Chevrolet Corvette fuel gauge problems

Filed Dec 11, 2025 · Fuel system · NC

Fuel sending unit in gas tank behind the drivers side is leaking gas making it impossible to park the car in the garage. There is a great possibility of fire due to this issue. No, I have not taken it to the dealer as of today but I am going to schedule it. No. No.

Filed Jul 19, 2025 · Fuel system · TX

Fuel is leaking from the top of the driver side fuel sending unit. This is a know issue on these cars and should be fixed under a recall. This is a very dangerous issue.

Filed Jan 17, 2025 · Fuel system · AL

After refilling my car with gas, there was a strong fuel smell. As the fuel level dropped, the smell of gas went away. With this fuel smell there were strong vapors in my garage. I had to open the garage doors and let the garage air out before starting any of my vehicles I have in the garage. It got to the point I had to part the Corvette outside. I finally took it to a mechanic (Christain Brothers Automotive Huntsville Alabama), they found the fuel boost pump (driver's side) was cracked on top. I did not have the tools or capability to change the boost pump.

Filed Nov 17, 2023 · Fuel system · SC

Strong gas smell after filling gas tank. This is a known issue on these cars and although it can develop at any time they only warranty the problem for 10 years. This creates a fire hazard. The attached service bulletin was just released by GM today: Special Coverage Adjustment 15682 Primary Tank Module Flange Fuel and Vapor Leaks Reference Number: N150682 Release Date: July 2016 Condition Some 2007 to 2009 model year Cadillac XLR and 2007 to 2013 model year Chevrolet Corvette vehicles may have a condition where a fuel odor is detected, fuel droplets appear below the left-hand fuel tank with fuel gauge level above 1/2, or a malfunction indicator lamp illuminates due to a leak path in the left-hand fuel pump module flange. Special Coverage Adjustment This special coverage covers the condition described above for a period of 10 years or 120,000 miles (193,000 km), whichever occurs first, from the date the vehicle was originally placed in service, regardless of ownership. For vehicles covered by Vehicle Service Contracts, all eligible claims with repair orders on or after July 25, 2016, are covered by this special coverage and must be submitted using the labor operation codes provided with this bulletin. Claims with repair orders prior to July 25, 2016, must be submitted to the Service Contract provider. Correction Dealers are to replace the left hand fuel tank fuel pump module. The repairs will be made at no charge to the customer.

Filed Jun 30, 2023 · Fuel system · NV

I have a 2008 Chevrolet Corvette. The current mileage (as of July 1, 2023) is 26,200 miles. I have a strong odor of gas every time I fill the gas tank to above 1/2 the tank. This is a fairly common condition, as evidenced by the hundreds of the federal safety agency related complaints, and the Corvette forums. Two Chevrolet Dealerships told me I need a new Fuel Pump. The most recent diagnosis at a Dealership was on June 5, 2023. They want $3,500.00 to replace the fuel pump. Chevrolet realized there is a faulty part causing the fuel odor condition. Chevrolet issued a few Bulletins about it, and offered to make the repair at no cost if you met certain conditions. I’ve enclosed the Letter that was sent to me in 2016. As you can see, it’s about the odor of fuel and fuel droplets appearing below the left-hand fuel tank when the fuel gauge is above ½. The Letter contained an underlined sentence that directed me not to take the vehicle to the dealer unless I had the above-mentioned condition. Verbatim, it says: Do not take your vehicle to your Chevrolet dealer as a result of this letter unless you believe that your vehicle has the condition as described above. Being an honest person, I did not take my Corvette to the Dealer at that time because I did not detect an odor of gas at that time. Now, a few years later, I’m experiencing the described condition on my 2008 Corvette with mileage of 26, 200. If this condition surfaces around the time mileage reaches 26,000, I can only assume that my car’s mileage was too low back when the…letter to repair… was in effect My primary complaint is that Chevrolet should not have had "time constraints". The mileage limit is 120,000, but the time constraint is around 2018. I feel Chevrolet should repair this known problem at No Cost primarily due to the fact that the vehicle has less than 120,000 miles on it. I'm attaching 2 documents produced by Chevrolet. Thank you.

Filed Oct 26, 2022 · Fuel system · MA

Drivers side fuel tank/system leak Leaking fuel in this area can/will result in a catastrophic fire which could lead to injury or death The problem just occurred but is a common problem for this generation Z06 Corvette The odd thing is no warning light, check engine light or messages displayed, just the smell of fuel and 18 inch puddle on the floor beneath the drivers side fuel tank. The fuel level according to the gauge is 1/2 tank.

Filed Sep 10, 2022 · Fuel system · NC

I have owned this vehicle the last 6 years. When the amount of fuel is over one-half tank, there is an abnormal odor of fuel. When pulling into the garage, there's fuel leaking if over one-half tank. Once the engine is cut off the fuel leak ceases. To control the issue, I keep the fuel level at less than one-half tank. A certified local mechanic determined the fuel tank and crossover tube cross connector needed to be replaced. The vehicle has not been repaired. The mechanic stated the failure was related to the federal safety agency Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 26,500, when i bought the car. The mechanic stated that GM did issue a service bulletin around 2010 stating that GM would make repairs if the failure occurred within 10 years/100,000 miles. The local GM dealer will not repair my vehicle since it is out of time frame window. It's not fair to those who bought the car after the 10-year cutoff point. or do not drive these vehicles very much.

Filed May 22, 2022 · Fuel system · CA

Strong odor of gas fumes in driver compartment, seems to eminate from driver side. Plastic flange on top of fuel pump is cracked and spews gas to surrounding area. Smell is constant regardless of fuel level. GM has been aware of problem for years but has yet to issue recall. They did issue temporary special coverage adjustment not adequate for earlier model years where issue was systemic. Yes my car is available for inspection. This is health and safety issue which should warrant a recall. Fire hazard as well. No warning lamps appear on dash.

Filed May 21, 2022 · Fuel system · FL

I recently purchased a 2011 Chevy Corvette Grand Sport from a dealer in South Florida named Greico Chevrolet in Del Rey Beach. It was purchased used and as is from this dealer, but this appears to be a quite dangerous problem. I smell gasoline on the drivers side wheel well most of the time and sometimes the smell seeps through the car into the cabin. This is not from overfilling the tank (which I do not do anyway). I researched this issue and it appears to be an issue with two GM cars. See this statement and let me know if I have a claim: "GM Special coverage adjustment 15682 update July 2016 .Condition Some 2007 to 2009 model year Cadillac XLR and 2007 to 2013 model year Chevrolet Corvette vehicles may have a condition where a fuel odor is detected, fuel droplets appear below the left-hand fuel tank with fuel gauge level above 1/2, or a malfunction indicator lamp illuminates due to a leak path in the left-hand fuel pump module flange. Special Coverage Adjustment This special coverage covers the condition described above for a period of 10 years or 120,000 miles (193,000 km), whichever occurs first, from the date the vehicle was originally placed in service, regardless of ownership. For vehicles covered by Vehicle Service Contracts, all eligible claims with repair orders on or after July 25, 2016, are covered by this special coverage and must be submitted using the labor operation codes provided with this bulletin. Claims with repair orders prior to July 25, 2016, must be submitted to the Service Contract provider. Correction Dealers are to replace the left hand fuel tank fuel pump module. The repairs will be made at no charge"

Filed Dec 30, 2021 · Fuel system · AZ

We purchased the car on 12/17/21. I went to Costco on 12/18/21 to get gas. I had a preset amount of $50 to put into the car. When I got to $50 I shut the pump off myself, the tank was not full enough for it to shut off automatically. As I look down on the ground I saw a fluid running out from underneath the car and rolling along the ground. I touched it with my finger and discovered it was gasoline. I put the nozzle back into the holder and I checked underneath the car and saw it was dripping from the drivers side in the area just behind the drivers door. I pulled the car over to the side to inspect it further. By now the gas had stopped dripping. Since the exhaust pipe is right next to the fuel tank I was afraid of a fire or explosion. Had some fuel vapors but they dissipated shortly after. My gas gauge was registering full at this time. Since then I have not had any gasoline leaks and or vapors present. I have not put any more gas in the car since then. (I contacted the previous owner and he said in an email response, if you overfill there is a vent hole that gas will leak out of at the top of the filler neck. It happened once when I put like 20 gallons in it.) I did some research and found that there is a problem with the Corvette gas tanks and or the crossover tube. I think this is a dangerous situation, thinking that if that gas ignited, the car and my passenger could have caught fire and possibly ignited the Costco gas station with an explosion. (This car will be going into the repair shop in January to have a diagnostic smoke test done to determine where the leak and or leaks are coming from.) I hope the federal safety agency recognizes this as a very dangerous situation. All of this will be coming out of my own pocket for the repairs necessary to make this car safe to drive and not be dangerous to myself and family. I consider this a very serious dangerous situation.