Fuel gauge stopped responding, leading to running out of fuel while moving. This is a common failure on many bike models from bmw from 2005-2013.the fuel level measuring strip in the fuel tank was replaced by the dealer04. This is an unsafe condition since loss of engine power from running out of fuel can be quite dangerous on a motorcycle
2007 BMW R1200 RT: wrong fuel gauge reading
10 of the 52 complaints about the 2007 BMW R1200 RT describe wrong fuel gauge reading.
- owner complaints
- 10
- of this car's complaints
- 19%
- typical mileage
- 39,287
- recalls
- 2
Is there a fix? There are 2 recalls for this area of the car. See below
Wrong fuel gauge reading by model year
What owners say
Fuel gauge stopped responding, leading to running out of fuel while moving on a city street. This is a common failure on many bike models from bmw from 2005-2013. I have had this happen 1 time so far, and each time the fuel level measuring strip in the fuel tank was replaced. This is an unsafe condition since loss of engine power from running out of fuel can be quite dangerous on a motorcycle.
Fuel gauge stopped responding, leading to the possibility of running out of fuel while moving. This is a common failure on many bike models from bmw from 2005-2013. I have had this happen 2 times so far, and each time the fuel level measuring strip in the fuel tank was replaced. This is an unsafe condition since loss of engine power from running out of fuel can be quite dangerous on a motorcycle.
Fuel gauge stopped responding, leading to the possibility of running out of fuel while moving. This is a common failure on many bike models from bmw from 2005-2013. I have had this happen 3 times so far, and each time the fuel level measuring strip in the fuel tank was replaced. This is an unsafe condition since loss of engine power from running out of fuel can be quite dangerous on a motorcycle.
Sirs, I am the original purchaser/owner of a bmw r1200rt motorcycle, VIN# [xxx]. I have had to replace the fuel gauge sensor (part # 16147675547 - sensor and # 16117677883 - gasket) three times already. Now it has failed again. This is the 4th time it has needed to be replaced in 6 years. I contacted my dealer (bmw motorcycles of countryside il) and spoke with service manager [xxx]. [xxx] informed that my last fuel sensor replacement was 27 months ago and therefore it will not be covered under warranty (24 month), despite it having failed and been replaced multiple times and despite the fact that the motorcycle has less than 14,000 miles on it. He then estimated it would cost me $350 to replace the sensor. If this was the first time I had to replace the sensor, I would unhappily pay the $350 and attribute it to the motorcycle being 7 years old as the mileage is negligible. But this is not the case. This part has repeatedly failed. [xxx] acknowledged that this is a widespread and recurrent problem. My own research indicates that multitudes of bmw r1200 model motorcycle owners have also been experiencing multiple and repetitive fuel sensor failures for many years. This issue is documented under the federal safety agency id # 10033130 and bmw service bulletin no. Sib-16-02-09. This r1200rt is the most expensive motorcycle I have ever purchased. I find it unconscionable that bmw expects me to pay the full replacement cost of a part that has required multiple replacements over the course of 14,000 miles, a part that obviously is the subject of an inherent design/manufacturing flaw. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Yet another fuel level sensor strip [fuel gauge] failure. This is number 6. Now no longer covered and cost $350 to replace at the dealer - 250 miles from my home. I think this is a safety issue because here in the western us where it's possible to travel over 100 miles without seeing another smiling face, running out of fuel is a serious threat to your safety.
My motorcycle ran out of fuel while indicating 1/2 full on the fuel gauge. I was on a busy us highway and had to coast to the soft shoulder of the road, where the bike almost tipped over into the traffic lane when the kickstand sunk into the soft ground. Fortunately another biker had a hose and we were able to siphon enough fuel using a coke can for me to make it to a gas station. Since that time the gauge has always indicated no less than 1/2 tank, even when empty. This is a safety hazard in particular for someone on 2 wheels. A sudden loss of power at lower speeds could have resulted in the bike tipping over in the roadway, causing injury to me & endangering me and others. Since that time I have learned that many other bmw riders are having the same problem, and that bmw denies the existence of this problem.
Fuel gauge read 3/4 tank of gas and vehicle fuel tank was empty - had to walk home.
The plastic electric fuel pump has developed cracks around a high pressure output fitting that carries fuel to the fuel injection system. It is possible to smell gas fumes around this area of the vehicle. There are stains on the pump that confirms the fuel leak. This leaky fitting is located within two inches of various electrical connectors used for engine management functions (fuel level, etc). All it takes is for a spark from these connectors to ignite gas fumes from the leaky connector to cause a vehicle fire. This is a fire hazard that could endanger the life of the driver as well as the vehicle itself. Most motorcycles are stored in closed garages and there is the potential of a fire, property loss or loss of life or an explosion if a motorcycle with this defect is parked nearby a gas water heater.
The fuel sensor on my 2007 bmw r 1200 rt failed while I was riding it causing the fuel gauge to read empty. This could cause a person to run out of gas at anytime. This has occurred to numerous other bmw r bikes and is a problem bmw is well aware of.
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V‑617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.
- Risk
- A fuel leak in the presence of an ignition source can increase the risk of a fire.
- Remedy
- BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 20V471000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.
- Risk
- A fuel leak in the presence of an ignition source may result in a fire.
- Remedy
- BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1‑800‑525‑7417 or email BMW at [email protected].
Recall number 13V617000 · Recall details
Questions about the 2007 BMW R1200 RT fuel gauge
Is wrong fuel gauge reading a common problem on the 2007 BMW R1200 RT?
10 of 52 owner complaints about the 2007 BMW R1200 RT (19%) mention wrong fuel gauge reading. The model year with the most reports is 2007.
Is there a recall or service bulletin for this on the 2007 BMW R1200 RT?
There are 2 recalls and 0 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2007 BMW R1200 RT
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 BMW R1200 RT?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history