1. Vanos Bolts recall. the federal safety agency Recall 23V‑707. Cause the car the have a rough idle, check engine light, car to stall, and cut off in traffic all with seconds. Dealership says it was not the Vanos Bolts that cause the shutdown, but it is the DME and ICM. 2. The safety of myself and my 15 year old daughter was at risk, along with the drivers on the highway. The car stopped in traffic, and would not release out of park to go in neutral. 3. State Trooper came to call a tow truck, the car was inspected by BMW of Irondale. 4. No warning lamps, messages or other symptoms prior to the failure. The car was driving as normal, a sudden rough idle, light came on, and the car cut off in ongoing traffic, with not warning before.
BMW 528I check engine light comes on
67 of the 833 owner complaints about the BMW 528I describe check engine light, most of them for the 2011 model year.
- owner complaints
- 67
- worst model year
- 2011
- typical mileage
- 103,000
Is there a fix? There are 2 recalls for this area of the car. See below
By model year
Often reported together
Stalling 20Fire or smoke 11Loss of power 8Jerking 6Hesitation 5Engine failure 5Fuel pump 4Overheating 3
Trouble codes mentioned
P17E1 1P0597 1P0087 1
What owners say
car was brought in for a recall could erupt fire from engine and electrical brought car to bmw 8/2025 have checked list when brought in car was in perfect condition per bmw .pick up car checked engine light was on brought back immediately manager took to shop and cleared light immediately came back on i called them then i drive screen was saying low coolant oil low drivetrain overheating oil leaks burning smell coolant smell etc called bmw na service manager etc waited for appointment 1/26 bmw had for 8 days only to say it had nothing to do with recall car now has no power excessive smoke smell undriveable been in garage for 3 months if ran would catch on fire 🔥
The contact owns a 2010 BMW 528I. The contact stated that the vehicle was repaired under the federal safety agency Campaign: 23V707000 (Engine and Engine Cooling); however, the repair failed to prevent a failure. The contact stated that while attempting to start the vehicle, there was an abnormally loud rattling sound coming from under the hood. The check engine warning light was illuminated. The contact stated that while driving at an undisclosed speed in Manual Mode, the vehicle independently shifted to neutral(N), the steering wheel became firm, and the transmission failed to shift out of neutral. In addition, the contact stated that while attempting to accelerate from a stop, the vehicle hesitated while accelerating with the accelerator pedal depressed. The contact stated that the vehicle was towed back to the same local dealer on various occasions; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.
engine light stays on. had it looked at by mechanic. told the issue is the valtronic actuator. car cuts off when idling. starts back up and drives, when I come to a stop light/stop sign car cuts off again. have contacted BMW North America and a dealership, keep getting the runaround. refer me back to each to contact.
The contact owns a 2011 BMW 528I. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated, and the vehicle stalled. The contact pulled over, and after several attempts, the vehicle restarted. The contact was able to restart the vehicle, and the message "Drivetrain Malfunction" was displayed. The contact stated that the failure started recently and had occurred several times. Additionally, the vehicle was vibrating intermittently and lost motive power. The contact stated that occasionally the vehicle failed to accelerate above 15 MPH. The contact smelled the odor of gasoline inside the vehicle. The contact stated that the check engine warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.
The contact owns a 2015 BMW 528I. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that after driving approximately 2 hours or more, there was smoke coming from underneath the hood of the vehicle and entering the cabin of the vehicle. The contact would pull over to a safe location and park for approximately an hour before continuing to drive. The failure was persistent and recurred after driving for approximately 2 hours or more. The check engine warning light was illuminated. The vehicle was taken to a certified mechanic, who diagnosed a failure with the water pump. The mechanic replaced the ignition coils twice. The contact stated that one coil was replaced the first time, and the entire four ignition coils were replaced the second time however, the failure persisted. The vehicle was taken to the dealer and the dealer related the failure to the recall; however, the part was not yet available. The manufacturer was notified of the failure and confirmed that parts were not yet available. The failure mileage was approximately 80,000.
The contact owns a 2015 BMW 528I. The contact stated that upon starting the vehicle, the engine warning light illuminated. The contact stated that the vehicle was taken to an independent mechanic who determined that the vehicle had experienced coolant failure. The vehicle was repaired. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 74,860. VIN tool confirms parts not available.
The contact owns a 2014 BMW 528I. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated. The contact stated that upon scanning the vehicle with a scanner, the contact retrieved DTC: P0597. The local dealer was contacted. The vehicle was diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000. VIN tool confirms parts not available.
The contact owns a 2014 BMW 528I. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, there was smoke coming from the engine. The check engine warning light was illuminated. The contact drove to the residence and turned off the vehicle. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000. VIN tool confirms parts not available.
The contact owns a 2015 BMW 528I. The contact stated that while driving at various speeds, the vehicle stalled with the check engine warning light illuminated. The vehicle was initially taken to a dealer where a diagnostic test was performed, and the diagnostic test showed that the fuel rail system was defective and needed to be replaced. The contact had the vehicle repaired; however, several days later, the failure returned while traveling at highway speeds; the drivetrain maintenance message was displayed, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and was diagnosed with a defective fuel pump. The vehicle was towed to another independent mechanic, and it was discovered that the vehicle was leaking oil and the valve cover gasket needed to be repaired. The vehicle had received a valve cover gasket repair, but the failure persisted. In addition, the manufacturer was notified about the failure, and the contact was informed that the vehicle was included in the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact was informed by the manufacturer that issue was not related to the recall. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 98,000. VIN tool confirms parts not available.
Related recalls
Engine and engine cooling: exhaust system: emission control: crankcase (PCV)
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
- Risk
- An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
- Remedy
- BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 17V683000 · Recall details
Engine and engine cooling: engine
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
- Risk
- If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1‑800‑525‑7417.
Recall number 14V176000 · Recall details
Questions about the BMW 528I check engine light
Why does the check engine light come on in the BMW 528I?
Owners who report it most often also describe engine stalls while driving, fire, smoke or burning smell and sudden loss of power, and the codes they mention most are P17E1, P0597 and P0087.
Which BMW 528I years have check engine light problems?
The model years with the most reports are 2011 (21 complaints), 2013 (10 complaints) and 2008 (8 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used BMW 528I?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history