The contact owns a 2009 Chevrolet HHR. The contact stated that while the vehicle was parked, and while driving the vehicle, there was a strong fuel odor coming from the vehicle. Additionally, the contact noticed that the vehicle was experiencing excessive fuel consumption. The contact also noticed that fuel had leaked onto the ground. The contact stated that upon inspecting the vehicle, the contact noticed that fuel was leaking from the driver's side rear wheel well, where the fuel tank was located. The contact related the failure the federal safety agency Action Number:Â PE20011(Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.
2009 Chevrolet HHR: gas smell in the cabin
26 of the 508 complaints about the 2009 Chevrolet HHR describe gas smell in the cabin.
- owner complaints
- 26
- of this car's complaints
- 5%
- typical mileage
- 111,800
- recalls
- 0
Gas smell in the cabin by model year
What owners say
The contact owns a 2009 Chevrolet HHR. The contact while driving at an undisclosed speed, noticed a strong fuel odor. The contact stated that upon parking and exiting the vehicle, there was fire underneath the rear driver's side, where the fuel tank was located. The contact was able to extinguish the fire with a fire extinguisher. There was no injury sustained. The contact then noticed a trail of fuel on the floor. The contact became aware that fuel had leaked while driving. The vehicle was towed to an independent mechanic, where it was diagnosed that the fuel line was corroded and needed to be replaced due to a wrong design. The contact stated that the fuel line was designed over the muffler, which caused water intrusion and corrosion. The vehicle was then towed to the dealer, where the fuel line was replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 28,000.
The contact owns a 2009 Chevrolet HHR. The contact stated upon parking and exiting the vehicle, she smelled a strong gasoline odor on the driver's side of the vehicle. There was no warning light illuminated. The contact stated that the failure persisted. The vehicle was taken to the dealer where it was diagnosed that the fuel line needed to be replaced. However, the parts were not available. The vehicle was not repaired. The contact referenced the federal safety agency Action Number: PE20011. The manufacturer was not notified of the failure. The failure mileage was approximately 111,800.
Fuel Smell / Leak. Car developed a gas smell while driving and after getting out of the car a small amount of gas poured out in front of the passenger door on the drivers side. I was told my gas line has rusted through and will need to be replaced.
Gas/Fuel line leaking at LR door area, not noticed until gas smell. Poor design, wrapping fuel line in insulation near exhaust collects salt and water causing lines to rust, dripping raw gas. A safety hazard, a spark or cigarette butt could have caused a major fire, not only to the vehicle but surrounding vehicles and or property. A Chevrolet HHR is the same platform as a Chevrolet Cobalt and a Saturn Ion, all have the same safety-related issue. I contacted a local Chevrolet dealer they were unable to repair for 4 days, and would not cover needed repairs under a recall or warranty. Imagine leaking gas puddle under the vehicle in a parking lot with children and people walking nearby, fireworks! A recall is desperately needed ASAP!
I have a 2009 Chevy HHR with only 62k miles. Recently while driving out of town there was a strong gas odor in the car all the way home. We had also parked the car in a relatives attached garage leaving a gas odor. When parked at home a puddle of gasoline formed under the car. The fuel leak was from corroded fuel lines on the driver side in front of the rear tire. Upon inspection both supply and return fuel lines were corroded in an approximate 5 foot span. This fuel leak put us at risk of fire and also the entire garage/house where the car was parked. I contacted General Motors about the problem and was told to take it to a dealer for service. I asked General Motors for assistance in the cost and they said it would require a diagnostic by the dealership. I contacted the dealership and was told I would get no assistance per General Motors PET equation.
The contact owns a 2009 Chevrolet HHR. The contact noticed that there was a leak coming from the rear driver’s side of the vehicle. Additionally, there was a fuel odor coming from the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that there was a rusted fuel line. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 103,900.
Fuel line corrosion causing leaking of gas that puddles on the ground below. The vehicle is unsafe to drive, or even leave parked in a driveway due to a gas leak!! The smell of gas is very strong due to an active leak under the driverside rear door, no warnings, just smell, visual of drips, and fuel pooled under the car. The car was parked. There is an open investigation started in 2020...how long will it take to recall these manufacturers' defect???
The contact owns a 2009 Chevrolet HHR. The contact stated that while attempting to start the vehicle, the vehicle would not immediately start. The contact later noticed a fuel odor inside the vehicle. The contact discovered a fuel leak coming from the rear driver’s side of the vehicle. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 125,000.
I own a 2009 chevrolet hhr. When I started the vehicle, a fuel odor was detected. I saw gas leaking from near the rear driver's side tire onto the driveway. Fuel line has rusted through near the hot muffler. Very dangerous condition.
Tl* the contact owns a 2009 chevrolet hhr. The contact stated that when she started the vehicle, a fuel odor was detected. The contact later saw gas leaking from near the rear driver's side tire onto her driveway. The vehicle was not diagnosed nor repaired. The dealer and manufacturer were not made aware of the failure. The failure mileage was 115,000.
Puddle of fuel near rear left wheel well noticed when parked. Smells of fuel. Residue can be seen on and around polymer block where fuel lines meet.
Service bulletins that may apply
Related recalls
No recalls on record for this model year.
Questions about the 2009 Chevrolet HHR fuel smell
Is gas smell in the cabin a common problem on the 2009 Chevrolet HHR?
26 of 508 owner complaints about the 2009 Chevrolet HHR (5%) mention gas smell in the cabin. The model year with the most reports is 2008.
Is there a recall or service bulletin for this on the 2009 Chevrolet HHR?
There are 0 recalls and 2 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2009 Chevrolet HHR
Power steering loss 55Airbag light 47Fuel leak 42Door locks 17Stalling 16Check engine light 15Loss of power 15Headlights 12No deployment 9Seat belt 9Steering lock-up 9Won't start 9Engine failure 8Fuel pump 7ABS 6Adaptive cruise 6Jerking 6Brake failure 5Fire or smoke 5Wipers 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 Chevrolet HHR?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history