP), OEM part number 13517824477 / 0445010517, failed catastrophically. This is the factory-installed pump on the 2014 BMW 328d equipped with the N47 diesel engine. Upon failure, the pump's internal cam and roller assembly disintegrated, releasing metal shavings throughout the entire fuel system — contaminating the fuel lines, injectors, fuel rail, and fuel tank. The vehicle will not start. The failed pump and contaminated fuel system components are available for inspection upon request. 2.) The vehicle experienced a sudden, complete loss of motive power with no prior warning, rendering it unable to start or operate. This type of failure — as documented in the federal safety agency Engineering Analysis EA23-001 — is known to also occur while the vehicle is in motion, causing unexpected engine stall at highway speeds with no ability to restart. This creates an immediate risk of rear-end collision, loss of vehicle control, and danger to other motorists. The failure provides no warning to the driver and cannot be prevented through normal maintenance practices. 3.) Yes. The high-pressure fuel pump failure and presence of metal shavings throughout the fuel system have been confirmed by a BMW authorized dealership. The dealer has documented the failure and provided a repair estimate for full fuel system replacement — including the HPFP, injectors, fuel lines, and tank cleaning — at an estimated cost of $10,000–$15,000. BMW of North America has declined warranty coverage citing that the vehicle has exceeded the 120,000-mile threshold under Recall 21V‑586, despite this being the identical defect covered by that recall. 4.) Yes. The vehicle has been inspected by a independent BMW Specialist 5.) Check engine light was present

Filed Mar 20, 2026 · Fuel system · MD

The fuel system has failed. The car shut off in the Baltimore harbor tunnel twice completely stopping traffic and creating a very hazard situation. One of those two times the semi truck behind me had to slam its brakes. When the car shuts off you must come to a complete stop and turn the car completely off. After restarting the car is in limp mode with reduced power. The incident has happened about 6 other times. Every time it happens I have feared my safety, especially if there is no shoulder to coast the car in to park. Independent service center has replaced three sensors related to fuel pressure system which did not fix. The vehicle and component has not been inspected by manufacture, police, insurance representatives or others. The manufacture claims there are no recalls on the fuel system of the vehicle. The vehicle has a rebuilt title from a small accident because no parts were available during covid so the insurance wrote the car off. The car was inspected by the state of North Carolina and deemed safe for the road. There is no indication that the car is going to shut off. It just cuts power and shuts off. After restarting the car, it will show a check engine light on the cluster and a drivetrain error on the infotainment screen . The error code p0087 Fuel/rail system Pressure - too low bank 1

Filed Aug 4, 2025 · Fuel system · 140,000 miles · FL

The contact owns a 2014 BMW 328D. The contact stated that the vehicle was taken to an unknown dealer, where the oil filter housing was replaced due to an oil leak. After the repair, the contact drove to the residence and the vehicle was not driven the following few days. The dealer called the contact to inquire updates on the vehicle after the service. The contact stated that the check engine warning light was illuminated. The vehicle was taken back to the dealer, where a diagnostic trouble code for the fuel rail sensor was retrieved. Upon inspection, the mechanic discovered metal inside the fuel system due to the high-pressure fuel pump failure. Upon investigation, the contact related the failure to the federal safety agency Campaign Number: 21V586000 (Fuel System, Diesel); however, the VIN was not included in the recall. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 140,000.

Filed May 8, 2025 · Engine · CA

a check engine light came on codes say it's the EGR valve and cooler dealer states since recalls are vin related there was not much they can do recall states its based by manufactured day not vin

Filed May 7, 2025 · Engine · CA

Check engine light came on and codes suggest it's the egr valve and cooler may be leaking

Filed Nov 18, 2024 · Fuel system · NV

While driving our 2014 BMW 328d the engine misfired then stalled on the highway. This was a very dangerous and frightening scenario trying to push it off of the roadway while my wife and children were inside the car while highway traffic on the I-15 interstate rushes by. I was not able to restart, so we had it towed to our local BMW shop. Diagnosed as High Pressure Fuel Pump complete failure. Metallic debris throughout the entire fuel system, lines, tank filter, injectors, pumps. No check engine light or any prior warning. Many of the components have already been disassembled to determine the extent of damage, and all the components are currently with the vehicle, and available for inspection. The vehicle has been at the shop since the end of June. Some parts were initially ordered then all repairs put on hold while awaiting direction/ recall approval from BMW of North America. 5 months later we are being told this vin does not qualify for the safety recall. We can not afford the cost of the repairs and they will likely exceed the value of the car. We also need to remove it from storage at the shop it was towed to, and take it somewhere else while this is sorted out.

Filed May 8, 2023 · Fuel system · 92,000 miles · CA

The contact owns a 2014 BMW 328D. The contact stated that on several occasions while driving at various speeds, the vehicle stalled and lost motive power. The vehicle failed to restart. The vehicle was towed to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced again. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer to be serviced under the federal safety agency Campaign Number: 21V907000 (Fuel System, Diesel). The vehicle was repaired; however, the contact stated that the failure reoccurred while driving at an undisclosed speed, and the check engine warning light was illuminated. The vehicle was taken back to the dealer, where it was diagnosed that further inspection of the high-pressure fuel pump was required. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 92,000.

Filed Apr 15, 2023 · Engine · FL

From purchasing this vehicle form Autohaus of Orlando, there was no such mention of this open safety recall at all. In fact, I believe the Check Engine Light had been tampered with, as it was not on, but immediately came on a couple days later. On the CARFAX, it is listed as a Manufacturer Safety Recall on 11/19/2021: "- Recall #21V‑907:404 - EXHAUST GAS RECIRCULATION (EGR) COOLER - Status: Remedy Not Available - Need more information about this recall? Find an authorized BMW dealer, email [email protected], or call 1-800- 525-7417" 200 miles from the car dealership, the car broke down as it was rapidly leaking engine coolant, it was inoperable and ran very hot, creating the potential cause of a fire. I had to take it to the nearest BMW dealership, which was BMW of Albany in Albany, GA. They fixed the coolant leak hose, which appears to be related to the open recall, and made note of the open recall. But did nothing to fix it. It was one day after the service from their shop where the check engine light came on, and I asked them about it, and Caroline from BMW Albany said: "Spoke to the technician, it says it is probably related to the recall for your vehicle that there isn't a fix for (the open recall you and I had discussed on the vehicle)- he says you could clear the code but it would probably just come back on with time. He says its also difficult to tell from that fault code --Caroline Eva BMW of Albany" I asked "what should I do about it" and got no response back. Message even says "read" On 8/31/2022, I took it into Fields BMW in Daytona Beach, FL for a separate service, and they did not fix this issue either. On it states the following: "If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner, please contact the federal safety agency Vehicle Safety Hotline at: 1‑888‑327‑4236 or TTY: 1‑800‑424‑9153 or file an online complaint with the federal safety agency." There has been no remedy in over a year and a half.

Filed Sep 8, 2022 · CO

Diesel Emissions System is producing an error code due to incorrect coding by the manufacturer for US grade Diesel fuel. Check engine light has come on. There are warranties out for the model years just slightly older than mine. I have read many threads with people talking about having the same issue.

Filed Apr 22, 2022 · Fuel system · 75,000 miles · ME

The contact owns a 2014 BMW 328D. The contact received notification of the federal safety agency Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that an unknown sensor had malfunctioned. The vehicle was not repaired. The dealer was made aware of the issue but confirmed that parts were not yet available. The manufacturer was made aware of the failure but confirmed that parts were not yet available. The failure mileage was approximately 75,000. VIN tool confirms parts not available.

Filed Mar 22, 2022 · Acceleration, Engine · 89,000 miles · TX

The contact owns a 2014 BMW 328D. The contact received notification of the federal safety agency Campaign Number: 18V755000 (Engine and Engine Cooling). The contact stated that while driving 60 MPH, the vehicle inadvertently decelerated to 40 MPH. The check engine warning light was illuminated. The EGR cooling message was displayed in the information center. The vehicle was taken to an independent mechanic where she was informed about fault code 29EB-00. The vehicle was taken to the local dealer however, the mechanic was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 89,000.

Filed Mar 21, 2022 · Fuel system · 97,396 miles · NY

The contact owns a 2014 BMW 328D. The contact stated while driving at 20 MPH, the vehicle started shuddering. The check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the Exhaust Gas Recirculation (EGR) valve needed to be replaced. The contact stated that the vehicle was repaired; however, the failure reoccurred 6 months later. The vehicle was taken back to the independent mechanic who repaired the Exhaust Gas Recirculation (EGR) valve for a second time; however, the failure persisted. The independent mechanic informed the contact that the failure was associated to an unknown Technical Service Bulletin. The vehicle was taken to the dealer who informed the contact that the parts for repair were not yet available. The contact later received notification of the federal safety agency Campaign Number: 21V907000 (Fuel System, Diesel) that stated that the parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 97,396. VIN tool confirms parts not available.