2021 BMW X5: engine overheating

Filed Nov 3, 2026 · Electrical · TN

The alternator terminal post overheated and broke off. The terminal post from the alternator broke off inside the middle of the cable eyelet and had welded itself to the end of the power cable. The cable showed signs of being overheated and melted. The power cable was loose and dangling next to the alternator creating a serious fire risk while driving. When this issue occurred I got a vague message indicating a power related failure and then BMW Roadside immediately called my vehicle asking me to pull over or take it to a service center. I immediately took it to the shop that services my vehicle and they documented the issue and informed me of the safety recall that mentions this specific issue. This is the exact problem related to the federal safety agency Recall 20V‑761 though BMW has told me that my specific VIN is not covered. I also understand that this recall has been extended additional porduction dates more than once. I believe my vehicle is an example of later production models built in 2021 that are still at risk for this issue and should also be recalled.

Filed Sep 23, 2026 · Electrical, Engine · FL

My 2021 BMW X5 xDrive40i intermittently fails to start, occurring on approximately 80% of start attempts, and displays the message "Repeat Start Attempt." This has been confirmed by code reading to be a starter-related malfunction. This defect significantly affects vehicle reliability and raises a potential safety concern. BMW previously recalled vehicles equipped with similar starter motors due to starter solenoid defects that could cause overheating, electrical short circuits, and an increased risk of vehicle fire. The symptoms on my vehicle appear consistent with those associated with the previously identified defect. I respectfully request that the federal safety agency investigate whether the starter motor defect previously addressed through BMW recalls extends beyond the identified production range, including 2021 model year vehicles. The recurring failure, similarity to previously recalled defects, and potential fire hazard warrants further review.

Filed Sep 21, 2026 · Electrical, Transmission · TN

My 2021 BMW X5 xDrive40i Sport (112,000 miles) intermittently fails to start, occurring on approximately 80% of start attempts, and displays the message "Repeat Start Attempt." The issue first occurred on September 8, 2026, while the vehicle was parked at my residence and was confirmed by BMW Roadshow Memphis on September 11, 2026, as a starter-related malfunction. The dealer quoted more than $1,600 to replace the starter motor because the vehicle is outside the warranty period. This defect significantly affects vehicle reliability and raises a potential safety concern. BMW previously recalled vehicles equipped with similar starter motors due to starter solenoid defects that could cause overheating, electrical short circuits, and an increased risk of vehicle fire. The symptoms on my vehicle appear consistent with those associated with the previously identified defect. Publicly available recall information indicates BMW's corrective action included software modifications intended to reduce current flow through the starter system. However, this appears to be a mitigation measure rather than a correction of the underlying hardware defect. I contacted BMW North America seeking assistance and clarification regarding the similarity between my vehicle's failure and the previously recalled condition. I was informed that my vehicle is not included in the recall population, and no resolution was offered despite my attempts to escalate the issue. I respectfully request that the federal safety agency investigate whether the starter motor defect previously addressed through BMW recalls extends beyond the identified production range, including 2021 model year vehicles. Specifically, whether these vehicles may contain the same defective components, whether the software remedy addresses the root cause, and whether additional vehicles should be included in an expanded recall. The recurring failure, similarity to previously recalled defects, and potential fire hazard warrant further review to protect ve

Filed May 19, 2026 · Engine · SC

After the car was.parked in sun for aome time during shopping at Costco, it did not start. We had to use remote starter which worked. However, upon doing some research I found that overheated starter is a known and recalled problem with 2021 X5 and remote start could have caused fire. Dealership also confirmed it to be the smae pronlem , but BMW has not listed this vin as recalled. I contacted BMW and they denied that it was same.problem, although mine is also 2021 X5 with smae.overheated starter problem.

Filed Oct 16, 2025 · Engine · 40,000 miles · TX

The contact owns a 2021 BMW X5. The contact stated that while driving at an undisclosed speed, the coolant warning light illuminated with the message "Coolant Dangerously Low - Fill Right Away" displayed on the instrument panel. The message was displayed on several occasions. The vehicle was taken to a dealer where the dealer discovered coolant leaking from the bottom of the vehicle and diagnosed that the water pump needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was no longer under warranty. The failure mileage was approximately 40,000. The VIN was not available.

Filed Sep 23, 2025 · Engine, Transmission · VA

Component Failed: Water pump (engine cooling system) - Part has been superseded by BMW with upgraded version, indicating manufacturer awareness of defect. Failed component retained and available for inspection upon request. Safety Risk: Complete water pump failure at 56,611 miles created immediate risk of catastrophic engine overheating and potential engine seizure while driving. BMW-certified mechanic warned that driving vehicle even short distances could result in total engine failure, creating risk of: Sudden loss of power on highways/intersections Engine fire from overheating Being stranded in dangerous locations/conditions Complete loss of steering assist if engine stops Confirmation: BMW-certified independent mechanic (formerly employed by BMW) confirmed water pump failure and identified it as "common B58 engine issue." BMW dealer (Silver Spring) immediately quoted exact repair cost of $2,300, indicating familiarity with this failure pattern. Mechanic documented that BMW has superseded the original part with an upgraded design, suggesting manufacturer acknowledgment of defect. Inspection Status: Failed part preserved by mechanic with full documentation including BMW's superseded part number from their system. Vehicle not inspected by BMW due to dealer network failure - three dealers failed to respond, one took 5+ hours to return call, none could provide service in reasonable timeframe. Warning Signs: No prior warning symptoms. Failure was sudden and catastrophic. Temperature gauge spiked without warning during normal driving conditions. No previous cooling system issues or warning lights. Regular maintenance performed per BMW specifications. Additional Pattern Evidence: Research reveals extensive documentation of identical B58 engine water pump failures between 40,000-60,000 miles across multiple BMW models (X5, X3, 3-series, 5-series) on owner forums. BMW's decision to supersede the part without issuing a recall suggests they are aware of the defect.

Filed Jan 7, 2025 · Engine · 80,000 miles · NC

The contact owns a 2021 BMW X5. The contact stated that the vehicle was taken to a local dealer for an oil change and the contact was informed that there was coolant leaking from the water pump and that the water pump needed to be replaced to prevent further damage to the internal components of the engine. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.