2014 BMW 328D: engine overheating

Filed Feb 3, 2026 · Engine, Fuel system · FL

The primary failure involves the EGR cooler system covered under Recall 21V‑907, with consequential damage to the intake system, including intake air leaks, charge pipe failure, displaced turbo-to-DPF V-band clamp, brittle/cracked fuel lines, and intake system integrity loss. Yes — the vehicle and all affected components are available for inspection upon request The EGR cooler internal leak defect and intake system failures create risk of engine overheating, thermal degradation, loss of engine power under boost, exhaust gas leakage, and potential fire hazard, which can cause unsafe driving conditions and sudden loss of vehicle performance The vehicle was presented to a BMW dealership, and the recall defect was acknowledged. The dealer confirmed that any decisions regarding inspection and repair must come from BMW corporate. The dealership refused to inspect or evaluate the recall-related failures pending corporate authorization. No. BMW of North America has not authorized inspection or evaluation. The dealership also refused to inspect the vehicle pending corporate direction. Yes. Symptoms included audible air leaks, intake pressure loss under boost, performance degradation, and component failures occurring both before and after recall repair attempts. These symptoms developed during the period when the vehicle was operating under a known recall-defect condition and continued after recall repair.

Filed May 27, 2023 · Engine · FL

While driving on the freeway at a high rate of speed in Pensacola, FL, my 2014 BMW 328d broke down. After several attempts to restart, the car was started in "limp mode" and we took it to a certified independent BMW mechanic, but could only drive at about 20mph in traffic with hazard lights flashing. Multiple error codes / mechanic inspection diagnosed a malfunction of the exhaust system overheating, which was melting the intake manifold. We towed the car the BMW dealership in Fort Walton Beach, FL. The service technician confirmed the problem in writing, "The tech did find the intake melted." Also, the vehicle had been losing coolant for several weeks, but the coolant was not dripping onto the ground, indicating a leak within the system. Here is where my problems begin. There are several recalls and an extended warranty that would would fix the issue, as the independent mechanic told me. They are: 1) Recall Campaign 18V‑755: Exhaust Gas Recirculation (EGR) Cooler Inspection; 2) Recall 21V‑907: Exhaust Gas Recirculation (EGR) Cooler N57T High Temperature; 3) SIB 01 05 20: N47T/N57T EGR Cooler Ltd Wty Extension to 10 years without mileage limit. My car was built to US spec, and sold via U.S. Military sales in Germany (I'm Active Duty USAF). I was relocated to Florida, and brought the car with me. When this happened, I was told to register my car with BMW North America to get into their warranty validation system, and I did so. However, my car does not show up as needing any recalls or warranty work, likely because it was sold in Europe. As such, the dealer wants me to pay in excess of $3,000 to fix the problem. Both an independent mechanic and dealer technician have identified the previously-known safety problems as the cause of my car's breakdown on the freeway. I am in desperate need of help to get this fixed, as I've had to rent a car for weeks, and multiple calls to BMW North America and dealership visits have produced zero progress.

Filed Apr 15, 2023 · Engine · FL

From purchasing this vehicle form Autohaus of Orlando, there was no such mention of this open safety recall at all. In fact, I believe the Check Engine Light had been tampered with, as it was not on, but immediately came on a couple days later. On the CARFAX, it is listed as a Manufacturer Safety Recall on 11/19/2021: "- Recall #21V‑907:404 - EXHAUST GAS RECIRCULATION (EGR) COOLER - Status: Remedy Not Available - Need more information about this recall? Find an authorized BMW dealer, email [email protected], or call 1-800- 525-7417" 200 miles from the car dealership, the car broke down as it was rapidly leaking engine coolant, it was inoperable and ran very hot, creating the potential cause of a fire. I had to take it to the nearest BMW dealership, which was BMW of Albany in Albany, GA. They fixed the coolant leak hose, which appears to be related to the open recall, and made note of the open recall. But did nothing to fix it. It was one day after the service from their shop where the check engine light came on, and I asked them about it, and Caroline from BMW Albany said: "Spoke to the technician, it says it is probably related to the recall for your vehicle that there isn't a fix for (the open recall you and I had discussed on the vehicle)- he says you could clear the code but it would probably just come back on with time. He says its also difficult to tell from that fault code --Caroline Eva BMW of Albany" I asked "what should I do about it" and got no response back. Message even says "read" On 8/31/2022, I took it into Fields BMW in Daytona Beach, FL for a separate service, and they did not fix this issue either. On it states the following: "If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner, please contact the federal safety agency Vehicle Safety Hotline at: 1‑888‑327‑4236 or TTY: 1‑800‑424‑9153 or file an online complaint with the federal safety agency." There has been no remedy in over a year and a half.

Filed Feb 5, 2020 · CA

Blower motor which controls air flow for heating and A/C system , the connection between the wiring and the blower motor is deteriorated ,this is leading the blower to only blow hot air at all times even when the A/C is on also might be overheating the car. Please look into this matter

Filed Feb 2, 2019 · Engine · 72,114 miles · CA

Car has gone thru numerous service calls for coolant leak, pressure testing & burnt oil smell & vapor fume coming inside the cab when engine reaches the operating temperature!! Makes the car not drivable!! After oil filter housing, cylinder cover & gasket change, there is still a visible burnt oil smoke coming from rear & sides of the engine area, best seen under a flash light after dusk! This is been going on since june 2018 & presently car is in the shop for repair again!!

Filed Feb 2, 2019 · Engine · 79,000 miles · FL

The exhaust gas recirculation cooler is not working. When I drive it, it begins to overheat and each time I add coolant throughout the day, it leaks or burns out rapidly.

Filed Sep 30, 2018 · Engine · 62,000 miles · WA · fire

Egr valve locked open, as sediment accumulated in the vacuum line from the leaking of anti-freeze into the valve. Manifold developed holes, as the egr overheated due the valve locking open. The smell of anti-freeze and diesel filled the car as smoke started coming from the engine, while I was driving on the freeway. Had to have the manifold replaced, as the manifold had four holes in it, and the egr valve vacuum line had to be cleared. Reported the issue to kuni bmw, who never reported the issue and warned me to not drive the car in the condition that it was in before the repair. Kuni also said that they had never heard of an egr valve issue and anti-freeze causing sediment to plug the vacuum line. This is the same issue that bmw has had to issue a recall for 2015-2017 models in europe and s. Korea. Kuni bmw knew of the recalls in s. Korea and europe when they talked to me. I am reporting this to ntsb, as bmw na told me that they had only made a informal report to ntsb, and they felt it was not a major issue. My car almost caught on fire and burned, while my pregnant wife and daughter were riding with me, but kuni refused to report it and bmw didn't consider it a big issue. Sad. Bavarian autoworks in vancouver, wa did the repair work. Recall should be extended to the 2014 models. As of today, I have reached out to the local news anchor on fox 12, as she also has a 2014 bmw diesel.