2017 Chevrolet Bolt EV: lane keeping assist jerks the wheel

Filed Aug 22, 2026 · Steering · CA

COMPONENT: Electric power steering (EPS) steering gear / rack and pinion assembly. WHAT HAPPENED: The steering gear binds internally. After a turn the wheel does not return to center and must be forced back to straight; steering feel is stiff and clunky. On at least one occasion the wheel felt stuck in place partway through a turn and I had to fight it to finish the maneuver. I nearly lost control of the vehicle. Exact date, location and speed of that incident: UNKNOWN. The condition is chronic and has worsened over time. I own two Bolt EVs (2017's); both have this defect and I am filing a separate complaint for each. Mileage on this vehicle: approx 96,000 but it's been bad since 80,000 (at the very least). SAFETY RISK: Binding steering requires manual correction after every turn, increasing risk of overcorrection, unintended lane departure and delayed emergency response. Worst at intersections, on/off ramps and parking lots. The driver cannot anticipate when the wheel will stick. WARNING LAMPS / PRIOR SYMPTOMS: [No warning lamps, messages or codes appeared] Earliest symptom: [stiff or notchy steering]. First noticed [right away when I bought the car used]. CONFIRMED BY DEALER OR SHOP: [not yet presented] INSPECTED BY MANUFACTURER, POLICE OR INSURANCE: No. AVAILABLE FOR INSPECTION: Yes — vehicle and original steering gear assembly. This failure is widely reported across Bolt EV and EUV model years. GM service information contains a diagnostic procedure for poor return of the steering wheel, indicating the manufacturer is aware of it. No safety recall has been issued, and dealer repair runs $2,500-$3,500 because the subframe must be lowered to reach the rack. Videos of the repair are available online, which also include plenty of discussion about the symptoms and dangers: [XXX] and [XXX] I request that the federal safety agency open an investigation into the Bolt EV/EUV steering gear as this should 100% be a priority safety recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 20, 2025 · Steering · CA

The steering wheel intermittently sticks and fails to return to center after turns or minor corrections, especially at low to moderate speeds. This requires constant manual correction to re-center the vehicle, which increases the risk of overcorrection or unintended lane departure. There are no warning lights or noise, and the issue does not appear to be related to alignment, tires, or pressure. Many other Chevy Bolt owners are reporting the same behavior, pointing to a potential defect in the steering gear or rack. This is a serious safety hazard that could result in loss of vehicle control. GM has not issued a recall or service bulletin, and repairs are expensive. See community reports here: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 4, 2025 · Steering · FL

When corning the steering wheel intermittently sticks and fails to return to center after turns, at any speed but especially at low to moderate speeds. This requires me manually turn the wheel to re-center the vehicle, which increases the risk of overcorrection or unintended lane departure. There are no warning lights or noise, and the issue us not appear to be related to alignment, tires, or tire pressure. Many other Chevy Bolt owners are reporting the same behavior. This leads me to believe that this is a potential defect in the steering gear or rack. This is a safety hazard that could result in loss of vehicle control. GM has not issued a recall or service bulletin, and repairs are expensive.

Filed May 3, 2025 · Steering · NC

While driving, especially at lower speeds or during small steering inputs (such as switching lanes), the steering wheel does not return to center as expected. Instead, it sticks in the turned position, requiring extra effort to manually re-center the wheel. This issue is intermittent but persistent, and worsens over time. It appears to originate from the steering gear/rack, as there is no abnormal noise or warning lights. The car does not exhibit issues with alignment or tire wear, and tire pressure is within recommended specs. This behavior creates a safety hazard, as the driver must constantly correct the wheel back to center, especially after turns or curves. This introduces risk of overcorrection, lane departure, or delayed reaction in emergencies. Multiple other Bolt owners are reporting similar symptoms in this owner forum thread, suggesting a potential defect in the steering gear or electric steering system. GM has not issued a recall or service bulletin on this yet, and repair costs are substantial out-of-pocket. This issue could result in loss of control if it worsens. Please investigate.

Filed Sep 1, 2023 · Driver assistance, Electrical · CA

My vehicle, an a whole host of others according to other owners online, have an issue with defective sealing in the rear bumper and underbody of the vehicle which allows water to enter, flooding the trunk which fries the electrical harness and audio system. As a result, all warning systems including the Forward Collision Warning, Lane Departure Warning, Parking Collision Warning, Rear Cross Traffic Warning, turn signals, emergency lights, door ajar warning, and vehicle status warning systems are inaudible. This is not just a nuisance of not having an audio system but posses great danger to the driver, their passengers and others on the road as warning systems cannot be heard. In addition, the wiring harness affects other critical components on the car and considering this is an all electric vehicle, this is of great concern. Chevrolet is well aware of the issue but either instructs dealerships to not cover the issue under warranty or has not sufficiently informed their dealerships that this is a known manufacturing defect that should be covered.