1995 Chevrolet C3500 problems

Filed Oct 3, 2014 · Tires · 193,000 miles · GA

Tl* the contact owns a 1995 chevrolet c3500 equipped with achilles desert hawk a/p tires, size lt225/75r16. While driving 70 MPH, the vehicle suddenly shook violently. The vehicle was merged to the side of the road. After inspecting the vehicle, the contact found that the rear passenger side tire sidewall thread separated and a bubble had developed. The dealer advised that the tire production date (4511) was not included in the federal safety agency campaign number: 12t006000 (tires). The tire was replaced. The vehicle failure mileage was 193,000. The tire failure mileage was 100,000.

Filed Jul 18, 2014 · Fuel system · 30,000 miles · MI

Tl* the contact owns a 1995 chevrolet c3500. The contact stated that while driving approximately 70 MPH, vehicle stalled without warning. The failure recurred multiple times and the vehicle was restarted. The vehicle was taken to the dealer where it was diagnosed that the injection pump needed to be replaced. The vehicle was repaired but the failure recurred. The manufacturer was notified of the failure. The approximate failure mileage was 30,000. The VIN was unavailable.

Filed Aug 21, 2010 · Fuel system · 170,000 miles · AR

I have a 1995 3500 dully 6.5 turbo, eng f, serial # [xxx]. I bought it 4 years ago 170,000 miles. This truck is used for towing and hauling heavy loads in my business.. One month after I bought it and after several stalls (creating some close calls) and hard starting and after several attempts at fixing stalling, starting problem I learned of the pmd problem. I replacement and relocated pmd with stanadyne part # 34583, and relocated to firewall. After driving a few months started experiencing some hard starting and stalling again. This summer 2010 when temperatures reached the 90s it got really bad. Once dyeing on a right hand downhill curve that caused the truck to cross the center line forcing an on coming car to take evasive action to avoid a head on collision before I got it under control. I hope you never have to experience controlling a chevrolet 3500 dully without power going down a hill using extreme efforts to steer and stop. And I hope you never meet one in like condition heading in your direction. A very frightening experience. It stalled again on a curving uphill road with no shoulders with a trailer in tow, creating a hazard due to blind curves behind truck and having to let roll back down hill in order to get it off road and wait for it to cool down before it would restart. Replaced pmd again, this time with new part stanadyne # 35976 and relocating to behind front bumper. Now truck has started experiencing a hard start until cools down condition again. I am forced to continue using this truck against my better judgment because of economic conditions and my business. I have made my wife and other aware of this stalling, starting condition so that if I do have an accident they can have the proper investigation done. Can you imagine how many of these heavy loaded trucks are still coming down the road toward your families? They are ticking bombs waiting to kill someone information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Apr 26, 2005 · Acceleration, Body · 100,000 miles · WA

Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go. Replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.

Filed Aug 30, 2004 · Tires · AZ

Problems with steering on 1995 chevrolet c3500 crew cab pickup. *mr while traveling on the highway, the steering wheel started to vibrate then moved from side to side. The consumer felt that he was going to lose control of the vehicle. As the consumer slowed to stop, it was difficult to hold the steering wheel as it rocked back and forth from side to side. The front end of the vehicle obviously swayed back and forth as well. When the consumer was able to inspect the vehicle, he found that the driver's side front tire had ballooned along with sidewall and tread damage. *sc

Filed Jan 23, 2004 · Engine · 143,000 miles · OH

Both engine head gaskets cracked. As a result, water seeped into the engine which burned white smoke. *ak the consumer was told that this was a common problem in 95 diesel 6.5 engines between 130k miles and 140k miles. (this was a metal problem) *sc

Filed Feb 21, 2003 · Engine · IL

Tech-cor, inc. Is a research subsidiary of the allstate non-life holding co. We receive and analyze inquiries from allstate insured customers. One, a mr. Henry alwardt, of key largo, fl, told of a defect in the fuel injector pump circuit of thegeneral motors 6.8l diesel engine, which was optional equipment on chev. & gmc trucks from 1995-2000. According to mr. Alwardt, the electronic control module for the fuel injector would fail without warniong, causing a loss of steering & brake control, which could contribute to an accident. He said that he has had 4 of these pumps and the electronic modules replaced on his 1995 chev. Truck , under warranty, since he bought it new in 1995. He further stated that as a result of personal contacts with other owners, that gm dealers have been inundated wit similar failures and subsequent warranty repairs. He is concerned about the potential risk of injury to drivers, passengers and occupants of other vehicles, if one of these vehicles experiences this problem, during operation. He is urging the federal safety agency to undertake efforts to get gm to fix this problem, once and for all and to alert insurers that their insureds, which own or drive these vehicles face increased risks of injury.

Filed Nov 2, 2001 · Tires · TN

Side wall failure resulting in blowout.*ak (dot number: 8xor 65c 5 tiresize: 235/85r16)

Filed Sep 12, 2001 · Seats · TX

Driver's seat bracket is broken. He was told that these seats break all the time.*ak consumer stated it is the seat mounting bracket.

Filed Mar 6, 2001 · Visibility · TN

Windshield wipers become inoperable in rainy weather conditions due to problem with solder joints. Vehicle not included in recall number 98v1500001.