2006 Chevrolet HHR: loss of power steering

Filed May 29, 2025 · Steering · OR

While replacing 3 motor mounts, engine oil pan,transmission oil pan, also CV axles, wheel bearings needed replaced. When i got my car back the power steering wasn't working. My mechanic said there was a recall for my year, make and model for the power steering assist. I haven't gotten this fixed yet due to lack of funds . I am filling this out to see if is recalled.

Filed Sep 12, 2024 · Steering · TX

The (EPS) system in my 2006 Chevy HHR has experienced multiple malfunctions. The power steering suddenly cuts out without warning while driving at both low and high speeds, making it extremely difficult to steer, especially when attempting to turn or change lanes. This failure happens intermittently, and the EPS motor is suspected to be the root cause. I have replaced fuses and relays, but the issue persists. This system is available for inspection upon request. This malfunction poses a severe risk to my safety and the safety of others. When the power steering fails, it becomes nearly impossible to turn the vehicle, which is especially hazardous during routine maneuvers such as lane changes or turns at intersections. The sudden loss of steering capability, especially at higher speeds, has left me vulnerable to potential collisions. Given the unpredictability of the issue, it could easily lead to a fatal accident if it occurs while navigating tight curves or avoiding road hazards. The problem has been confirmed by a certified mechanic, who validated that the power steering system is malfunctioning and recognized the danger it poses. The mechanic advised that this issue is prevalent in vehicles of this make and model & suggested filing a formal complaint to prompt further investigation by the manufacturer. To date, the veh has been thoroughly examined by an independent service center. They confirmed the malfunction of the EPS system but were unable to fully resolve the issue through standard repairs like fuse or relay replacements. A "Power Steering" message illuminates on the dashboard. A few seconds later, the power steering system fails completely, leaving the vehicle almost impossible to control. These warnings have been intermittent, but their frequency has increased over time. The first occurrence was about a year ago, Given the ongoing danger and prevalence of this issue among other 2006 Chevy HHR owners, I am requesting that GM initiate a formal recall.

Filed Mar 25, 2024 · Steering · 146,000 miles · NV

The contact owns a 2006 Chevrolet HHR. The contact stated that the vehicle was parked with the key locked inside. The locksmith assisted the contact with entering the vehicle. The contact stated that it was difficult to pull out of the parking space due to a loss of power steering functionality. The vehicle was driven to a local mechanic but was not repaired due to the cost. The manufacturer was not made aware of the failure. The approximate failure mileage was 146,000.

Filed Dec 5, 2023 · Steering · KY

The power steering went out. Very hard and unsafe to drive.

Filed Oct 23, 2020 · Steering · 40,000 miles · PR

Tl* the contact owns a 2006 chevrolet hhr. The contact stated that while driving 30 MPH, the steering wheel became difficult to turn. The power steering assist warning light was illuminated. The vehicle was turned off, restarted and the vehicle operated as designed. The failure recurred on several occasions and persisted. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000. Invalid VIN.

Filed Jul 8, 2020 · Steering · 138,000 miles · IA

Tl* the contact owns a 2006 chevrolet hhr. The contact stated that while driving approximately 65 MPH, the vehicle loss power steering assist and became difficult to steer. The vehicle was not diagnosed nor repaired. The vehicle was taken to an independent mechanic who replaced several fuses however, the failure persisted. Deery brothers inc located at 200 s. Gear ave, west burlington, ia 52655, and the manufacturer were notified of the failure. The failure mileage was 138,000.

Filed Apr 1, 2019 · Steering · 150,000 miles · TX

Power testing motor can fail randomly and at any time causing the car to revert to manual steering control and increasing chances of a crash. Defective is the power steering motor controller and or the torque angle sensor! Wife was mid-turn when power steering failed and she almost ran into a tree. 16 year old daughter was driving and veered into oncoming traffic when power steering motor failed while she wasn't in a turn.

Filed Jan 20, 2019 · Steering · 85,000 miles · NM

The power steering keeps "clicking off" seems like an electrical issue but there are no fuses blown. If I turn the car off the power steering will reset but as soon as I turn it back on the power steering will turn off again. It quit for awhile but now its back in full force. I basically have no power steering now.

Filed Aug 23, 2018 · Steering · 113,000 miles · IN

Every couple weeks while driving my car, there will be a ding sound with a message indicating power steering failure. I have to pull over and keep turning it on and off. Eventually it seems to reset itself and work again. I cannot steer it at all when it fails and is at times hard to get off the road in time before it locks up. It is very dangerous since I have to drive on a highway to get to work.

Filed Aug 9, 2018 · Steering · 137,000 miles · VA

My 2006 hhr lost power steering. The light came on and it took all I had to steer it. Everytime I cut it all off and crank it back up the light will go off and I can drive it for about a minute to 5 minutes usually in the light saying power steering will come on and the steering issue will occur again. I love my hhr and this is my first chevrolet product but I really think there should be a recall due to the fact that after much much research I have found that the hhr as well as other chevrolet vehicles have hundreds to thousands of people with the same exact complaint. The power steering light would come on and they would lose all power steering. This should not be a cost that us who have purchased and put our trust of safety into chevrolet to have to bare. This can be extremely dangerous and can actually lead to vehicle fatalities due to the power steering going out. Chevrolet should be responsible for the repairs of the power steering due to it being a known fact based on very much research and complaints from so many owners. This fact shows and proves that it is the fault of the way the car was designed or built or faulty parts used by chevrolet/gm. Please consider the danger that this fault can cause to owners and do a recall to have these issues repaired so that it doesn't end up causing more damage or taking a life because someone loses control of there chevrolet due to faulty parts. Thank you, [xxx] from halifax virginia information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Dec 31, 2017 · Steering · TX

Power steering comes up in messsge center over 10 MPH. Steering is very hard. When you turn the motor off and restart it resets. Over 10 MPH power steering comes up again. Brought it to local dealership and diagnostic test done but test comes up with no problems. Gm recalled only the 2010 hhr for this problem, not the other year models. I purchased my 2006 hhr new in december 2005.

Filed Aug 6, 2017 · Steering · 169,207 miles · IL

Power steering went out. Message indicated power steering on dash. I paid dealer$1000 to replace steering column.