The contact owns a 2009 Chevrolet Cobalt. The contact stated that the vehicle was taken to an independent mechanic for repair; however, the mechanic found a fuel leak and an abnormal gasoline odor. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 17,311.
Chevrolet Cobalt fuel smell problems
602 of the 7,681 owner complaints about the Chevrolet Cobalt describe gas smell in the cabin, most of them for the 2006 model year.
- owner complaints
- 602
- worst model year
- 2006
- typical repair cost reported
- $700
- typical mileage
- 90,000
Is there a fix? There are 2 recalls for this area of the car. See below
By model year
Often reported together
Fuel pump 253Fuel leak 236Check engine light 18Fire or smoke 17Stalling 9Hesitation 9Fuel gauge 8Won't start 7
Trouble codes mentioned
P2270 1
What owners say
Fuel lines leak around fuel tank, causing a fuel smell around the vehicle and a major fire hazard
The contact’s wife owns a 2006 Chevrolet Cobalt. The contact stated there was an abnormal fuel odor inside the cabin of the vehicle. While exiting the vehicle, the contact became aware that there was an oil leak underneath the rear end of the vehicle, and the fuel odor was more evident. There were no warning lights illuminated. The vehicle was jerking while accelerating and while driving from being stationary. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Our daughter observed a significant puddle forming under her vehicle and noticed a strong smell of gasoline. She sent us a video, which clearly showed gasoline leaking from the driver-side rear area of the car. Due to the proximity of the fuel leak to the exhaust pipe, we had the car towed to a mechanic, as it was too dangerous to drive. The mechanic diagnosed the issue as a severely rusted-out fuel line that required immediate repair. At no point did the vehicle display any warning lights or alerts related to this issue. Alarmingly, our daughter had unknowingly driven the car while the leak was occurring, unaware of the serious fire risk this posed. We believe this is a serious safety hazard that could lead to a fire or explosion and strongly urge an investigation. This failure occurred without warning and could have resulted in a catastrophic outcome. We are fortunate this was caught in time, but others may not be as lucky.
The air bag never deployed I bought car in 2018 from original owner with car only having 33,000 miles on it and still under warranty til car had 100,000 miles and I hit a deer head on 2 months after getting car which bought in may of 2018 hit the deer in July 2018 . The deer was hit with the front passenger side it broke my headlight n messed my hood up and smashed in the grill little and my air bags never deployed I hit deer at 50 mph , after that had happened I took it in to Chevy dealership and had them look at car cause I told them I hit that deer and air bag never deployed and that my air bag light came on once in awhile and said service air bag . The dealership said they do that sometimes and did something to make light go off that was it my air vag light still comes on and says service air bag . Also ignition switch and fuel smell foul coming from car a lot and is as I speak . My reduce engine power light comes on a lot and have no power to gas pedal n car won’t stay running . I have try to get two recalls fixed back in 2-21 I was having problems with my car back then too special reach called me in Jan of 2021 and told me that there were two recalls on my car ignition switch and fuel module so I informed dealership when I took my car in That next month in feb 21 told them I was informed on 2 active recalls on my car . When they were done with my car later that day I asked them if they fixed the recalls they said no cause it was map sensor so I then made an appt to get recalls fixed when I got there for the recalls to be fixed one of the technicians told me it shows that they were done . I called Chevy and complained about the issue I just had and never had recalls fixed but they must of put it in computer they fixed them So I’ve been really upset that I been trying to get past recalls fixed that are on my car and I get run around and told there isn’t any I know about a past recall on shift selnoid low circuit too that was a past recal
The contact owns a 2009 Chevrolet Cobalt. The contact stated that while driving 55 MPH, the contact struck a deer. The air bags did not deploy. Additionally, while driving at slow speeds, the vehicle lost motive power. The contact restarted the vehicle. There was an abnormal sulfur and fuel odor detected. The air bag warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the MAP sensor needed to be reset. The mechanic reset the air bag light. The mechanic was unable to determine the cause of the air bag failure. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 33,000.
strong smell of fuel affraid to drive the igntion get stuck and locks so you cant turn the car on
Gas smell, no gas is visable on ground and vehicle is hard to start after sitting.
The contact owns a 2007 Chevrolet Cobalt. The contact stated that there was an abnormal fuel odor near the fuel tank. There was fuel leaking from the fuel cap. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the failure was related to the federal safety agency Campaign Number: 09V419000 (Fuel System, Gasoline). The manufacturer was not contacted. The failure mileage was approximately 105,000.
Fuel leak very strong gas smell
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
- Risk
- Fuel leakage in the presence of an ignition source may result in a fire.
- Remedy
- GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1‑800‑521‑7300.
Recall number 12V459000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- General motors is recalling certain model year 2006 chevrolet cobalt and saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 chevrolet cobalt, pontiac g5 and saturn ion vehicles originally sold in or currently registered in the states of arizona, california, florida, nevada and texas. The plastic supply or return port on the modular reservoir assembly may crack. If either of these ports develops a crack, fuel will leak from the area. If the crack becomes large enough, fuel may be observed dripping onto the ground and vehicle performance may be affected.
- Risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina, tennessee and texas and model year 2007 vehicles registered in: alabama, arkansas, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina and tennessee. The safety recall is expected to begin on or before february 4, 2010. Owners may contact chevrolet at 1‑800‑630‑2438, saturn at 1‑800‑972‑8876 and pontiac at 1‑800‑620‑7668 or at the owner center at www.gmownercenter.com.
Recall number 09V419000 · Recall details
Questions about the Chevrolet Cobalt fuel smell
Which Chevrolet Cobalt years have gas smell in the cabin problems?
The model years with the most reports are 2006 (185 complaints), 2007 (168 complaints) and 2009 (101 complaints).
How much does it cost to fix gas smell in the cabin on the Chevrolet Cobalt?
Owners who mentioned a price put the repair at about $700 (median of 41 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Chevrolet Cobalt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history